My 2005 Prius (86 K mi.) has a warning light on - brakes. Put on the scanner and came up with code P1116 coolant temp. sensor circuit stack for coolant heat storage system. Also C1378 - capacitor communication circuit malfunction. I'm just a shade tree mechanic but can usually fix stuff if I know where to start.
View 4 RepliesIn my one-owner purchased-new 2005 Prius w/ 74K miles and w/ no maintenance/accident history other than doing all scheduled maintenances at Toyota Dealers along w/ recalls applicable at each time (other than we had Toyota replace the 12V battery last year just because I knew it would die at some point anyway and I don't like pushing my luck; I'm not 100% certain if there's been a recall on any water pump for this car and if so, don't believe the dealer has mentioned it), I have the following indicators which appeared all at once while I was driving along at around 45 MPH in no unusual circumstances (80F, dry afternoon, about 30 minutes into a trip of mixed speeds, no loads in the vehicle, no effect on the car while driving):
From Left to Right on the display:
1) Red Triangle - Master Warning Light
2) Orange (Symbol)CHECK - Malfunction Indicator Lamp
3) Orange (!) - Brake Warning Light (but it didn't highlight the word 'Brake' in red)
4) Orange VSC - Vehicle Stability Control Warning Light
On the Screen:
Orange Car w/ the ! symbol - Hybrid System Warning Light
We immediately aimed for the house (about 5 miles away); the car drove perfectly fine, with the engine stopping and starting at lights as needed, with speeds going from the 55MPH we were traveling at the time of the alarms down to 0 and back up thru 35/45 MPH and such per normal off-interstate driving. The battery currently shows all the blue bars, and the engine and hybrid systems showed charge/discharge as usual as we drove. There was no discernible change in the driving reaction of the car to brake, steering, accelerator, etc.
It has now come on 3 separate occasions, a week or more apart. Each time the yellow brake or tire light comes on. The next few times they come on together at start up. Then the triangle by itself comes on, does not clear. First time I was driving up hill. Second time I had just hit a drive way riser (not jarring). Today I was driving on a straight level highway and it came on at around 55 MPH.
Battery had been replaced after first instance. The inverter valve replaced too. Now what? It drives normally. Though it is the yellow brake light that accompanies the triangle Toyota says that codes say battery problems.
My 2005 Prius with around 60K has the occasional Headlight Leveling Warning Light. My question is how serious is this? Do I need to go to the dealer or can I wait on it? The lights still work fine.
View 1 RepliesI've got some issues with my 2005 Toyata Prius (~150,000 miles). My wife was driving recently and the "Master Warning Light", the "Hybrid System Warning Light" and the yellow "Brake System Warning Light" all came on.
Some quick reading of the owners manual said we should take it to a dealer right away, but because it was a yellow, and not red, brake system warning light it seems ok to drive at least to a dealer. in regard to the yellow brake system light the manual said it could be that: "the regenerative brake system failed or that the hydraulic brake system failed".
Now, I have a cheap bluetooth OBD reader hooked up to the "torque" app on my phone and I thought I would try to see what error codes there were to learn more. But strangely, it did not read any fault codes. I've used this reader successfully on my 2001 Mitsubishi galant, but I'm not reading anything for the prius in this case. I'm not sure if there is legitimately no error code associate with the warning lights or if my app is just failing to read them for some reason.
On my commute to work this morning my dash lit up wth warning lights for the ABS and VSC, shortly after I noticed that the brakes were pulsating.
I was in slow traffic becuase of a wreck on the interstate and each time you touched the pedal enough to apply more than regenerative breaking, they would pulsate to the point of shaking the car (at under 7 miles an hour). The car acted as if the system was alternating between applying stopping force and not, several times per second.
I have just recently bought a 2006 prius (T Spirit model in the UK) with 46k miles on the clock.
Anyway i took it into a local garage today for its full service, as part of the process they disassembled the brakes to inspect them. unfortunately when they put it all back together, all the brake related lights have come on (VSC, ABS, anti skid, handbrake) and despite the mechanics efforts to reset them, could not turn them off. When the car is turned off the brake pedal now feels loose and makes a funny twang noise as if it has come off its spring. there are also dull noises coming from the brakes when i am driving the car and turn the steering wheel full lock to the right or left.
