OK, so I've been getting the "Tyre Pressure Monitoring System Fault" warning message repeatedly for some time now. I had the "G" code TPMS control module installed last week (under extended warranty) thinking that that should fix the fault. However, the fault continues.
Do this fault might be due to dead or dying batteries in the TPMS wheel units (not covered under extended warranty)? If not, what else could it be?
After 3 trouble free years my car had a different TPMS problem, with TPMS FAULT message popping up. The dealer initially changed one or two sensors and then the most updated module. For 1 day there were no problems and while driving on the highway the malfunction warning came up again. Now they are suggesting it could be related to the tires that are not the original ones, but same size and specs and I have been driving on them for a year without any problems.
View 4 RepliesRecently replaced the front tire pressure monitor sensors from my '04 T V8. Since then the readings are fine with the only exception that I do get the "FLAT TYRE" warning a few minutes after I start my trip and for about 2-3 minutes until it goes off again. Shall I take it back to the dealer for reprogramming, is it something else I should look for...
View 1 RepliesI have 2004 V8 Phaeton ,the message LEVEL FAULT WORKSHOP. keeps appearing ,then disappearing, sometimes it will stay until the car is turned off,. When it comes some times even on long highway journeys I wont see it at all!. When it comes on nothing seems to change.
View 6 RepliesSo I had a bent wheel and had to replace it and the new one did not have the TPMS sensor so now I get a permanent low tire warning message.
Is there anyway to disable this warning? Alternatively how costly is it to get a new TPMS sensor?
I've been getting this "system fault workshop!" error message popping up like crazy. Its got a picture of a key, and makes the audible beep when it appears. on a short drive to work, maybe 10 minutes, it will randomly come on and beep anywhere from 3-10 times during my drive. The car starts and drives perfectly fine. This has been happening for a little over a week now. I noticed one post about this before, but that owner seemed to have different symptoms as their car wouldn't start. I really would hate to bring it into the dealership, as I've just paid them a small fortune fixing different things to finally get down to the bottom of it to find out i needed new fuel pump modules.
View 3 RepliesMy 2004 Phaeton with a little over 100k miles on it has been giving me a problem with the air ride suspension. When starting the vehicle, a "Level Fault - Workshop" message is displayed on the instrument cluster, and the car has been slowly sinking as the air ride (I presume) slowly deflates. Around 10,000 miles ago, I had a problem with the suspension, but that time the car immediately and actively sank; this was solved by replacing the air ride computer (it is the B, not C-type). I've tried replacing the computer with another B-type computer, but to no avail. The local VW dealer and an independent import car garage have told me some things, and I would like to learn more about this problem and possible ways to try and solve it.
1. I have been told that no voltage is making it from the computer to the left front sensor. Dealer says its the computer, but could this possibly be the wiring harness or a bad connection? If so, how do I get into the wheel well in order to test this hypothesis? My best guess is it isn't the computer, as the car never actively sank (this happened when the original computer went bad).
2. I have also been told that the right rear sensor is bad. Is this a part I can replace with a modest amount of auto knowledge? I do my own oil, replace brake pads/rotors, etc. If so, any drawing/maintenance manual parts list available?
3. I have heard conflicting reports as to a freshly-ordered sensor being and not being compatible with the B-type computer. Dealer told me new sensors will only speak to a C-computer; independent garage told me new sensors will speak to my B computer. Who is correct?
From a few hours of internet browsing from the first instance and this second instance of failure, it seems this is a somewhat common issue with the 2004 Phaeton.
The warning in the title has been appearing for months. Push reset and the display message goes away but the orange light stays on. No rhyme or reason. Sometimes it's gone after a restart for a day or two. Sometimes it stays on no matter how many times the truck is shut down and restarted in a day.
So I finally took it into Ford for service today because the truck is still under warranty. They ask if the tires have been replaced. Obviously they have because I've got BFG KO2s that are a size or two bigger than stock. But I explained that the tires have been on for several months and that the issued did not present itself when the truck came out of the tire shop. It didn't happen until a couple of months later.
So they tell me that their tool can't even detect that any sensors are present and that they'll break down a tire to check and see that a sensor is there. Two & a half hours later they tell me that they've ordered a body control module and cut me loose with the truck. They'll call when the part is here.
Ever since I bought my 04 V8, the TPMS warning light has been on due to dead sensors and a disconnected controller (G model controller), and I had just learned to live with the alert and the icon on the display for the time being. Last weekend I installed a 6 button cruise control switch and recoded per Michael's instructions. The switch works fine and everything was good. After a couple of drives with the new switch I noticed that the TPMS was not giving me the usual failure message or the fault icon anymore. If I hit the Vehicle button I still get the same fault message in the J523 screen but no warning in the cluster, and no warning upon startup. Ran a VCDS scan and the errors for the TPMS module not being there are still present as they always were.
View 4 RepliesI got a "Defective Wheel" warning from my TPMS system today. I haven't had a chance to check the pressures today, but they look fine. I had gotten a couple intermittent "Flat Tyre" warnings over the last few weeks. Those would appear briefly then go away. This warning came on and stayed on. I doubt it is simply a pressure drop from cold weather, because I would get the "Check Pressures" warning when that happens. I had never seen either of these two warnings before (Flat Tyre or Defective Wheel). Should I assume that one of the sensors has failed in a wheel?
View 22 RepliesI have just had my LHS battery replaced after ages messing about trying to get it done at a reasonable price and level of skill and the car feels like it is new. Once they had cleared out the erroneous fault codes, everything came back to life. For the first time, the central locking system works as it is supposed to, and the centre display in the binnacle no longer flashes. So everything's great - except the TPMS.
