Plymouth - Sundance :: 1991 - After Replacing Fuel Tank Gas Gauge Showing Less Than Empty?
Aug 29, 2013
I recently replaced my gas tank in my Sundance, it was getting very rusty around the sending unit area and was starting to leak. Everything is back together and it is running well with no leaks. The new problem that it has, when the car is running, the gas gauge shows less than empty, even though it has a considerable amount of gas in it. When I shut the car off, the gas gauge slowly moves up to where it normally would be when it would be running. Did I somehow mess up the ground or did I cross something? This is my daily beater car and need a working gauge.
View 1 Replies
Advertisement
Ok so the fuel gauge says empty and the low fuel light stays on even though the tank is full. I'm assuming its either the gauges or the sending unit. If it is the sending unit where is it located on this car?
View 4 Replies
The installation of the new 50 gal. Titan tank went well overall. Start up was smooth with no leaks but the fuel gauge is showing empty with about 45 gallons in the tank.
The sending unit was properly oriented ("clocked") so I'm guessing the electrical connector is not secure at the top of the sending unit. Not sure I can reach the connector without lowering the tank somewhat.
View 6 Replies
I just bought a used 2004 F-350, 4x4, crew cab, short bed, 6.0L diesel. I'm having a WTF moment on fuel. Gage indicates just under 1/4 of a tank of diesel but the on-board computer is flashing like crazy stating 5 miles to empty, what the hell is that all about?
View 1 Replies
My wife was driving my ' 91 Sundance when she said it started pinging real bad. (Not sure if it was overheating at that time as the guage doesn't work) Trying to call me about it on the phone, her phone didn't have coverage, so she kept driving it. It started to lose power, then it backfired and a little cloud of white smoke out the tailpipe. She pulled in to the driveway, turned the key off and it kept running for about 2 minutes. Once it shut off then the engine was steaming. I'm thinking a blown head gasket?
View 2 Replies
Its been happening often where it shows empty (when i really have half a tank) and my avg mpg resets itself. As I am driving it will go back to normal.
View 11 Replies
2004 Venture LT ... The newest problem I am having that I haven't resolved is that the fuel gauge is showing empty, low fuel light on, range on trip computer says (E). I repaired the wiring harness's on the left and right front due to ac leakage, and I also repaired the pass through behind the drivers seat. This seemed to resolve many of the problems I was having.
The thing I noticed is that before I repaired the pass through connector the gauge would work intermittently but now its totally dead. I find it unlikely that the sender and the connector would go out at the same time. Any wiring diagram of that connector, or at least which color the wires are for the sending unit and the resistance values I should get?
View 14 Replies
I have a 2004 F150 XLT 5.4 L 79,000 miles. Yesterday i was driving home turned a corner and the low fuel light came on and the fuel gauge is well below empty. I had approx 1/2 tank of fuel when it happened. I have since filled tank all the way but the gauge will not move and low fuel light stays on. Everything else is working fine! I have never run the truck low enough on fuel to make the dummy light come on.....
View 5 Replies
I have a 2004 Hyundai accent hatchback with 225000km. The first time I drove it for over an hour, 1 trip no stops, the fuel gauge dropped to empty while there was 3/4 of a tank. The 2nd time I drove over an 1 the fuel gauge dropped again and the gas light came on (again around 3/4 of a tank). My mechanic said until it does it consistently he can't diagnose so I let it go.
More recently, driving it to and from work 5 days, plus some extra city driving, I used 1/4 tank the full week. Today I picked up 4 winter tires and bringing them home (approximately the same distance as my work) I used 1/4 tank right there. I understand it is weighed down, but could it really be that much? What is causing the fuel jumps and gauge jumps? I've already had the float replaced.
View 2 Replies
Full tank and the gauge reads empty. Has happened to me a few times. Occurs after a fillup and disappears after the car is left to sit for a while off. I would hate for this to happen on a long drive. Dealer hasn't been able to duplicate the issue. Am wondering if this might be related to the hiccup in some way. Also, am wondering if this is a fuse issue.
View 8 Replies
My 01 sl2 wont start and the gauge says that the car is empty (before this problem, everything was working fine). I know that I have more than a half tank of gas, the car continuously turns over but wont start. I replaced the fuel pump and still it wont start (not to mention that the tank was more than half full at the time). I checked all the fuses and relays and everything seems fine. I am not even getting gas pumped to the filter.
View 9 Replies
I'm new to the Gen 1.
All has been well in just over a month of driving the car and about 3300 miles logged. The 12v, Aux battery was dead from the car sitting on the lot for so long (I replaced with a new OEM Toyota 12v battery) After a week of the car experiencing dim headlights, and various other electronics
No codes or CEL though.
Now that the 12v battery has been replaced, the car runs exceptionally well, aside from an intermittent fuel gauge issue where it only reads full bars (completely full) if I let the tank get to empty (Flashing single bar) or close to that. If I fill the tank from s
View 4 Replies
I have a 2009 Sonata SE 3.3 with about 35,000miles. I am the second owner.
I believe that my gas gauge or the sending unit in the tank is bad. The gauge will show empty when the tank has fuel and then it will sometimes read normal.
View 10 Replies
So yesterday I was driving home from work.. I know my tank was 3/4 full. All of a sudden, my low fuel light came on and my gas gauge needle went to empty.
The needle sits at E, but it still says about 20 miles till empty on the MFD. When I left the house this morning, it said 5miles till empty.. by the time I got to work, it said 20. Kinda odd..
I will hook up the vagcom when I get home tonight, any area I should scan for? or just a complete scan? There is no CEL error on the dash though. What I could look at to fix this?
View 4 Replies
When do you typically see your fuel light come on? I never need to let the tank run down very far but the other week I was curious about this. The fuel gauge was way less than 1/4 tank left and the range display was ~50kms. When I filled up shortly after it looked like there still would have been at least a gallon in the tank still.
Just feels weird because my last car (Camry) would throw the fuel light when you still had a full 1/4 left in the tank.
View 11 Replies
I just filled up my gas tank and when I turned on my car the gas light turned on and the needle read empty. But before I put gas, the gas light wasn't on yet and. Was at 1/4 of a tank. Maybe I filled it up too much and it'll resolve itself after the gas goes down?
It's a 10.5 if it matters.
View 4 Replies
My fuel gauge acted pretty weird today. When I left my house today it was just above half a tank. I was sitting in traffic quite a bit and then looked down and it was below the e. I knew it wasn't empty so I kept going. Got to work. Went for lunch and it said full drove about 5 mins to eat and it went down to half a tank. What's going on? I am thinking of the fuel sender or wiring?
View 3 Replies
For the second time in 6 weeks My 2004 F250 Powerstroke has run out of fuel with the gauge showing a 1/4 tank. First time it was just under a 1/4 showing I had it towed to dealer and they told me it had sucked in the filters requiring replace and flush of system. The told me that this happening very often and I would be replacing all of the injectors at my cost. I told them that I didn't want this to happen again and to check out the fuel gauge and sending unit and replace if in doubt. Well they checked it out and found nothing wrong, told me it was accurate and should not be an issue again. Now 6 weeks later on the Friday night before a holiday, it did it again, this time with over a 1/4 tank showing. I really don't want to spend 6 grand replacing injectors and would really like to trust my truck again, getting to the point that I'm nervous at 1/2 tank.
View 9 Replies
I bought a 2006 F250 6.0L a couple of months ago, from a dealership. It's been bulletproofed already, has an intake, coolant filter kit. Has 95k (mileage). Today, my fuel gauge dropped to empty from 3/4 of a tank for a couple of miles and set off the CE light. I hooked my scan tool to it, to clear the code (P0460).
After just checking other things out with the scan tool. I cleared it and went on... I had to run to the store, later on... I was pulling out of the neighborhood and the gas pedal was a lot more "touchy" and the truck, responded to it and it launched pretty good and blew a good amount of black smoke.
Do any of you think this has/or had a tuner on it and I may have activated it with my scanner?
View 6 Replies
1994 Plymouth Sundance Duster (4 door, automatic transmission) with 97K miles.The power steering fluid leaks every now and then, and sometimes I have to fill it twice in a week. There is some fluid leaked onto the ground.1. What possible causes could these be? (How to diagnose the problems?) and how much might it cost to repair? 2. I need to drive the car ~2,000 miles from Chicago to LA in August. What major checks do I need to do before the roadtrip to ensure a worry-free ride? (I need to fix the A/C for sure). Also, is this car able to haul a U-Haul trailer (5' x 8' in size) with household goods worth a small studio apartment?
View 6 Replies
I have a 2010 2.0t passatt wagon and the gas gauge falls to empty and it shows --- in the miles to empty.it is doing this every second day now..
View 1 Replies
