Prius (2001-03) :: 2002 - P3125 Sub Code 325 With No Start / Inverter Failing
Mar 16, 2015
Pulling into parking lot and the triangle and exclamation light appear on dash. Drive about an additional hundred feet with what felt like lower power and no noises.
- Check 12V after about an hour and it reads 12.4 volts.
- Read codes and get P3125 sub code 325.
- Temperatures and HV battery numbers all looked good.
- Clear codes and immediately code comes back with no start, nothing. Did this many times.
This code and sub code lead to the inverter failing. Being that there was no noise as a MG2 stator failure this also leads to an inverter failure right as the MG1 motor starts the engine? Inverter pump still running good as it was recently replaced along with ATX fluid. Within the last two weeks two HV modules have been replaced.
View 18 Replies
Advertisement
I bought an 01 Prius with 148k miles. It had code P3125 which mean bad inverter. I replaced the inverter with one from a junk yard with 81k miles. As soon as I was done the car started right up, and I didnt get electrocuted!
Right after the car started I got codes P3115 P3001 and P 3191. I cleared them out and turned off the car for a min.
When I started the car again I got codes P3030 and P3001.
This car has an extensive service history, It has a new Cat and exhaust, a new accessory and HV traction battery that are less than 8 months old. Crank position sensor is new. fuel tank is new.
What could be causing the P3030 and the P3001?
View 19 Replies
My 2002 Prius died the other day. Getting DTC P3125 when I ran it through my scanner, but I don't have an advanced enough one to get the sub-codes. It's got 215,000 Miles on it, so I would expect something major to be happening at this point.
Here's a detailed description of what happened --- I was driving down the freeway the other day and started noticing my car was sputtering a little bit and losing a slight amount of power. I pulled over to a restaurant to say hi to a friend; when I came back out I started the car and the check engine and battery lights came on. About 10 more miles down the freeway the car started heavily limping and barely was able to get me off the freeway, then the car completely died. When I would start it back up it would die in about 5 to 10 seconds. The 12v auxiliary battery, not the main hybrid battery, had completely died.
I figured it might have been just a dead old battery that needed replacement so I put in another new one. It ran amazingly for about five minutes around the parking lot, then the same thing happened again. It completely died just like before.
The 12v battery isn't getting re-supplied with the juice it needs. Something's wrong in there.
The either the inverter is shot, it's just overheating due to a faulty coolant pump, or the MG2 generator isn't putting juice back into the 12v system.
I checked the fluid reservoir. It looks like it's flowing, but there is a few bubbles floating to the top of the fluid. Is that normal?
View 3 Replies
My Wife was driving our 2001 Prius and got the big triangle and the car went into limp mode.
The Codes were P3100 (info code 196) and P3125 (info code 325)
P3100/196 = Internal Error - Generator CPU Malfunction
3125/325 - Inverter Internal Short. - Generator Inverter Fin - Inverter Internal short
Clear the codes and the car runs fine, but the problem will eventually resurface.
The dealer wanted tor replace both the converter/inverter and HV ECU.
I purchased replacement converter/inverter from Ebay and inverter coolant pump (new) and installed.
Problem eventually resurfaced. I purchased replacement HV ECU from ebay and installed.
Engine would not start (does not attempt to even turn over), but was not throwing any codes. I had this same symptom with a third HV ECU as well. The part numbers on the HV ECU were exact matches.
View 11 Replies
Working on a 2002 prius with 153k miles. bought it with a "Bad transmission" diagnosed by toyota dealer. Got I home and did a quick check but there were no codes. I drove it about 50 feet into my garage where it would shudder badly while being driven which from my experience sounds like a bad MG2 motor. Drained the oil and thought hhmmm th oil does not smell bad and neither did it look burned. Proceeded to pull the mg2 but found it looked brand new, no burned spots or any such thing. SO I put it back together and think its a bad invertor. put on a different invertor that I have lying in my garage that I "think" is good and start the car. get code p3125 and p3120 and still have the bad shuddering when i try to drive it..Is there any way to test it further before I pull the trans and put a new trans back in?
View 19 Replies
2002 Prius with 94K gave me today P3130, after I tested the Inverter Water Pump I found out that it bad but until I go to the dealer in order to buy the part $147 he was closed. the question is can I drive with the car like this bac home (65 miles) and if I turn on the A/C the Engine will work all the time right? And also after replacing the Inverter Water Pump how can i tell if the problem solved?
View 14 Replies
I read in the owners manual that the engine antifreeze should be an ethylene glycol type. I believe that Prestone makes this type of coolant in a 50/50 mix. Is that correct? Also, what type of coolant does the inverter use? I want to try and stay away from buying it at a dealer. Also, my gen 1 has 117,000 miles and I must admit that I have been slacking with the maintenance. My gas mileage is down to 40/mpg compared to 48-49mpg when I got the car two years back with 40k. I am pretty sure the original auxillary batter is still in it, so I order a new one today. I also plan an changing the transaxle fluid, PCV valve, air filter, and cabin filter. The plugs where changed at 80,000 miles. Where can I order a gasket for the transaxle pan? I intend on dropping it and cleaning it out. Do you think this will get the gas milage back up?
View 3 Replies
I have a 2001 Toyota Prius. The inverter cooling pump was dead and I had the P3130 fault code. I replaced the pump and the refilled the fluid. After more than 4 or 5 times bleeding the system, now the pump sounds funny. It sounds like a water fall and look like it has too much air!!!! I can’t see any turbulence in the reservoir tank either.
There are 2 bleeding valves on the front side of the Inverter. Which one should be used to for bleeding the system? Both?
Does the system have any thermostat that could cause problem? Does it use the same radiator as the main one? What could cause having NO turbulence? I think the new pump will be dead too if it can’t make the turbulence.
View 5 Replies
I am working on my folks 2003 gen 1 prius. Dealer told them inverter was bad so I bought a used one to replace it from junk yard. I was able to drive the car on purely gas mode prior to replacing inverter. I have now replaced the inverter and innitially was able to drive it on battery power, but no gas engine, it wont start. Now no movement at all. I have reset codes both with my obd2 scanner and by the touch screen diagnostic window. Am I missing something here as I can't get the warning orange triangle to go away or check engine light, and now gas engine. When I turn key, I hear clicking sound in rear of car. Also, I left doors open when working on car and drained little battery, I replaced it with a larger battery that I have put in a battery box.
View 7 Replies
I just purchased a 2002 Prius from a government auction. The car had to be jump started at the auction yard. It ran for awhile and then died before I could put it on the dolly. I jumped it again, load it and towed it home. When I got home I jumped it and drove it off. I tried to charge the 12V battery on a 2 amp current, but it wouldn't charge so I replaced it with a new battery. Now the car won't start at all. Don't worry, I did not reverse polarity at anytime. Here's what is happening now....
View 2 Replies
I picked up a 2003 that had a bad AUX battery and P3130 code. Just FYI, aside from the battery it drives fine. Kicks the Warning light after about 15 miles but since the battery was bad it kept getting reset. Replaced the battery with a nice optima conversion.
Took out the inverter coolant pump, tested the circuit (good), tested the pump (bad). Replaced with a new one from dealer. Set up the bleeder tubes and massaged the lines till the new pump stopped SCREAMING at me. Added probably 2 qts of TLLC total. Bleeder tubes never had enough pressure to push fluid back up to reservoir but got solid 2 inches of fluid with no bubbles. Topped of the coolant. Went for a drive around the block, made it halfway (about 28mph) before the light kicked in and the motor seemed to bog down. Limped back home and read the 3125 Code. Code reader does not give me sub codes.
2003 Prius 154K miles on ODO.
View 3 Replies
2002... 184,000+ miles
I was driving the car and triangle popped up and engine would not shut off while parked (key on) I hooked up the non prius aware scanner (carry one with me at all times) and don't remember the code, but it was a "HV malfunction".
I didn't shut the car off to clear the code as I was not home and attempted to drive it home, meanwhile engine never shut off. I had to come to a complete stop at a red light and the car died. tried restarting it but nothing. so I pushed it off to the side of the road and cleared the code. Tried again and nothing. didn't start, nothing. it beeped and error code popped up. Checked the code and it was p3125.
I know there are subcodes but online it was leading to inverter. but I replaced the inverter last year with a re involt. I had the car towed to my job for $50, to have it towed home, would cost roughly $168. When I got it to work, I did the screen thing and checked the 12v battery and it was reading 10.9 I have been meaning to get a new one for about a year now so I did.
I purchased a new optima battery and installed it yesterday, cleared the codes, tried to start it and nothing. error code p3125. What leads me to believe that it may be a transaxle, well actually a Mg2 is when my inverter went bad, it would start then shudder and die then the triangle would pop up. this time around, it doesn't even start. I have an appointment with the dealership to get the code with subcode read on Tuesday 10/15 for $98.7.
View 7 Replies
Car stalled and ran on battery only. Set code P3125, and depleted aux battery. So, I replaced the inverter and recharged aux battery.
Drove it 20-30 miles test driving it, when the MIL came on.
Drove home and found 2 codes set, 1st was set while driving, 2nd was set after parking.