The dealer reported that it was working fine, and so it appeared, for about a mile, then the warning tone and message flashed up and I was back to square one. The same thing happened this morning. When I started the car, the TPMS was working, and displaying the pressures on the screen, and after about a mile, the dreaded warning tone and error message. If you think your battery is low, do get it replaced.
I have a 2013 F250 and to day the TPMS light came on with a low tire warning message. A little back history, I put new tires on the truck when I bought it and they currently have 9200 miles on them. I didn't like having the tires at the 80psi the tire shop set them at so I lowered them to 62psi right away and haven't had any issues with the low pressure warning going off. Today I was backing into a parking spot and the warning light came on with a low tire message. I checked all the tires and they were right where they should be, but when I got home I added another 5psi to see what would happen and the light never went off after taking it on a 10 mile drive.
My question is, do I have a wheel sensor issue or is something messed up in the computer? I know the door sticker says 75psi front/80rear, but I've been running the tires at 62psi for 9200 miles without trouble so I can't think that the pressure is the culprit. Also, does the spare tire have a sensor in it? In the manual in one paragraph it seemed like it does, but in the next it said that the spare doesn't have one so the light will stay on to remind you to change the spare out.
I just got the Air Bag Fault light and warning on my display for my 2006 Phaeton. I have not seen any posts on this topic doing a keyword search. This happened the day after I got back to my car at the airport parking and found a cracked windshield that is $825 for the glass alone. Not a good week so far.
View 9 RepliesA few days ago I got an Airbag Fault Warning while driving, since then the orange airbag light has remained on and at start up it gives me a "Airbag Fault" warning. Any remedies? The manual states to just take it in to the dealer.
View 7 RepliesI have one TPMS sensor that incorrectly tells me I have a flat when I do not. I presume the sensor is faulty because the wheel was moved to the rear as part of a recent service and the problem moved with the wheel.
What I find peculiar is that the flat tire warning comes at virtually the same time when I drive, about ten or so minutes into the journey, and leaves about five minutes later, usually not to return. Indeed, when I occasionally drive the car to work, I know when the signal will come on, within about .25 mile.
I have owned a Phaeton W12 for around a year and have got to know my local VW dealer extremely well. My latest woe is the hazard warning lights which refuse to operate. The dealer advises it is a fault with the J523 (?) unit.
View 4 RepliesI have just had what I feel like is a big problem. It started raining tonight( I don't know if it's related) and I got back into my car, after putting the baby in the rear passenger seat, and started it up and the "System Fault Workshop" warning came on, with a warning symbol next to my tpms symbol that is shaped like a key, and the "car outline icon" in the center had the rear passenger door light blink open. I hope that made sense.
I tried to restart the car to see if it would go off, and it won't. The infotainment doesn't light up, and the blinkers don't work, and neither would the high beams. So the steering wheel lights/controls are dead. Also my keyless entry doesn't lock/unlock the car. I couldn't find anything in the manual, and the only online I could find that might be related is the following: " the actual issue is/are leaky seals on the front latch solenoids/actuators, period.
I just tried to go start the car again, and the alarm started going off. Then I started the car to try and stop the alarm, and it kept going off...Then I thought the battery might have something to do with it so I opened the trunk with the key since the button in the drivers door wouldn't open it, and the alarm when off when I manually opened the trunk.....What am I going to do now?
The rear seat footwell lights are on, and you can see a youtube video of the warning lights at: [URL] ...
Because the battery gauge in the dash showed the battery being completely dead with no charge, I tried to "jump" the car with another car using jumper cables hooked up to the battery in the trunk on the drivers side. Again the alarm went off when opening the trunk, and when starting the vehicle, and the battery gauge was still completely dead.
One of my taillights stopped functioning last night on my drive home. The "check lights" message came up on screen, accompanied by a loud warning chime. However, it wouldn't stop. It kept flashing "check lights" over and over, and kept repeating the chime every few seconds for my entire ride home.
This morning, everything seems to be OK. The taillight is still out, but it's not chiming repeatedly (at least for now). What caused my Phaeton to freak out like that?
I'm getting a service now message on my display but no other warnings. Why this would be coming on?
View 7 RepliesYesterday my light went on for the exhaust warning. Does this mean I should now drive with a window open? And how serious can it be? Also, about 2 months ago I was told I need a serpentine belt. Would this have anything to do with the light coming on? You see, last time I wrote in here, I was told I needed new front brake pads and rotors. I was told from folks here that the dealer's quote was 2X what it should be, so I am hesitating to go back to same dealer.
View 24 RepliesI have a V8 engine, and I have been getting the coolant overheating warning come on once in a while.
The engine fans go crazy, and the temperature needle on the small round gauge climbs all the way to red then the coolant overheating warning comes on in dash screen.
This can happen right after I turn the car on, or on occasion, it can happen as I am driving around the city.
I stop, switch the car off, and I turn it back on after a minute, and the car is just fine. So, basically, it doesn't seem like the engine coolant is actually overheating, but the fans and warning systems seem to think that they are. The fans are pretty loud, and its noticeable when they go on, and when this happens, I know that the needle will go all the way up and the warning will go off. I also know that if I turn the car off for a minute, and it will be just fine.
The conditions are random for when this happens. So its not when its particularly hot or cold or anything predictable. Could this just be a sticky thermostat? Is it a bad water pump? Bad battery?
The trouble is that now I am afraid I cant take a real drive. Around the city I can just pull over, but I am afraid to take the car two hours out or something.