Prius (2004-09) :: Changed Spark Plugs But Gaps Were Little Out Of Range
Feb 21, 2013
Just got done changing the plugs on my new to me 2008 Prius. They were in there a little tight and the crunching noise they make at first is a little disconcerting, but I'm thinking it has something to do with the coating NGK puts on their plugs.
Anyway, everything went smooth and I took my time and used tips I read about here. I've worked on cars since I was 16 and have rebuilt motors and completely restored a 1956 Chevy, but this Prius is a different animal. I think in the end though we are going to be friends...
Here are some pics of the old plugs. The gaps were a little out of range, and there was some wear, but 148k on spark plugs and the car still runs good?
View 19 Replies
Advertisement
I changed my spark plugs now I got a miss and rough idle .#2 and 6 seem to be the ones that miss the idle don't change when I unplug the coil , I take coil off and put it next to the motor it sparks ! I put everything 3 plugs and got about 200 miles on them and 3 out of 8 had melt downs and left me on the side of the hwy. I got autolights in it now but it got a miss and rough idle ! Did I not do something right ?
View 7 Replies
I have rough idle problem after changing spark plugs, fuel filter and battery. There was no rough idle problem before this work was done. What could be wrong. Once the speed is above 20 mph it seem to run fine but at stops it vibrates and seem like it may stall!
View 6 Replies
I don't have a torque wrench. I just have a spark plug wrench. I changed my own spark plugs. I don't like taking them out and putting them back in. I'm not sure if I got the torque right. What should I do?
View 1 Replies
As far as I know, my Passat has never had any other spark plugs other than OEM. I could also swear that those OEM plugs always had 3 grounds. My gas mileage historically averages about 27MPG in a mixed city/highway environment.
Recently, my spark plugs were replaced and now my gas mileage has dropped to 24MPG. I had a similar problem once with my previous car (1998 Jetta GLI) and it was due to going from a three ground spark plug to a single ground plug. Putting in three ground spark plugs instantly restored the gas mileage to previous levels.
I've read repeatedly that the NKG PFR6Q is the OEM plug but it only has a single ground. I realize that my memory could be faulty, but this is driving me nuts.
Alas I can't be sure what was there before versus what's there now, but I know my previous mechanic was a stickler for OEM parts. Would switching from a multi-ground to a single-ground cause a 10%+ drop in mileage?
View 3 Replies
Here's the run down:
-bought 6 months ago for cheap because it wouldn't pass smog test
-changed Purge Control Valve (PCV) and it passed
-filled with gas, heard popping noises like a backfire, and coded it read the same "Bank 1 and Bank 2 running lean, like it did before the PCV and then also "Cylinder 3 Misfire" appeared.
-At this point the car started running rough, at idle, and through acceleration...sputtering uphill, and when climbing through the gears.
-Changed the plugs & wires
-NOW, it's cylinder 5 misfiring, and not nearly as bad. It's idling and running rough, acceleration has somewhat come back, but it's definitely not 100%.
Should I start with the PCV again, since it's not starting after I fill the tank, and climbing gears slow? Is there anything else I should be checking?
View 2 Replies
So in the middle of a road trip 9 days ago my check engine light came on. I was 2 hours into an 8 hour round trip day trip. I was close to a Toyota dealer so I went there for a diagnosis. They said my MAF bank 1 sensor 1 needed replacing but they didn't have the part so couldn't do the fix but I'd be okay to complete my trip. They collected their $100 and sent me on my way with no warning lights on.
30 minutes later the check engine returns and I'm unable to accelerate. I stop the car for a bit and then am able to continue my trip. I have one other incident where when I was traveling at a low speed, I lost all power. I was able to drive home 4 hours with the check engine light on but no further issues with the exception that I got less than 20 miles a gallon for the trip.
Took my car to a local Toyota dealer. They independently diagnosed that the same sensor needed replacing. They also told me that my spark plugs were shot. According to the service rep, they looked like they were from a car with over 100,000 miles.
Is this possible given the description above from the first time my check engine light came on?
View 19 Replies
I got the plugs for my '06. I hope to put them in in a day or 2. My question is: is it necessary to disconnect the 12v battery to do this? I've changed plugs in other cars without doing so.
View 6 Replies
My husband just replaced the spark plugs in my 2005 prius with 174,000 miles (also replaced the right headlamp bulb). When I started the car, the PROBLEM check engine light Hybrid Warning Light came on.
Owner's manual says take it to the Toyota dealer. The dealer is 50 miles away. Is it safe to drive it the 50 miles? It drove okay up and down my driveway.
