I have a gas leak coming from the r/s rear of the tank. The exposed fuel lines all look good. It seems to be dripping down from the top but I can't see anything unless I drop the tank down. I ran the smoke tester but don't see anything comming out. Could I have overfilled the tank??
View 6 RepliesI have the dual tank setup & this is my problem.
Last year I replaced both tanks - the front was leaking bad and rear was starting to leak. After replacing both tanks, the rear tank (which I was using before) was unusable - it would idle fine and when applying throttle would stall out. The front tank's gauge did not work.
This week I pulled both tanks. Had new gauge assembly put on front pump unit. Also had the rear pump replaced with a new (rebuilt?) one. Installed both tonight. Now the front tank is running fine with a gas gauge. I Filled up the rear and once I had about 16 gallons in, fuel started leaking from the front top of the tank it looks like (where in-tank pump is). This leak has continued as the truck was turned off too. I think it may have stopped now, but its dark and I am parked on a hill. As another problem, I still have the same "stalling" problem. The rear will idle fine, but start to stall out when a load has been applied.
So to summarize:
- What is causing it to want to & stall out?
- Why am I leaking gas?
It seems to stop dripping gas after (maybe) the pressure is lower from leaking the gas out. Also, when 1st starting it up on the front tank, it wants to stall out...probably from the gas that leaked out while it was shut off? The truck will run for about 1/20th of a mile on the rear tank when initially starting it up before showing signs of stalling.
I have a fuel leak below the rear passenger seat, just off the fuel tank, something that looks like a filter or fuel pump, dripping fuel and after an hour it just stops, makes me think it`s empty. What is that thing anyways, has a hose running all the way up front? I have 2004 V8 beauty.
View 1 RepliesI have a 2005 V8 Phateon. The molding on the driver side and rear passenger side door molding is coming off. Any clips you have to buy or can you just slide it off and put it back? Don't want to break anything trying to take the molding off.
View 2 RepliesI recently purchased a used 1999 F250 Super Duty with about 150k miles on it. The truck runs great and I have no complaints but there are a few things that need to be taken care of. It looks like there is a very small fuel leak where the filler neck ties into the rubber hose that runs into the fuel tank. There is a thin film of diesel along the side of the tank, on the leaf spring, the air bag and various other places. Nothing is dripping. I want to drop the tank and replace the hose. The Haynes manual says to depressurize the whole fuel system--is this really necessary if I don't plan on doing anything to the system aside from dropping the tank?
View 2 RepliesI have a relatively decent standard of DIY mechanics, but I have never worked on a Hyundai before.
I have a leak coming down the drivers side rear shock absorber (the bit that bolts onto the swing arm) this has obviously resulted the the rear of the car riding low, but, is there something I can take apart and replace or do you have to replace the whole thing.
it seems likely that it could just be a seal broken somewhere.
I've experienced a fuel leak, I've checked all over, and the only thing I've came up with so far, was maybe its coming from the banjo bolt going into the front of the driver side head.. I cant really get to it good enough to tell though..
View 6 RepliesI have developed a leak coming from the top, driver side, rear of my engine and I could not figure out where it was coming from. I took it to a reputable shop for diagnosis and they tell me that the rear leak is coming from the transmission lines.
The weird thing is I never thought the leak looked like ATF. They also told me that it looks like the stock radiator/cooler has been bypassed so I have no cooler.
Should I assume that the stock internal cooler failed and that is why the PO bypassed it? Also is there a decent write up on deleting these lines and running soft transmission lines to a aftermarket cooler?
I have a 1986 F150 6 cyl, dual tanks, no AC, manual fuel pump. Just recently, I have been having issues with the tanks. At first it seemed like the back tank was siphoning from the front tank. Now I have fuel coming out of my front tank filler neck. When I open the back tank gas cap, there is enough pressure to spray me with gasoline. I am not familiar with the fuel delivery system of my truck ...
View 2 RepliesMy 2006 Sonata GLS 3.3 started dripping water the other day from the ceiling handle. The drain hoses do not appear to be plugged, water runs freely out. I pulled off the headliner around the place of the leak, and I can kind of see a plastic attachment with the drain hose on the corner of the sunroof frame. The water is coming from somewhere from it, but not from the hose attachment.
My question is, Do I have to replace the sunroof frame? Is it difficult to do? Or can I get away epoxying around the leak if it's small enough? In any case, how hard is it to remove the headliner?
This is on my sig truck. I can hear the pump running, and a sound like fuel spraying around inside the tank, but not getting any up front to the carb. What is the most likely culprit for this? Can't get the bed off, or get the strap bolts loose, so I haven't been able to "eyeball" anything, yet.
