Prius (2001-03) :: 2002 - False Main Battery Warning
Feb 6, 2013
Got a recall letter last January from Toyota concerning a false warning light on my model. Letter mentioned that moisture in the cables was triggering a false warning message about the main battery. My 2002 was having this problem. The dealer refused to do the work. Told me they did that recall work in 2006 but I did not have the problem back then and Servco Hawaii told me that Toyota had not put that out as a recall back then. The light has gone off and on now for a year. Car drives perfect otherwise and only have 60,000 miles on it. What do I do?
View 8 Replies
Advertisement
I have a 2002 prius with 143,000 miles. On Friday, I went to start my car and put it in gear and the check engine light came on and the "triangle of death" lit up and car died. I turned it off and waited about 30 seconds and tried starting it again. It started and I drove 1/2mile home. Went into the garage and got the Actron/OBDII code reader. Pulled the code P3125 which when I googled it, it was referring to the inverter. I cleared the code and all was well.
View 6 Replies
I bought my 2002 prius with 120000 miles. Last night it died with the main battery light and triangle of death on. I haven't taken it to a dealer to have the codes checked out you, but will do it soon. My daughter was driving it when it happened and said the car started shuttering and died. She was able to drive it a few feet at a time before it would die again. Does this sound like a HV battery problem? I will be digging into it tonight.
View 19 Replies
I need to replace the main battery on my 2003 prius - whether or not they've replaced the battery, and what the end result was afterwards - did the car continue to last? Is this just a "regular maintenance' thing and all else will work swell, or is the beginning of the end?
View 12 Replies
My main battery is dieing will my prius run on just gas until I can get it fixed? It is a 2001 hybrid. I need to get to work for the weekend.
View 6 Replies
Ok just bought this 2001 Prius One Owner new car trade in it sat for a month without moving It needed a boost to start it then the three lights on the display lighted up PS+Main Batt + a pic of the car with a ! in it ! is it just from sitting so long and the Battery is low ? If I use an OBD and reset it will this and a charge take care of the problem ??
View 3 Replies
I have a 2003 Prius with a hard falt code of P3000 main battery bad! But there is not anything wrong with the batt or how it runs. I cleared the code and in 10 miles or so it comes right back? I was thinking of a reflash on the computer, what to do?
View 1 Replies
A warning came on the display with the words "PS Main" and a picture of a battery. I took it to a dealer and he gave me the bad news: I allegedly need a new hybrid (main) battery. The diagnostic code was P3009--I didn't know about sub-codes, so I didn't ask if there were any. P3009 means that there is an electrical leak from the main battery.
View 9 Replies
Recently my 2nd gen Prius has been acting, strange. I hoping to get some insight to the best way to fix the problem, so I will include as much detail as I can.
Over the weekend I went to go run some errands and while I was leaving my neighborhood, my dash lit up like a Christmas tree, with the red triangle, CEL, low tire pressure, and the exclamation on the MFD. So I quickly turned around and parked it back in my garage.
A little later and after doing some research on the forum here, I began to troubleshoot, at which point the feeling of dread was at the pit of my stomach and decided to go to the local auto store and have the code read. It was of course the "P0A80 - Replace Hybrid Battery Pack" the exact message I didn't want it to be.
So I turned around and went back home, the entire time all the lights stayed on and monitored the SOC of the traction battery. It was charging, just increasing and decreasing quicker than usual.
View 8 Replies
Just returned from a mechanic who tested my 2004 Prius with 134,000. It indicated there is a problem with the main battery. I was trying to avoid the dealer but it looks like it is a must. He suggested I ask the dealer to remove the battery and bring it to a place in Clearwater Florida to have them refurbish it. If I try to trade in this car I won't get anything for it with the engine light on, right? What should I do? I replaced the 12V two months ago.
View 8 Replies
I have a 2003 Prius with just over 116,000 miles. When my wife cranked it a couple of days ago, the "Hybrid System Warning Light" came on.
As advised by the owner's manual, we didn't drive the car. We took it to the local dealership to be checked out. When I called for an update last night, they said that the computer indicates that the hybrid battery is leaking.
So I guess my questions are:
1) What kind of lifespan is typical of a 1st Gen Prius?
2) How many more miles are reasonable to expect from the gas engine?
3) Is there anything I should be aware of to make sure I'm not taken advantage of? (eg is there a credit for the battery since it has valuable components)
View 7 Replies
I replaced my hybrid battery of my NHW10 a year ago. now recently it shows the warning triangle. Once it went off after a long drive but now its permanent. is there a way to Diagnose what is the cause of this? If its a Hybrid battery issue, will it go off if i replace the bad cells?
View 3 Replies
My wife and I are driving our 2005 Prius with 130k miles and have experienced some weirdness with the car while driving. We've got the master warning light (red triangle w/ !), and another yellow (!) warning light, plus the center display shows a red car with an !. I've gathered that it means something possibly with the brake controller, so when I parked I put the e-brake on.