P3000/123 - MPH=22 MG2.RPM=1280 SOC=65% Position=D
P3125/287 - MPH=1 SOC=60% Position=P
Any TSB on this issue?
View 8 Replies
I bought my Prius after I tested the car around town and on the highway and went smoothly. I drove the car about 200 km after the warning came on board, high temperature and cold engine warning (red and blue). Stopped the car and I found nothing to be hot (engine or inverter).
I rebooted and the errors disappeared but reappeared and on the highway (120 km) car no longer accelerate, pedal did not respond.Stopped and restarted repeatedly trying to get as close to home and a Toyota service. High and low temperature have appeared and disappeared after stopped and restarted. Warnings appear together, none or only one of them.
But after 600 km appeared turtle on board and the car stopped. I was unable to start. They came from Toyota and were able to start with another auxiliary battery and ran 10 km with a tester on the dashboard (at full throttle and the car accelerated 1 km / sec until it reached 60 km / h then accelerated normal to 125km/h. When he put the foot on brake and after that tried to accelerate again the pedal was non responsive and the car stopped again and they towed it.
Next day they told me that the ECU is faulty (the one located behind the glove compartment) together with the Auxiliary Battery.(1100 Euro ECU).They told me that the temperature sensor is 200 degrees Celsius with a cold engine.
We towed the car to another service closer to home (1300 km) and asked a second opinion telling me that is defective inverter. I decided to buy an ECU. (220 Euro/ second hand)
Meanwhile my traction battery died after they tried to start the car many times.
After I charged the traction battery (one module at a time), whole battery shown after charging 301 V.
Now I have the following :
P3120 HV transaxle / Wire harness
INF. Code 249 (Open or +B short in motor temperature sensor)
View 19 Replies
While driving home last night the Red Triangle, CEL and the Hybrid Warning lamp, (on the MFD) all lit up. The cruise control also shut down. We stopped and checked the manual to identify what the symbols meant. We were approximately 90 miles from home, drizzling rain and it was about 60 degrees.
View 18 Replies
I have a 2004 prius that will not start. First let me tell you what we have replaced so far (within a week) inverter pump, thermostat, water pump, battery 12V(brand new from toyota) and the inverter and it seems to be stuck in drive, but we cannot get it started to figure that one out.Code was reading p0A78 and even after changing inverter it still is reading that code is there.
View 7 Replies
My 2005 died in the middle of the road a few days go. Was just rolling along fine then suddenly out of a stop light, the car stalled and would no longer go back into P, D, or R while the battery still seemed to be working. So had it towed to the dealership to be checked.
View 5 Replies
I have a 2007 Prius, and bought it used about 4 months ago. I have not had any issues with it until last night. Last night I was driving home and the red triangle with the “ ! “ in the middle and check engine light came on. The car seems to be running fine, but it scared me to see the lights come on...so this morning I called my local Toyota dealership.
NOTE: I recently went to them for an oil change and they informed me that I had three recalls on my vehicle that needed replacing, but I did not get them replaced because I was told it would take 5-6 hrs (which I didn’t have at the time).
Anyway, they told me that it would cost $70 to have the codes read...and that did not include parts that may need replaced... I thought that sounded a little high for just having the codes read so I went to my local Autozone and they gave me this code:
P0A93 - Inverter Cooling System Performance
View 16 Replies
I own a 2006 JDM prius with 323,000 km. The inverter coolant pump failed recently (got P0A93 code and no agitation in coolant reservoir). I ordered a replacement on eBay and am awaiting arrival. I may need to do some light driving in the in the interim and am thinking about installing a 10 inch fan in the space between the inverter/transmission and radiator to keep things cool. Is this wise or should I just let the car sit until the new pump gets here?
Also, I am burning oil...I usually have to top up 1 to 2 quarts in between changes. Is there anything I can do without tearing down the engine? A friend of mine suggested using Lucas oil stabilizer the next time I change oil...could this have any negative implications?
View 8 Replies
My 2001 Prius with 134k miles has been running great but leaves a small amount of coolant on the ground after parking. I've had to add approximately 8 ounces per 100 miles.
View 13 Replies
Toyota ticked me off. I had them repair the ac on my Prius and during this time I read bleeding the inverter coolant can be a pain. They said they would flush and fill the inverter coolant for me. Over the weekend I get a P3130 error saying inverter overtemp. I did not have "turbulance" in the reservoir when I first bought this car and didn't know much at the time. Now, with getting the code I looked into this deeper. I told Toyota that this repair had been skipped and they denied it. Ends up the fluid was lower than it should and the tech said the pump wasn't working. "How did you bleed the system then". They gave me 2 gallons of coolant and I told them I will repair this myself now.
View 7 Replies
