Prius (2004-09) :: 2005 - New Battery Installed Now Car Will Not Start
Apr 3, 2014
My mechanic installed a new Hybrid battery in my 2005 Pruis using the repair manual and a video that showed him how to do it. He also replaced the harness and the ECU battery. When he tries to start the car all of the lights light up on the dash but no ready light on the start button and the car will not start. The instructions did not say anything about this issue so he is lost! He thinks the smart key and the ECU have to be synced in some way but doesn't know how to do it.
View 6 Replies
Advertisement
I purchased a new 12 volt battery from Toyota and installed in my 2009 Prius. My car wouldn't start. So, next I tried to jumpstart it. I pressed the Power button (the light was GREEN) but it wouldn't start. I pressed the Power button again (The light was AMBER) and the hybrid drive engaged and the CHECK ENGINE light came on; however, the engine didn't start, the dashboard didn't light up and the READY indicator did not appear.
Next, I grabbed the Owner's Manual and went through the Troubleshooting sequence. Engine still wouldn't start.
View 19 Replies
My mechanic installed a new Hybrid battery in my 2005 Pruis using the repair manual and a video that showed him how to do it. He also replaced the harness and the ECU battery. When he tries to start the car all of the lights light up on the dash but no ready light on the start button and the car will not start. The instructions did not say anything about this issue so he is lost! He thinks the smart key and the ECU have to be synced in some way but doesn't know how to do it. (none of the books covered this.
View 1 Replies
I just bought 05 prius from a dealer I don't know the history was told all it needed was a hybrid battery.
Now I have a 05 that I drive with known good parts so I pulled my hybrid battery and installed it in the new car the monitor showed engine charging inverter then going to the battery. However the bars on the battery graph start dropping. only code is a engine code 2102.
I also noticed the old A/C condenser in the back.
View 19 Replies
My 2005 prius will not start. We had some body work done to it after a deer ran into me. They did a small amount of welding and had disconnected both batteries. Now the car will not start. It can be put in auxiliary mode but if you try to start it with your foot on the brake, it flashes some lights for a few seconds and then goes dead. Is the hybrid battery too low to start the car? It was pretty low. before the batteries were disconnected. Or did they possibly do something wrong when they disconnected the hybrid battery? Final question would be do they have to do some reprogramming after disconnecting the hybrid battery?
View 11 Replies
I decided to install a new Optima yellow top battery because I performed the battery check and found the voltage low and therefore believed my 2008 was still running on the original OEM 12v battery. Much to my surprise I found a non-OEM battery installed and the vent tube elbow missing!
View 10 Replies
Just put in a new 12v battery but when I try to connect the ground cable, I'm getting sparks, indicating a current draw. And the horn starts blowing nonstop.
View 6 Replies
My car had a new bumper installed, and now they can't get it to start. When you hit the button to start, the red "immobilizer" anti-theft light blinks for a moment like the key is not in the car.
This is true even if the key is inserted into the dash. The remote key still can open and close/lock the doors just fine, so this is strange.
They did mention that they had to recharge the battery for some reason. I don't know why the battery had died for them, but it is charged now. (Headlights, etc work fine).
View 6 Replies
Over last two years have replaced a few alternators and (3?) batteries in my 2000 Solara SLE with 150,000 miles. However, In last three months I have had three additional alternators. Car wouldn't start, had it towed, and a mechanic put in new alternator and battery. Happens again, car won't start (now own a jump charger!), and the same mechanic puts in new alternator. Happens again and Mechanic #1 says he has checked it and its fine. I then go to my regular mechanic... Says its the alternator which is bad (when you put the AC and Radio on, it appears to charge for a while, but if you leave it running it will stop charging and then after a while it will go to overcharging and undercharging. I noticed when driving on highway my lights will brighten and dim).
He sends me back to the first mechanic because the alternator is bad. They put in a new alternator. I take it back to Mechanic #2 my regular mechanic to test it so I don't get stuck. He says its still doing the same thing. I tell him I will pay to have him put in the new alternator and he can own the warranty.... He sends me to a car electrical specialist. After having my car for 3 days the car electrical specialist just called and said in 30 years he has never given up but he has now. May or may not be related: My check engine light was coming on and I had mechanic put in new oxygen sensors. I also have intermittant traction light and ABS light coming on and the check engine light will sometimes come on too. My dash board feels like Christmas...