What has really annoyed and scared me is that when i now drive the car and brake, on releasing the brake pedal i get the feeling the brakes do not disengage immediately, instead there is some lag with the brakes disengaging a second after i have removed my foot from the brake pedal and makes the car jerk a little before coming to a stop. the car also feels sluggish to drive and on the drive back home only managed to achieve 45 mpg (heart breaking!). the mechanic has promised to take a look at the car next tuesday (we have a long public holiday this weekend so most stores will be closed) leaving me to suffer 4 days of anxiety and non use of my car.
Last night I was driving my 2005 Prius in a light rain. I had only been driving for about 5 minutes or so on the freeway. The check engine light and the big red triangle came on. It was a couple of miles before I could get off the freeway, and by the time I could get to the exit ramp, the car at times was starting to race the ice. It was beginning to feel like it was slipping the "transmission" and I felt fortunate to get it off the road. I coasted into a convenience store and parked it. My scan gauge showed me a code of POA3F. I have discovered that this is the Drive Motor 'A' position sensor circuit. What does this all mean? Is this going to be an expensive fix? After letting the car set for a while and a few phone calls later, I attempted to start and put the car in gear. It would only let me put it in neutral. Is there any chance at all that my problem could be less than major?
View 5 RepliesAbout a year ago, the rear brakes became very suspectable to moisture and started grabbing. After a few stops the grabbing would subside, but I could still feel the rear brakes engaging a little earlier or more than the front brakes (the rear-end of the car would hunker down a little). So I replaced the rear shoes, the old ones had about 90K on them, not worn real bad and had plenty of life left. I made sure that when I installed them to clean everything, put a skim of silicone brake grease on a couple of the friction points and set the adjusters down so they would be able to auto adjust to the right setting.
The grabbing didn't stop, so I've lived with it for a while and finally got around to replacing the front brakes on the assumption that maybe since they were old that they may not be stopping the car as much as the new rear brakes were. Didn't work, in the back of my mind I'm wondering if there is possibly something wrong with the master cylinder and the balance between front and rear brakes is off. I'm going to go clean the rear brakes again today and crank the adjusters back to see if they adjust to a better position this time around. The drum and disc surfaces are in good shape and color.
Can the master cylinder get its balance messed up?
A year and a half ago, I had the hybrid battery warning lights come on and had it towed to the dealer. After given the option of replacing the battery for $4300, I took it home and did a single cell replacement (all cells ~8V, one at 6.6V which I replaced), which seemed to be all good until yesterday. Back with the warning lights and blower fan, I jumped to the conclusion that I have a similar situation, removed the battery and all cells are 8.04V +/- .05V except for 1 cell at 7.92. I am not convinced that this cell is really the culprit.
View 11 RepliesMy 2005 Prius has about 141000 miles on it. The red triangle exclamation point comes on the dash and a yellow exclamation comes on the LCD 1st and then a 2nd yellow symbol comes on the LCD. The problem happens once or twice a day. It seems to start, run, and drive just fine. I do restore antique tractors and I am pretty good with computers and I have some pretty good mechanical know how. Attached are pictures of the lights.
View 1 RepliesWell all the lights are on for mine as well as of 2 days ago... checked the 12v, was at 11.8v, tested under accessories load (without engine on) and went to 11.4v then tested with the car on and we're at 14.2v
So just to be safe I went ahead and got a NEW 12v and installed it yesterday. All the lights went away immediately. Drove 30 minutes to the town over after the install... fine.... it sat off for about 1 hour.... drove it back home another 30... perfectly fine.
This morning the wife takes it to work, starts the car, all the lights on again... turns it off completely, then turns it back on and all the lights are off and then drove it to work just fine.
I own a 2005 Prius with 233K miles. I got the terrible red triangle of death and several other warning lights. Had the codes checked out at Toyota and confirmed a bad HV battery. I am kinda handy and I replaced it myself. No big job, it took about two hours, most of which was spent removing the interior panels, etc. Test drove the car and all looked well. Thirty or so miles later, BAMMM, lots of warning lights. At this point I took it to my mechanic to have it checked out. They found nothing you wouldn't expect when you've disconnected the two batteries.
