I replaced my hybrid battery of my NHW10 a year ago. now recently it shows the warning triangle. Once it went off after a long drive but now its permanent. is there a way to Diagnose what is the cause of this? If its a Hybrid battery issue, will it go off if i replace the bad cells?
View 3 Replieswell I saw one other thread on this topic but no resolution. I replaced the hybrid battery like the codes told me too on my 2003 prius and it now drives great but as soon as it start it shows a problem and the red triangle stays on. No check engine light, no codes, no driving issues just a red triangle. How to diagnose a red triangle when there are no codes.
View 16 RepliesThere's an ad for a car quite far away from me and one of the photos shows the dash lit up like a Christmas tree. Is this normal during power-up or is it normal when there's something quite wrong?! There is no red triangle of doom shown; I'm unsure if that might be out of shot though. Car is quite high mileage with just over 270,000 km on the clock and is from 2006.
View 2 Replies My wife has a '03 that has been great. No issues. I am a excellent mechanic, on conventional cars and motors. Here's my story:
Bought the car used and working last week. Put in a new 12v Group 26 battery w/conversion. I verified the 12v battery was at 12.8v and when engine was running, 13.6v to charge the battery. Car was starting and driving wonderful for about 600 miles. No shuttering, no shaky starts. Mileage was about 38.6. Anyway, yesterday was driving and all of a sudden the warning Triangle comes on, Hybrid system icon comes up and the engine goes off. I was able to drive the car about 1/2 mile on the traction battery back to my work.
It happened to have a code reader handy and it reads a P3125, Inverter. I realize there are sub codes that further diagnose the issue, but I don't have that type of OBDII reader although mine is a very expensive model. Anyway, I reset the code and got the car to start. Motor begins to go up in RPM and throws the code again. I shut it off, reset the code, try to start the car and I feel it slightly jump forward, engine does not start, then throws the warning code again. I did notice the traction battery is at 25%. I do this two more times trying to get the engine to start before I call the tow company. BTW, the car rolled easy, so I don't think its the MG2 is bad, although correct me if i'm wrong but doesn't Mg1 start the engine?
Oh, incidentally, also the ignition key does not release either. The key release solenoid is energized unless I unplug the 12v battery, then I can get my key out.
This afternoon, after driving about 150 miles, I came home and shut off my 2001 Prius. It was sitting for about 20 minutes before I turned it back on to drive off. Almost immediately, the hybrid warning light came on on the MFD, the red exclamation mark light illuminated, as well as the check engine light, and the motor shut off. I popped the hood, and could hear a high pitched squeal coming from near the inverter. I called my dealer to ask the service department what I should do, and they just told me to bring it in and they will take a look at it. I live over an hour away, so I don't want to bring it there if I can avoid it. I then shut it off and let it sit for a few hours.
After reading about the possibility of the auxiliary battery being bad, I went and turned the Prius on, and then shut it off several times to reset the hybrid warning light (I had to do so in order to access the aux battery information through the MFD). It turned on without incident, and shut off fine, and after being reset the hybrid warning light shut off, as well as the red triangle light. Then, I went through the process of pulling up the battery voltage information through the MFD.
With the car off, and the lights and fans off, the battery voltage read about 10.0-10.5 V. With the lights and fan on, the voltage dropped to about 9.5 V. After getting those readings, I drove it down the road a little ways, just going about 20 mph. It seemed to work fine. The check engine light is still illuminated. With the motor running, the voltage reading was 13.2 V, and then when I got back from my test drive and shut it off, the voltage hovered at 10.6 V with the lights and fan on.
I have a 2003 Prius with just over 116,000 miles. When my wife cranked it a couple of days ago, the "Hybrid System Warning Light" came on.
As advised by the owner's manual, we didn't drive the car. We took it to the local dealership to be checked out. When I called for an update last night, they said that the computer indicates that the hybrid battery is leaking.
So I guess my questions are:
1) What kind of lifespan is typical of a 1st Gen Prius?
2) How many more miles are reasonable to expect from the gas engine?
3) Is there anything I should be aware of to make sure I'm not taken advantage of? (eg is there a credit for the battery since it has valuable components)
The last few weeks I've been noticing that, upon start, the hybrid battery is showing at 1 line. It's been really hot in SO cal and the air con has been blasting, so I've been letting it charge up a bit before driving. Once I'm on the road, the battery charges fine and seems to hold a charge.
View 10 RepliesMy 2002 Prius stopped while driving down the road and will not restart.
The fuel level is flashing and was ~ 1/2 when the car failed. My scanner will not read the OBDC 2 (not connecting). The windows other than the drivers will not go up or down.