View 3 RepliesMy '99 Passat V6 TDi has just developed a fuel leak somewhere around the tank outlet/inlet. I'm just going away on a trip (in another car) and can't get underneath to have a look-see just yet. Any typical problem in this area?
View 1 RepliesThe exhaust pipe connecting the cat and muffler is broken. However, the bolts connecting them are so rusted that look like one piece. Any tips on removing them off? I am afraid that PB blaster won't work in this case. I am thinking of drill them through, but afraid of damaging the cat.
BTW, my car's fuel tank has some leak. I can smell the gas. Is it safe to use a torch to remove freezing bolts?
I have a small fuel leak (97 Legacy Brighton wagon). The leak is detectable on the garage floor under the gas tank although I'm not certain that the gas tank itself is actually leaking.
View 3 RepliesI've had the Titan fuel tank installed for about a month now and am loving the extra range, although this morning I walked by the truck and got a slight whiff of diesel by the fuel filler door. I pulled out the flashlight to take a look, and noticed a really small, faint trail of diesel fuel running down the driver's side of the tank near the rear strap.
I crawled under the truck to inspect it as best as I could in the driveway, feeling around the sender, filler, and vent tube connections, and didn't notice any obvious puddles of diesel. About the most I got was some dampness around the sender unit seal, but it wasn't much, and could even be residue from the fuel lines dripping during installation of the tank. Based on where the trail down the side of the tank has formed, my best guess is it's going to be a filler or vent tube hose clamp that I didn't get tight enough.
Unfortunately I just filled the tank up last night and am headed out camping for the weekend this morning. I followed all the install instructions exactly, making sure to check the torque on the sender unit seal four times before installing the tank back in the truck because I didn't want to deal with any leaks, so I really hope it's not that seal. I also filled the tank up to the brim right after install and crawled all around it a day or so later and noticed no dampness or leaks. Needless to say, I'm not looking forward to dropping the tank again and then potentially waiting on parts if something is defective. I'm waiting on a call back from Titan to get their advice.
Below are a couple pics of the weepage. Obviously not a huge leak, but something I want to get taken care of ASAP.
The gas cap light comes on when my tank is low on fuel, dealer says it is a small evap. leak. I have an '07...
View 10 RepliesI have about 500 miles on my 2008 R32, and today I noticed while sitting in the car with it running that there was a noticeable buzzing coming from the fuel pump. It sounds like it is coming from the pump under the tank itself. Hear this coming through to the cabin? Rather loud, I wonder if this issue has already been reported with other 3.2 VR6 setups.
View 22 RepliesNew to me 2003 F250 Super Cab 6.8 V10. Great condition inside and out. 68,000 miles. Began smelling fuel (gas) a few days after driving it 250 miles from purchase location. Traced leak down to the top of the gas tank. Staining was visible around the rear vent. Applied about 5 psi to the tank and sprayed soap around until I saw bubbles coming from a hairline crack at the rear vent connection. Its where the fitting for the hose comes out of the tank.
My first choice would be to hot weld the crack. I'm not very comfortable with the idea of a heat source near a gas tank. I'm not sure, but the heat from the plastic welder might be hot enough to ignite fumes? Second option is to try some industrial 2 part epoxy (PIG) and seal it with that. Is there pressure inside the tank, and if so how much? Can try this fix with epoxy or JB Weld?
I have a 08 r32, hearing a popping noise that sound like its coming from fuel tank. When sitting not running in garage, bout 15 to 20 seconds between pops. Maybe evap system? Just notice after filling up with gas.
View 4 Replies1996 F-150 5.0... So I bought this truck a couple months ago for a really good price and its my regular vehicle that I use daily. While driving I switched tanks from the front to rear and when i reached my destination i noticed that fuel spilled from the cap, I opened the cap and fuel overflowed. I've read in forums saying that its the Fuel Pressure Regulator or the Fuel Tank Selector Valve . It still drives and runs fine, but I would like to know which part its specifically causing the problem?
View 1 RepliesNot my Elantra, but an '05 Santa Fe 2.7 ... I have a fuel leak from the driver's side of the tank. It has continued leaking while the vehicle has been parked with about a quarter tank of gas, even after 8 hours. I can see where it is leaking from - a quarter size depression in the tank - but I think this is some sort of plastic pan, not the tank itself.
Is there is a plastic pan under the tank?
If so, does it cover just the bottom half?
If it is a plastic pan, is the tank itself plastic or metal?
If it is plastic I don't see how it could develop a leak, so is it possible for the leak to be at the top of the tank due to a fuel line problem (maybe some mysterious syphon condition)?
I searched the forum and leaking fuel tanks don't seem to be a common problem. My usual parts store doesn't even have a listing for a replacement fuel tank.