They cleared the codes and off I went. Again about thirty miles out the lights went on again. Back to the garage once again. What they found was a corroded connector running to the fan, located under the rain gutter of the hatch, passenger side. Hmmm, how'd that get corroded?? Two years ago I remember drain the sump where the spare's located of 6 inches of water, how'd that get in there??? My mechanic confirmed he has seen that before in the Prius. So now I am wondering, did the initial battery fail because the fan may have failed??? Perhaps we need a warning light.....
I just purchased this car & thought there may be a learning curve to dealing with the brakes, but I think it may be abnormal.
When braking, I apply more & more pressure smoothly down on the brakes, but no matter how evenly, slowly, and smoothly I try to remain when braking, there is a point when it abruptly brakes to jolt the passengers forward and make me look like a terrible driver, lol. It provides for a smooth decline in speed until I'm almost stopped, then it does it. Jerks us to a stop. So I've learned to apply even pressure and right before that is about to occur, lift up on the brakes and restart that slow pressure to avoid it happening.
I can deal with this because it's not that big of an inconvenience once I've gotten used to it, but I am just worried it may turn into something more or who knows, could be an easy fix. I had the car inspected by a Toyota dealership before I purchased it, and they said that everything was in great condition aside from windshield wipers. It has 81,000 miles, one owner, clean carfax.
My 2005 Prius with 116K on it has been having some uneven acceleration lately and today the Triangle warning light, the check engine light and the brake light came on at the same time. I had about 1/2 mile to go, so I proceeded slowly and called the dealership which had performed a routine oil chg two days ago. They said that if the lights weren't flashing then I could drive it. They recommended that I take it to AUTO ZONE and put it on the analyzer. This elicited these codes: P3019: no definition and P0A80: replace Hybrid Battery.
I have an appointment in 2 days and I'm wondering about a salvage HV battery since the car is 7 yrs old and over 116K miles.
We recently purchased a used 2006 Prius. The vehicle has approximately 74K on it now. Well the other day my wife went to leave work and pressed the power button while pressing the brake pedal, and the Master Warning Light and brake warning light both came on. The car would not allow her to shift the car so she tried to turn it off and it wouldn't do that either. After about 5 minutes she finally got the car to turn off, and when she restarted the sequence everything went back to normal and she drove home fine.
We called 2 dealers and they both seem to be confused by the symptoms, but one thought that maybe the battery was old on the transmitter. So thinking that might make sense I replaced the battery with a new one.
My wife and I own a 2006 Toyota Prius that we bought used 2 years ago. a couple of days ago, the master warning light (red triangle exclamation point) and check engine light came on. I took it into the dealer and of course, our hybrid battery was dead - battery and a new ECU required.
Our car is at 99,000 and 32 days out of warranty. Went down the road to atlanta hybrid repair. they were incredibly nice, and said that my computer was fine, but the battery would need to be replaced.
I was driving down the road and the VSC warning light came on with the check engine light... What could be wrong should I have it tow to the dealer!
View 4 RepliesThe red triangle warning light on our 2004 came on and went away again It has 100k miles If I take it to the dealer can they pull some codes and figure out why it turned on We have to drive the car to 600 miles for the upcoming weekend and I don't want to be stranded on the side of the road The car has 103,000 miles We just replaced the 12v battery so I know that is OK
I also saw the following things to check. Is there anything else we should check?
1 - Are any warning lights on besides the red triangle? For example, the red BRAKE light, the amber ABS and VSC lights, or the amber circular icon?
2 - Did you check the brake fluid level? If low, buy a new container of DOT3 brake fluid and replenish as needed This fluid will dissolve paint, so do not spill it
3 - While you are at it, check the radiator and inverter coolant levels by looking at the translucent reservoirs behind the radiator and next to the inverter If low, fill with Toyota Super Long Life Coolant
It was driving me crazy that the red triangle warning light (master warning light) flashed for only a split second, once per day, two days in a row.
I drive 100 miles per day. My 2004 Prius has 136K miles.
It turned out to be low motor oil level, 1.75 quarts low.
My car is burning about one quart every 5K miles which probably is within the normal range for a 136K car.
I was driving earlier today and it flashed twice (about a second and a half each), and then didn't see it again for a few hours. I was going about 40 MPH at the time.
I was driving somewhere else today and when I got to the 70MPH mark (really, between 60-70), it objectively increased in frequency. I searched google and these forums, and the closest thread I can find that shares my ailments was this one: