Pontiac - Montana :: Loud Clunking Noises From 2005 Minivan SV6
Mar 21, 2015
I have a Pontiac Montana minivan SV6 that is making strange clunking noises from possibly the rear or middle of the van when I go over a bump, large or small. I have had it in to our local mechanic and the local tire/repair shop and transmission shop. They have not been able to locate a problem other than agreeing that there is a noise.
Our mechanic replaced the front struts and strut mounts, the rear shocks and has gone over the entire suspension and transmission more than once. The noise is very loud, like something is broken but despite three separate shops checking it out nothing can be found.
Any possibility is could be something with the automatic side doors, such as the motor being loose or something strange like that? If it didn't have this clunking sound the ride would be very smooth and quiet. It doesn't affect the ride at all. The other bit of info here is that we haven't owned this van for very long, we bought it as is thinking that it needed shocks or struts. They've been replaced but the sound is still around!
View 19 Replies
Advertisement
I own a 2002 Pontiac Montana van with 36,000 original miles. The past year it started making a loud whining noise that seems to come from the rear of the vehicle. It seems to be worse in summer than in winter. It iis really loud when turning into a parking lot or when turning sharply to go thru a drive thru at a restaurant. I have taken it to several mechanics and also to a dealership, and no one seems to be able to find the problem.
View 4 Replies
I have a 2006 Pontiac Montana SN6. Last summer my brother took me to his favorite outback place in Arizona via 8 miles of dirt roads. When we were almost back to the pavement I heard a loud, low pitched, (a low "B") thumping sound. I stopped, thinking some part of the suspension was loose, but couldn't see anything. I've seen 6 mechanics since and still have the thump when we cross a bump. Yesterday a mechanic decided it was the front of the gas tank hitting the floor of the car, and he pushed the tank to show it made the low-pitched thumping sound. Now it is 10 times worse.
It happens only when the driver's side rear wheel goes over a bump. It didn't used to be every bump, just the significant ones. Now it includes less significant ones too. I took the chairs out of the back, pulled up the carpet, and laid my ear against the floor board to see if I could pin point it. It seems to be in front of the rear wheel, about even with the back of the door frame, 14 to 16 inches into the car. It does not seem to be a vibration against the floor of the vehicle, but may be something hitting the fuel tank. That is now my conclusion since I can't see anything loose, and it isn't hitting the car body. Also, the pitch of the thump would be different against the floor of the vehicle, but the tank makes a hollow low "B" when you hit it.
View 7 Replies
Vibrates above 45 mph. Did have tires balanced . Still happens.
View 3 Replies
I have a 2006 pontiac montana sv6 AWD
Once everything warms up the steering looses power at low rpm and starts making whistling noises around the steering wheel and can also be herd outside the car somewhere.
I have just replaced the power steering pump and flushed the system. I also replaced the belt and tensioner at the same time.
Air has been bled from the system and i have checked everywhere for leaks and cant see any and I am not loosing any fluids. But I still have a lack of power and the whistle noise sounds like it is sucking air into the system somewhere..
I still get some small bubbles coming up in the reservoir even tho i have bled the system soo many times now.. What is going on?
View 4 Replies
My 2000 Pontiac Montana squeaks while accelerating. There is about 55,000 miles on it. At first I thought it was a belt but it would squeak the whole time if so. It only squeaks (like a mouse), every time accelerating.
View 6 Replies
I have a 2001 Pontiac Montana that was overheating. It was low on coolant, and using coolant. I took it to a mechanic who checked it out and found exhaust gases in the coolant. He initially told me that it was a bad head gasket. After doing a bit of research, I am told that it could also be an intake manifold gasket. I know I am losing coolant, but I cannot tell where. I don't think it is going into the oil, as my oil level does not go up. I do not see coolant leaking below the vehicle, so perhaps it is going into the exhaust? Or leaking slowly on top of the engine where it is burned off before it can go on the ground.
Is there any test I can do to determine which gasket is bad before tearing into the vehicle? I thought about sending an oil sample off to determine if I am getting any coolant in the oil, but I don't know if that would be useful information at this point.
View 9 Replies
I have a 2006 Pontiac Montana, The little engine picture came up on my dash. I took it to the car parts store to have the code read and it came up as an O2 pre-heater sensor. My husband has been trying to google how to fix it and can't come up with anything. It doesn't even come up as to where the part is located.
View 3 Replies
I have a 1999 Pontiac Montana that has recently started whining when I accelerate. It stops after I take my foot off the gas pedal. It usually takes about 15 minutes of driving before the whining starts. It started about 4 months ago and has recently become louder.
Van has 85K miles.
View 13 Replies
The passenger air bag indicator light got pushed in so I need to get the vent panel off so I can push the light back flush. I do know the surrounding of the radio pops off without any tools. But taking that off doesn't get me anywhere. I still don't see access to remove the vents.