The PRNDLB does not show gear.
The 12 volt battery is OK, but the HV battery shown as blank on the energy screen.
I hate to put too much into a 2002 with 190,000 miles, but it does still have value if I can get it running again.
For example if I needed a rebuilt battery for 15-1800 I would probably go for it. So far the car has been 100% reliable.
i have a 2006 with almost 200k miles. Got the red triangle, check engine light, and the red car at the top of the MFD. I ran the codes and got P3000. Does this sound like traction battery failure? The car still turns on and ICE still cycles off and on.
View 19 RepliesI have a 2007 Prius with 107k miles. Last July it had a minor drivers side front end collision. Last November it had the hybrid battery replaced. I believe all this is unrelated just putting it out there for information.
I am currently having the red triangle pop up intermittently. When it does a "problem" message will display on the MFD. This seems to occur most often after a long downhill or when the Energy display is showing the hybrid battery is nearly full.
The hybrid battery seems to be functioning normal and the car is driving normal and has expected fuel economy. I do have a headlight that cuts out occasionally but no other noticeable electrical problems. I do not have a diagnostic device to get the codes.
First off I have a 2010 with about 11,000 miles and it has been running great since I got it. This morning I was greeted with the "Yellow triangle" and the "check hybrid system warning". The car started fine and I pulled out of the garage under battery as usual and then the engine kicked in also as usual, everything seemed normal except for the warning lights. Since I have a long commute I just took my wife's car and got to work and did a forum search on this issue. I called my wife and had her turn the car on and off three times and she said it cleared the yellow triangle and check hybrid system but it still had the check engine light on. She also said the car seemed to be running fine and shes driving around town in it. I couldn't find anything on the check engine light. Is it ok to drive it?
View 3 RepliesDuring a highway trip three months ago, my 2004 Prius suddenly lost engine power, the red triangle Master Warning light came on accompanied by a warning sound, and then the Hybrid System Warning sign appeared on the Multifunction Display. I pulled off to the side of the road and stopped. I turned the car off and then tried turning it on again. Engine power was restored although the warning lights remained. We took a chance and carried on with our trip. The same sequence of events reoccurred about 10 times on our 1,300 km journey. I took the car to a Toyota dealer where they found a C2318 DTC. They checked the battery and the HEV fuse but could not locate the problem.
We returned home and on the way the same thing happened a few more times. My service manual noted that the description for C2318 is Low Voltage Error (Power Supply Malfunction) and the trouble areas are HEV fuse, IGCT relay, Wire harness or connector, or Auxiliary battery. Since the car was nearly 7 years old I thought I had nothing to lose by replacing the battery, which I did. However, on a short 150 km trip last week the problem appeared again, once while approaching our destination and once when we were almost home. There seems to be a pattern in that the problem appears every 150 km or so of highway driving. It has never done it while driving in the city.
A few days ago I was driving my 2005 Prius aggressively up a mountain road and all at once the hybrid system warning light, the triangle with the exclamation point, and the regenerative brake system warning lights came on.
After about 2 minutes parked, I restarted the car and the regenerative brake system warning light went off, but the other two were still on. I still drove it twenty miles home, over another substantial mountain gap (about 1000 ft up and another 1500 down), without any problems.
I checked the voltage of the 12v battery, which seemed to be on the low end, but OK. (I think the lowest reading was 11.9). There seemed also to be some turbulence in the inverter coolant reservoir.
I brought it into the electronic vehicle specialist in town here today, who pulled my codes and said that the hybrid battery was dead.
Possible hybrid battery failure in my 2004 Prius (96K miles).
Sunday before last, the check engine light, warning triangle, and hybrid warning light came on when I started my car at the grocery store.
Because I was close to home, I drove home and the car functioned completely normally. The next morning, when I started the car, the same warning lights appeared. However, when I tried starting my car with the headlights off (I always leave them on), no warning lights appeared.
I took my car to an independent mechanic. This is their written report:
"Found multiple check engine codes, P3000, sub code 123, V0100 sub code 211/330. These codes are set when high voltage control detects a malfunction in battery pack/ECU assembly. To check battery pack we took vehicle out on a test drive while monitoring the cells in the battery pack. Found that they are all weak and drop fast when battery is put under a load. Code C2318 is a low voltage error/power supply malfunction code with the auxiliary battery. The voltage spec for setting the code is 9.3 volts, this battery is less than 9.2 volts."
In conversation, the mechanic also told me there was significant voltage variation across the cells in the hybrid battery.