View 7 Replies
So my 2003 VW Passat will not start. I last drove it a few days ago, and it has been sitting inside a nice warm garage. The battery was replaced a few months ago. The car doesn't "turn over" but just has a steady sound when you try to start it. It's not a clicking sound like I had 6 months ago with it. I attached a link to the audio file of me trying to start it today. There are no warning lights per se coming on only the typical ones coming up when the ignition key is turned on. The lights and interior lamps come on indicating there seems to be power but nothing else. The plugs were cleaned a few months ago as well. Could it be alternator? I could try jumping it but the sound it makes leads me to believe there is plenty of juice.
[URL] .....
View 16 Replies
I replaced the battery because I was getting the red triangle with no screen powerup. This is a slight improvement but I'm stuck as to what the "Problem" indicator on the MFD is about.
I've checked the battery in maintenance mode, reading 12.6V.
View 5 Replies
Install new HV Battery in 2005 and now I have no dash display lights.
View 2 Replies
I have a 2005 Prius that I purchased in 2010 as the second owner. When I first got it, I would average 50-65 MPG depending on city vs. interstate (per trip computer). After about a year, I was usually in the 40's. However, in the past 6 months or so, the MPG has dipped drastically. Based on the trip computer, I average about 30 MPG on the interstate and 15-20 MPG in the city. I have read that often times, a dip in MPG signals a need to change the 12V. I tested the 12V, and it's usually around 12.4V after sitting unused for 12+ hours.
More info: -The poor MPG is consistent whether it's 95, 65, or 35 degrees outside.
-Flat terrain (Washington, DC)
-Usually shorter trips of about 20-25 minutes.
-75% city, 25% highway. Highway driving is pretty smooth, little traffic, average of 55 MPH. City driving is incredibly stop and go due to traffic, constant stop signs and red lights, etc., with probably an average of 15 MPH when I'm actually driving.
-No overfilled oil.
-Had an alignment maybe 8 months ago - nothing unusual about the drive or tire wear.
-Goodyear Viva 2 Tire P185/65R15, maybe 15k miles put on them. Tire pressure unknown at the moment.
-I drive like a grandma in D mode.
-I don't warm up the ICE.
-HVAC is off.
-In terms of whether any significant changes occurred around time I noticed the drop: none. I was living in Florida at the time, doing a highway commute of about 2 hours roundtrip every day with a small bit of city driving when the mileage drop occurred. I have since relocated to DC, and the problem is the same.
View 8 Replies
I have two Prius's, a 2008 and a 2005. My 2005 with 129k miles on it is the one in question. Recently I got a check engine light with the code P0A80 and P3016. I purchased a pair of tested to be good cells from Ebay which finally arrived in the mail yesterday. Today I finally got around to installing it and everything was pretty self explanatory... One of 28 cells tested to have 6.24v in block six and all the others had between 7.98-8.00v all around. I went ahead and replaced the bad cell with the new one and put everything back together and now the car will not start.
Cliff notes: Replaced bad cell in main battery back due to CEL P0A80 and P3016.
Car will not start, only turns on...
Getting error message on the radio screen about the Park position is not correct and to park the car on a flat level ground with parking brakes and try again.
Have charged the 12v battery to make sure it has enough juice in it.
View 16 Replies
195k miles.... I have charged the battery, I have bought a new battery, I have Charged the new battery... All with no avail.. Slowly but surely one at a time the abs trac control and stability control lights come on and eventually the triangle of death... Meaning when I shut it off its not going to restart.. If i drive it sparingly it might take a week if i drive it all day then it takes one day... when fully charged there is no warning or sign that there is a battery issue or draining untill the voltage is starting to get low. I have an ultra gauge hooked up and shows 14.14 while driving, I am lost as to whats the issue. also no codes or pending codes... I have taken the new battery to auto zone and had a functional test done.. said checked good... signed befuddled
View 19 Replies
The MFD on my 2005 prius shows that every time the gas engine kicks in, it trys to charge the batt. even when it doesn't need to be charged. This has been happening for about 2 weeks, and not one time has the gas engine kicked in without showing the arrow going to the electric motor, even when the batt is completely full. I know it's not just a problem with the MFD because my MPG average has clearly gone down since this started.
