Prius (2004-09) :: Engine Coolant Overflow Bottle Almost Empty
Jun 10, 2010
Doing the 48,000 km service yesterday, and when checking everything noticed the engine coolant overflow bottle was almost empty. MAJOR PROBLEM!
There is no sign of leaking, so I presume it evaporated or it was never filled to the full mark from the factory. Man, that level is hard to check. It's dark down there! I may mark the passenger side end of the overflow bottle. Much easier to see the level there.
Coolant loss, presumably from evaporation? This was after 3 years of operation/48,000 km or 30,000 mi.
View 4 Replies
Advertisement
Have a 2007 Isuzu I290 four cylinder with 5 speed manual transmission with 116000 miles on it. have used Mobile One oil from day one and replace it and the filter about every 8000 miles. Twice in the last 20,000 miles the coolant overflow tank has been empty and an antifreeze puddle on the ground. Both times it was just before an oil change so the truck had gone roughly 8K and the engine oil was down about a half quart to a quart. Engine temperature gauge stayed normal, midway on the gauge, or very slightly above normal, never got hot. Can’t find a leak in the coolant overflow tank or hoses. thought it might be tied to the low oil so was going to check it on a more regular basis and keep it topped up. other than the coolant puddle twice, nothing leaks on it and thus far has been a nice, reliable, maintenance free truck.
View 12 Replies
A bit over a week ago, I posted about a major coolant "spew" in my shed.
View 5 Replies
I recently bought a 2002 prius with 65000 mi. I have been driving it for a few weeks and everything seems to be working good. I noticed there was no engine coolant in the reserve bottle and added a quart to bring it to the full line. The next day I noticed leaking coolant, but it is on the drivers side where I believe only the inverter components are. I really don't know though. The engine coolant level has dropped down. Does the engine coolant flow over on the drivers side? I cant tell exactly where the leak is.
View 1 Replies
I've got an 1989 Celica St that as it warms up it pushes water out through the overflow bottle. The car seems to be cooling ok as long as I don't get stuck in traffic. My daily commute is approximately 40 miles and if I keep refilling the radiator the car stays relatively cool. However, if I do not stop and let the car cool off between commuting to and from work the car loses enough coolant that eventually it starts to overheat and I need to pull over and refill the radiator once again. I have replaced the radiator cooling fan already and am going to flush the radiator this afternoon. I am thinking that the head gasket might be leaking and causing my problems. What to try next b4 I tear the head off? BTW the motor is a 2.0 L 16 valve. Hoping I can fix this problem w/o a head gasket.
View 14 Replies
Back in February, received a light and discovered that the inverter coolant reservoir was empty. I refilled the reservoir and cleared the code. Today, only 3 months later, the same thing happened. I don't see any wet hoses, puddles, or obvious signs of leakage. Where all my coolant is going? What steps should I use to properly troubleshoot...
View 8 Replies
While servicing the bosses 121k 6.0, I noticed the coolant resevoir empty. It took 1 1/2 gallons to bring to proper level. Returning under truck to install drain plug, I noticed coolant coming from rear of the engine(right side). And of course Ford has changed the cooling system cap, so I wasn't able to pressure test it to pinpoint the leak. Started the engine and seen coolant coming from the left rear as well. I've been reading here to see what others have been seeing, (EGR cooler, head gaskets). With all the heat shields,not much room to look.
After work I did go and buy the adapter to test the cooling system. With any luck I will be able to see leak better.
View 14 Replies
I know my car has a leak. Blok check test confirmed. Symptoms:
Car overheats after driving for awhile but only intermittently
Overflow is filled almost to top after driving and has wet sides.
Coolant fails to return to engine.
Here is the interesting part. I removed the lid for over flow and took out the hose and exposed it to air. Then I took off rad cap. Instant suction and collapse of both lower and upper hoses. Why did this occur? Bad rad cap and or/ blockage?
View 4 Replies
I currently have summer washer fluid in my 2003 Toyota Echo's windshield washer fluid tank. I need to replace this with winter washer fluid within the next few days before the temperature goes below freezing.
When I pop open the hood, I see that the bottle is located on the left hand side of the engine bay. The bottle has a black cap with a picture of a fountain (wiper spray).
I have no experience working on the mechanics of a car. However, I would like to know the easiest way of replacing my summer wiper fluid with winter wiper fluid. The tank is currently full with the summer washer fluid.
a) How do I go about emptying the bottle completely without removing it?
b) If I need to remove the bottle and then empty it completely, how do I do this and what tools do I need?