I then took my car to the dealer to try to confirm this analysis. They were unable to read any codes because the independent shop apparently cleared them. The dealer was unable/unwilling to do more than read the codes to diagnose the problem. (Indeed, they seemed surprised that the independent mechanic could monitor the cells in the pack.) All they did was to drive the car around some more to see if the check engine light would come on. It did not.
The car has been driven 80 miles since the warning lights last appeared and appears to be behaving normally. From your perspective, does the report from the independent mechanic make sense and is it believable? And is their test under load definitive of a hybrid battery problem? Could the results be affected by the low auxiliary battery? Also, if I do have a hybrid battery problem, what are the chances of being suddenly thrown into limp mode while driving it?
I have a 2005 prius with 84,000 miles. The car is running fine but the main red triangle light came on. I took it to toyota and they said I needed a new hybrid battery.
View 10 RepliesI have an 07 Prius which I bought used in 2011 and which has been fine (except for some A/C work last year) but got the 'triangle of death' this morning and having towed it to my regular shop, they tell me the code (they couldn't give me the number) simply said 'replace hybrid battery'... the car has 102,605 on the clock.
View 9 RepliesI have a 2007 toyota prius. The car drives, but pulsates. The Check engine light and triangle of death are on. Diagnostic test says "replace hybrid battery pack", but wouldn't the car not even start if the bat pack were dead? What it could be? perhaps a bad cell or two? a bad ecu?
View 19 RepliesI have a 2007 Prius and the red triangle showed up. It has less than 50,000 miles. I noticed that almost right after I start it up the hybrid battery fan kicks on. This leads me to believe that maybe one or more cells in the hybrid battery are overheating due to charging problems. Is there a way I can check this out without going to the dealer?
View 3 RepliesI've seen this a couple times but always made it home with the Red Triangle and VSC warning. A year ago, I blamed it on the OEM 12 volt battery and eventually replaced it with a Optima Yellow Top. No more problem until today. Day time driving with my Plug-in Supply 10k rechargeable conversion performing normally. City driving raining but normal Western WA conditions. Red Triangle and VSC warning. Other systems operating normal.
I knew, from previous experience that the Prius operating systems would continue to work only until I turned it off. I did turn off the Plug-in Supply controller to isolate that system and observed that the OEM traction battery was at a fairly high state of charge and the ICE was still providing the normal amount of assist to the traction battery through normal street and driving conditions.
I should have driven the 20 + miles to get home, even with the Red Triangle warning. I had done that in the past with the old OEM 12v battery. But I needed gas and went to a station and turned off the system ICE out of habit. Sure enough, the system wouldn't go back into Ready but would go from Park to Neutral. Since it was rain hard now, and I was calling my road service, I ask for a Flat Deck Tow home rather than a jump start.
As soon as I got off the tow truck I put my battery charger on the Yellow Top and it only read 11.7 volts. It's still on charge now. Now I'm wondering why the power conversion system wasn't charging the 12 volt battery or is my 1 year old Optima bad?? Or is there something about my driving conditions/plug-in conversion that is effecting the charge of this battery. I did a 2400 mile road trip to So. Calif and back to WA without any problems. Car has just 98169 miles right now. About 10k miles on the Plug-in Supply conversion.
I have an 04 Prius that recently had the HV battery rebuilt with replacement of a couple of cells. It now is showing dash lights of Red Triangle, Small Exclamation, and VSC. Error codes are coming up on techstream v9 as :
P3000 curr
P0A84 hist
C1310 curr
C1311 curr
(all 4 of the above have asterixes by them )
B1421 curr (no asterix)
The car is running perfectly and seems to be fine.
I own a 2005 Prius with 233K miles. I got the terrible red triangle of death and several other warning lights. Had the codes checked out at Toyota and confirmed a bad HV battery. I am kinda handy and I replaced it myself. No big job, it took about two hours, most of which was spent removing the interior panels, etc. Test drove the car and all looked well. Thirty or so miles later, BAMMM, lots of warning lights. At this point I took it to my mechanic to have it checked out. They found nothing you wouldn't expect when you've disconnected the two batteries.
They cleared the codes and off I went. Again about thirty miles out the lights went on again. Back to the garage once again. What they found was a corroded connector running to the fan, located under the rain gutter of the hatch, passenger side. Hmmm, how'd that get corroded?? Two years ago I remember drain the sump where the spare's located of 6 inches of water, how'd that get in there??? My mechanic confirmed he has seen that before in the Prius. So now I am wondering, did the initial battery fail because the fan may have failed??? Perhaps we need a warning light.....