View 2 Replies
My van will rev really high when started and may stay that way for most of the day. Sometimes once it is turned off it will restart just fine. but when it is revving like this you have to hold the break down at stop lights, constantly slow down because it wants to take off. Now it is stalling when driving slowly. the throttle positioning censor has been replace a couple of times.
View 4 Replies
I have a 2001 Pontiac Montana van, when i drive i feel like there is just not enough power there. Most of the time when i hit 30mph the engine drops in power, hard to explain so I will try my best. I get in turn the key starts right up with out any hesitation what's so ever! I leave for work, while driving when I come to a stop sign and stop and take off its gets sluggish so while my speedometer is going up my movement is not changing as it should so needless to say I have to do 80 85 mph just to keep up with the average moving can at 70mph.
Once in a while I will give it some gas and let go of it and it would back fire a little not sure why. Recently I had new head gaskets put on cause temperature was not staying where it was suppose to be, they smooth out the headers and did a tune up, not sure about the timing, New fluids, once in awhile the temp would climb but that cause of the fans. Took it to AutoZone they did a obd code check came back with O2 senser and nothing else, so if I replace this will it bring my van back to normal running operation? And would it be anything I could check to rule out?
View 6 Replies
I have a 2006 Pontiac Montana SV6 with 80,000 miles on it. Recently the dashboard warning "check gas cap" has started coming on. I have replaced the gas cap and cleared the code and it is doing it again. It seems like it is more likely to do it when the gas tank is 1/2 or less full but it also did it today with almost a full tank. The code from the computer said P0455, what this could be?
View 7 Replies
I have a 2004 Pontiac Montana minivan. I get a hard downshift from 2nd to 1st only when the engine is cold - especially noticeable in cold weather. After a mile or so of driving (or a few minutes of idling) is shifts fine. All upshifts are fine all the time. The tranny fluid level is fine and is in good condition. What it could be?
View 9 Replies
I have a 2002 pontiac montana that needs the head gasket replace. Mileage is 152,000 miles with a v6 engine. I would like to get at least another 75,000 miles once the repair is done. Is it worth doing as alternative is to scrap the van and buy a new vehicle...
View 3 Replies
What is causing the engine to sound like it's not getting enough gas AFTER we turn off the A/C? The two times we have used the A/C, after we push the button to turn it off, the engine sputters like it is going to die ... sounds like it is not getting enough gas. It has over 178,000 miles on it and it sat for about three years before it was given to us.
View 13 Replies
I flushed out my cooling system through the radiator with distilled water four times. It's a 3 gallon system, but I could only drain/fill a bit more than a gallon each time.
I figured that by the end of it, it's mostly distilled water so I only added antifreeze concentrate at the end. How long should I let the system circulate before I considered it well mixed and ready to test the concentration?
View 9 Replies
While driving my recently purchased minivan (a 1999 Pontiac Montana) for about 40 miles, I noticed the temperature gauge was reading high when I wasn't moving very fast, though short of what appears to be the overheating zone. Opening up the radiator revealed no coolant that I could see, but plenty of brown sludge. Looking under the oil cap revealed more brown pudding-type stuff (that wasn't there when I did an oil change when I first got it).
The lack of coolant makes me nervous that the engine might have overheating without the temperature gauge reading it properly. Is that possible? The heater was working, which searches seem to suggest means there must have been some in there.
I figure that either the intake or head gasket must be bad, so I'm nervously setting out to replace both using a gasket set like this: [URL] .....
What I'm more worried about though, is clearing the cooling system out of all the gunk. It sounds like oxalic acid and washing soda and back flushing might work? But I'm anticipating a large quantity of sludge, oily, rusty coolant water. How am I going to dispose of it all?
View 19 Replies
I had a code for the EGR valve stuck open. I tried cleaning it but it didn't work (and didn't seem that dirty). Then I tried replacing it. Both times the code came back. What should I do now? I reset the code each time by disconnecting the battery.
View 14 Replies
I have a 2004 Pontiac Montana, and it just started making a low buzzing vibration noise when it's in motion. tone/pitch only changes with vehicle speed, not engine RPM. It becomes noticeable at about 20 MPH. Pitch starts low, gets a bit higher and faster as speed increases. Have looked for anything loose, nothing found. Braking is not a factor in the sound. Tires are good, Engine doesn't seem to be tied to the noise. Nothing noticed on body panels, air dam, etc... I suspect either transmission or possibly U-Joints.
View 3 Replies
I have a 2004 Pontiac Montana with 90K. If the overnight temperature has been below 40ish, there is a noticeable hesitation or stumble (almost as if the engine cuts out for a second-but never actually stalls out) on the 2 to 1 downshift when braking to a stop while the vehicle is in open loop. As the engine warms up the stumble becomes less noticeable until the temp gauge reaches the 1/4 mark at which point the stumble is gone. It won't return until the following morning - the next cold start. Our mechanic has cleaned the Throttle Body and the MAF- no change. Their transmission guy said he did not think it was a tranny issue. It has no other symptoms and seems to shift normally at all other times. What to do next??
View 11 Replies