View 6 Replies
I have a 2002 Ford Explorer and I am still trying to figure out why the coolant will overflow in the radiator reserve tank. I put in a new thermostat and a new cap to the overflow tank. When the tank is cold, sat over night, I put in new anti-freeze to the cold coolant line. Then I start up the explorer and let it run for a while. The temp gauge goes up, then drops a tad and cold air comes out of the vents.
After I rev up the engine, I see the coolant level starts to rise in the overflow tank, then it goes to the top and starts to leak out. This takes a while being the thermostat has not kicked in to suck the fluid in. Before this happens, the heater core lines are luke warm. After the tank overflows, the remaining gets sucked into the engine and I get nice warm heat. What causes this. I had the test done to see if the head gasket is bad. The test was negative.
View 9 Replies
1993 ranger, 3.0 V6 203,000 miles. As engine warms up coolant in blown into over flow and spills out. At that point system is low and truck runs hotter than norman, 3/4 way across gage. What would be causing overflow to overfill from engine. Could it be a bad rad. cap? Just replaced head gaskets at 200,000 miles. Truck runs good. No oil in water, no sign of visible leakes other than overflow tank overfilling and loosing coolant.
View 10 Replies
I have an 04 gti 1.8t and last night it started over heating. I pulled over and checked the coolant and the oil but everything looked good. I let it cool down and drove it home. When I popped the hood there was a little steam coming from the coolant overflow tank but I saw no leaking. I decided to vent the pressure off the system and then I got a little drip on the passenger side close to where the inter cooler is. I can't pinpoint the leak though.
View 4 Replies
I just noticed this morning that the coolant tank (close to radiator) is empty. The other coolant tank level is normal. Big surprise! I thought they are connected, and coolant can flow between them.
View 5 Replies
I have an 1979 F150, 351 V8, only 104,000 miles. Been driving it sporadically, had it serviced over the years, been driving it until recently. At least three new batteries have drained to dead in short amounts of time. No one seems to be able to pinpoint the trouble. It has two gas tanks--the original tank overflows out the filler cap in hot weather, even when mostly empty. I must find this trouble. Again--it's been seen by several repair shops, but no one has fixed the problem.
View 1 Replies
I had to drive my wife to SEATAC this morning. I would normally drive my car (Camry), but my trunk is a mess with muddy tire chains and the back seat is a mess with muddy dog fur, etc.
View 2 Replies
1,500 miles ago my car had it's 30k service. Today, i got "CHECK...". At home this evening i checked the inverter coolant reservoir, it was empty. I've added 1L of de-ionised water (which got it to full, and i see turbulence in the fluid) until i can get the correct fluid.
View 13 Replies
Last night on a 400 mile trip the wheelwell plastic fell loose onto the wheel and was destroyed. There was some kind of white bottle that attached to it that got ruined also. What it may have been? The car is 200 miles from home and me or i could be more specific.
View 3 Replies
My truck has a 6 o powerstroke. I noticed some coolant loss, which I've been monitoring since I had the truck studded 2 years ago. Today I was looking around trying to find a cause of the coolant loss and I noticed some crusty orange residue on a hose that runs under the coolant reservoir. The hose seems to go behind the valve covers along the firewall to the passenger side through a steel line, and then go in a loop back to itself?
I'm guessing it's for the heater core, but I didn't see where it actually goes into the heater core, or anything else for that matter. It is a molded hose that has one of those crimped transitions into the steel line, so I'm not sure if patching it is an option or if I should look at replacing the whole piece. I'm guessing it's going to be expensive. From the fact that it never failed before, I'm thinking it wasn't originally routed with it touching the valve cover and was just something that happened after having the body off during the stud install.
View 7 Replies
I have coolant leaking from under my degas bottle. There was a spot on the driveway this morning and upon investigation, I saw a drip hanging from the bottom of the degas. No liquid on top at all. Where this is coming from? Bottom hose?
Also, the boot that connects the tube (right side while looking at front of truck) to the elbow that goes into the intake is leaking oil and making a mess. Whats the best way to fix? Remove boot, clean up, and put back on? Or replace boot? If replace, where can I get that boot?
View 12 Replies
The last time I got gas the shut off switch on the gas hose did not shut off. I was standing there and I shut it off immediately. There was some overflow. I have gone 170 miles since this fill up and the fuel gauge has not budged from totally full. I bought the car new and normally it would be down about half a tank by now.
I disconnected the 12 v battery. After reconnecting it the fuel gauge still reads totally full. I know about the problems with the gen 2 fuel tank- bladder, fuel pump and other components inside the tank.
I wouldn't be excited about getting a new fuel tank with only 43k miles.
View 3 Replies
Aside from other issues I am having with my prius, this was one lurking. I originally thought the prius was "using" the coolant insufficiently. Anyhow, I bought this prius from a private dealer....(know how that goes)......
View 15 Replies