The car was driving fine with these lights on (we were in the middle of Canadian highways and couldn't stop anywhere) except that cruise control would not work.
Eventually, it actually went into limp mode, where we would floor the pedal and the car would barely accelerate. Pulled over, turned it off for a few minutes, then back on and it drove fine, warning lights still on.
I just replaced the driver's front wheel hub, and I can hear the passenger front going bad, so I'm suspicious that this may be related. Just replaced the 12v within the last few months with an Optima.
View 9 Replies
I have a 2005 prius with 84,000 miles. The car is running fine but the main red triangle light came on. I took it to toyota and they said I needed a new hybrid battery.
View 10 Replies
2001 Prius
I was able to pull codes this evening ( no subcodes).
The codes are as follows:
P3000, Battery Control System Malfunction
P3030, Battery Voltage Detective Line Snapped
Will the P3030 cause a P3000 to pop up since it appears I have one of the 19 voltage detect lines corroded or broken?
Once I fix this issue, is there a chance that the P3000 will disappear?
I was just getting the triangle and the Main Battery error on the MFD up until yesterday. Yesterday, the ! with the car came on (Hybrid system) on the MFD. I did not check any codes until today. Car will currently not start at all.
Aux battery voltage is confirmed to be 12.3 volts via the MFD in the diagnostic mode so it's good to go.
No one around has a scan tool that will also pull the subcodes.
View 12 Replies
I have two Prius's, a 2008 and a 2005. My 2005 with 129k miles on it is the one in question. Recently I got a check engine light with the code P0A80 and P3016. I purchased a pair of tested to be good cells from Ebay which finally arrived in the mail yesterday. Today I finally got around to installing it and everything was pretty self explanatory... One of 28 cells tested to have 6.24v in block six and all the others had between 7.98-8.00v all around. I went ahead and replaced the bad cell with the new one and put everything back together and now the car will not start.
Cliff notes: Replaced bad cell in main battery back due to CEL P0A80 and P3016.
Car will not start, only turns on...
Getting error message on the radio screen about the Park position is not correct and to park the car on a flat level ground with parking brakes and try again.
Have charged the 12v battery to make sure it has enough juice in it.
View 16 Replies
I have a 2001 Prius with about 110K which I have owned since new. It displayed the hybrid warning light (as well as check engine) 2 weeks ago and I took the car in to the local dealer.. After a little muddling around they came up with codes indicating that the computer for the battery was going. I purchased that Part Number: 8989047030 Part Description: electrical, battery, computer H.V. SUPPLY. and the dealer installed that part a couple of days ago.
Now the following codes (and only these codes according to the dealer) are displaying and indicating faults in the main battery: P3006 and P3000.
View 6 Replies
I was on my way home (a 50 mile trip on very rural roads) when my hybrid warning light came on. The car seemed to be operating fine, so I continued on. About 20 miles from home, the computer display lights flashed on and off and the car died. After coasting to a stop, I let it sit for a couple of minutes and turned it back on, and continued on. Warning light was still on. Probably ran about 7 miles or so and died again. This same scenario happened a couple more times, but I did manage to get home.
My Prius is a 2002 with a little under 150000 miles on it, and it has never given me any problems since I bought it at 70,000 miles four years ago. I will be calling the Toyota dealer tomorrow, but I wanted to ask whether or not this sounds like a possible battery pack failure.
View 8 Replies
I pulled the traction battery...remanned it with great success computer very happy with results... drove it for a week. Took it to Walmart to have oil changed... Got in car , started fine...new oil made motor even smoother....then in 200 yards at traffic light , motor died with unusual sound... pulled over and restarted...but would die. Lights all over dash on.
made it back to oil bay...engine would not restart.
pushed inside and would start and then die... then was rattling when dying
checked aux battery with testers , both indicated dead cell 10.25 volts
tried to substitute a new battery via heavy jumpers... got it to start then die..,..then no try at all
I have read forums ,,,that indicate after 3 tries on a dead aux battery , computer will immobilize it
Have tried replacing with a new lawn tractor battery .but seems the car is immobized . Read codes with Mini VCI, and was able to clear all codes but the immobilizer code.
View 14 Replies
My v8 2004 shows on and off L front flat tire caution sign. (may be once a week or so for last 1 month)it happens usually when i start driving in cold weather usually. when i turn my vehicle sign the pressure system is usually ok. i have checked the tire pressure and it is fine and it drives fine. What is wrong and do i need to take it to the delaer.
View 6 Replies
Lately, I am getting the uncomfortable "beep" and a "Check brake lights" message every time I get cough in a traffic jam and guess what: I checked the break lights and everything is OK. It took me sometime to be able to check the lights when the fault is on because usually it disappears after 30 seconds or so. Off course, when I take it to the dealer we cannot reproduce the problem (is not every time I break, is only when a break a lot of times in a short period of time looks like something is overheating) . The beep is driving me crazy!
View 9 Replies