View 10 Replies
A year and a half ago, I had the hybrid battery warning lights come on and had it towed to the dealer. After given the option of replacing the battery for $4300, I took it home and did a single cell replacement (all cells ~8V, one at 6.6V which I replaced), which seemed to be all good until yesterday. Back with the warning lights and blower fan, I jumped to the conclusion that I have a similar situation, removed the battery and all cells are 8.04V +/- .05V except for 1 cell at 7.92. I am not convinced that this cell is really the culprit.
View 11 Replies
My Prius has 150k miles on it. We didn't drive it for a few days and when we went to turn it on,it wouldn't work. We were able to jump start it a couple of times, however after that we ended up having to replace the battery. We purchased it brand new from toyota. Then, the car wouldn't do a thing (No sounds, no lights, other than the red amber power button and the flashing check engine light, which was not on before.) We ended up having two blown fuses and we replaced them today, one was for the battery.Now the lights are on, but the car still won't start. It will cost over $200 to have the car towed and I am really trying to avoid that right now. I don't know much at ALL about cars. but I'm trying.
View 5 Replies
Well all the lights are on for mine as well as of 2 days ago... checked the 12v, was at 11.8v, tested under accessories load (without engine on) and went to 11.4v then tested with the car on and we're at 14.2v
So just to be safe I went ahead and got a NEW 12v and installed it yesterday. All the lights went away immediately. Drove 30 minutes to the town over after the install... fine.... it sat off for about 1 hour.... drove it back home another 30... perfectly fine.
This morning the wife takes it to work, starts the car, all the lights on again... turns it off completely, then turns it back on and all the lights are off and then drove it to work just fine.
View 10 Replies
If this has been posted before feel free to remove. I searched everywhere and didn't see exactly what I experienced with our Prius when the 12v battery was in it's final stages of death so I wanted to share.
Below issues all occurred within a one week time period 3-7-16 to 3-14-16. 2005 Prius with 145k miles, replaced traction battery on 7-30-15 / 127k miles.
First occurrence - happened a few seconds after starting and driving the vehicle. The ABS light came on and the power steering faded out and then came back, just briefly, and the car did not die. Turned the car off and back on again and all was well.
I performed the 12v battery test by entering maintenance mode. (hold the display button and turn the lights on/off three times, vehicle signal check, battery check) the battery was reading 11.9volts with the car off, I drove the car and it was charging at around 14.7volts and then was reading 12.2 with the car off after driving it. Which at the time seemed a little weak but nothing that was a red flag. I've read that you're supposed to replace the 12 volt battery every 4 years but I swear the one I removed looked stock.
Second time - again happened just a few seconds after starting the car and driving. ABS light came on, red triangle of death light, brake light, power steering was gone, and the power steering light came on, the car did not die. Restart fixed the issues again.
Third time - Happened about 30 minutes in to the trip while the wife was driving on the interstate around 75mph, wipers were on due to rain but visibly lost power, radio came on and off, all the lights on the dash (warning lights included) flickered on and off, power steering was gone, car died completely and would not restart. Tow driver had to boost the battery long enough to put the car in neutral so we could load it on to the tow truck. When we got the car home the battery was completely dead again.
I ordered an Optima Battery 8171-767 (DS46B24R) YellowTop Prius Battery from Amazon which appears to be a direct replacement, and simple to install. I drove the car for a few miles, returned to the house, performed battery test again via maintenance mode and the battery was charging at 14.0 and reading 12.5 when off. I can't be certain but I think the battery check feature may be displaying false information if the battery has dead cells and the car is trying to charge the battery? I took the old battery to Advanced Auto Parts and had them run a diagnostic check and the tester stated that the battery had dead cells and needed to be replaced. I gave them the old battery even though I didn't buy the new one from them and got a 10.00 store credit, unexpected and nice.
View 19 Replies
I replaced the hybrid battery in my 2005 Prius today & when I disconnected the 12v battery the wrench arced & I assume that I blew a fuse. I have looked, but have not found anything. I hope I am missing something obvious.
View 5 Replies