View 4 Replies
Right now I am seeing roughly 41 MPG and that is after changing the spark plugs with brand new NGK Iridium's, Air intake filter and did an oil change since it was due for one. I have driven the car roughly 2,500 miles since all of this stuff was done and it just seemed to continue to drop to the 41 MPG mark.
What I have noticed though is that when the motor turns off it shudders and the when it restarts while the car is in park the car will roll back and forth slightly. I have also noticed that the car seems to struggle to get up to the posted speed while climbing an incline and also while the car idles in park or at a complete stop there seems to be a bit of a miss fire. Could that be caused by a bad coil? Because I have tried everything short of taking it to the dealer which I really do not want to do again and be told there is nothing wrong with it when I know there is.
View 19 Replies
I am changing my own spark plugs for the first time. I have a spark plug wrench, dielectric grease, anti-seize compound etc.
I have a Haynes manual for my 2002 Toyota Corolla. The book was written before Irridium plugs were used. Should I tighten the spark plugs to the same torque specifications as regular plugs? The book says 158 inch pounds. How do I know I have tightened them to the right amount?
How do I avoid cross threading the spark plugs? What happens if you cross thread the spark plugs (assuming the car seems to be running fine)? Would I need a new engine or expensive repair when it is time to replace the spark plugs again?
View 19 Replies
Bought my car three weeks ago. I was looking around under the hood and noticed that the color of the connector on the spark plugs is different. Two are grey and two are black, in alternating order. What's up with that?
View 5 Replies
04 intrepid cranks but won't start no spark at the plugs 2.7v6 could it be the pcm...
View 2 Replies
My 2004 honda civic hybrid has 8 spark plugs. The ones in the back of the motor look like they get much hotter and both times I have replaced them, all four in the back were really really loose.
View 2 Replies
Sstripped threads using an impact to remove the plugs?
View 4 Replies
My 2010 prius had been giving low mpg since the last three months. It has now 145K miles.when I bought it a year ago, it had 134K on it. I haven't changed the spark plugs, do they have any effect on low mpg? My mpg is about 39 now,but was 42_45 before.
What are the symptoms for the spark plugs to be changed?
View 1 Replies
Ok , i have a 2004 Pontiac Grand Prix GT V6 GM 3.8, my car didnt have any misfires until after i changed my Lower Intake Manifold Gaskets. After changing the gaskets and putting everything back together. The car ran fine. The next day i took it an hour and 30 min away, while driving there it started misfiring and shaking,rough idle at an hour into the trip. The check engine light went to blinking. The Next day i drove it all the way back home in the condition. Put code scanner to it, and received P0303 "Cylinder 3 Misfire":
So i automatically assumed it was the coil pack because i just installed new wires and plugs a week before changing Lower Intake manifold Gasket. Bought new coil pack. Still getting rough idle and P0303 code. So i decided to take a look at Cylinder 3 Spark plug and it was dry black, carbon fouled:
So went and bought new spark plug, installed it, started car and still rough idle and misfiring. Took the new spark plug out and it had been FOULED also ( DRY BLACK AGAIN). So i was told to switch a coil pack around. I did it and the started car, took away some of the rough idle, car actually wasn't misfring or shaking, would run smooth for about 5-8 seconds then start misfiring (Didn't that until i switch coil packs around).
Next Decided to pull out the rest of the plugs from the back and all of them were WET with GAS!! and 2 Spark plugs are just dry fouled!! (Cylinder 3, Cylinder 1). If I can figure this out i will fully have my car back to running correctly.
View 12 Replies
My '07 had the check engine come in the other day, engine misfire. I took it to the dealer hoping it was a coil, due to the 100,000 mi warranty from Ford I was hoping would be covered. Sadly, and of course, all coils tested fine, turns out 2 plugs were bad. They replaced all 8 plugs, plus a plug boot. Not one plug broke (truck had 80k on it) so no extra cost there. So much more, but peace of mind that all the plugs are new one piece plugs is great. He recommended that they should be replaced every 60k to avoid any issues.
View 7 Replies
I am a newbie here, and also a new owner of a 2006 F150 XLT 4X4 with the 5.4 engine. It has 68K miles on it and looks to have been well cared for. I have a couple questions. First the truck is runnig great, no problems. I have read the threads regarding the spark plug issues and was looking for an opinion about changing them. Should I wait until I have problems, or due to the age of the truck, should I go ahead and attempt it soon? Also, I would like to find a used cap for the bed. I have the 6.5 bed, and wondered what range of years would work with my truck.
View 3 Replies
2004, 4L, sohc - Is there any issues or problems changing spark plugs?
View 4 Replies
My 2004 honda accord will not start, there is no power to the spark plugs or to the coils.
View 3 Replies
