Phaeton :: Coolant Leak - Bad Water Pump
Feb 2, 2014
Noticed about a gallon of coolant on my floor the last 4 days. Got it pressure tested and was told bad water pump. Had it changed with timing belt and tensioners. Got home, next day, same thing. Coolant everywhere. Also, do I really need to put G12++ in as coolant? I've been using it but the shop put some green stuff in it.
I have a 2005, V8, Phaeton with 181,000 miles. Also, my car overheated, got the coolant too hot warning, 270 on gauge, let it sit 5 minutes, no problem afterwards. Should the thermostat have been changed also?
View 3 Replies
Advertisement
So I parked on an incline last night for ~an hour or so, and suddenly my coolant light came on and my reservoir was completely empty. Sure enough, all the coolant had leaked out of the car. I am sure it's the water pump, but it doesn't seem to be a complete failed one because I picked up and filled my car's reservoir back up today and it hasn't leaked at all.
My guess is the pump isn't bolted on right and on the incline, the gasket is breaking it's seal, or some oil dripped down onto it when on the incline and the gasket swelled.
Nonetheless, my dealership is covering it on Friday, and they said they finally are making them with metal housings instead of plastic, and recalls should be going out soon (win for the MKVI crowd).
View 2 Replies
1994 - 3.0 .... Back behind the water pump there is a stream of coolant what could that be. Water pump has been replaced earlier last year I thought that fixed it,there has always been a mystery leak..
View 6 Replies
So my coolant system woes have continued! I recently replaced my thermostat ,thermostat housing, thermostat cover and all of the rings and gaskets. I finally stopped the leak on the driver side which seem to be the thermostat now about seven days later I am experiencing leaking on the passenger side. I walked out from work today and noticed I pool of coolant under the car. I can't tell exactly where it's coming from but it's coming from one of the components that runs off of the large belt. I snapped a few pics from the bottom of the car I don't think this is the actual component that's leaking. I think the leak is just falling off of it . I was wondering where the water pump is located.
View 5 Replies
My 92 Explorer 4WD has a coolant leak somewhere at the front of the engine above the water pump. I assume it's the lower intake manifold gasket leaking. The engine has 170k miles. I'm also seeing a small amount of white smoke, possibly steam when the engine is running. It's somewhat heavy when I start it up but mostly goes away once warm, so I suppose it could be steam, but could be coolant from either a head gasket leak or lower intake leak.
I also get a lot of water from the exhaust dripping on to the floor and the smell of the exhaust could be that of coolant, it's hard to tell. There is no coolant in the oil. I was wondering if I should go ahead and change the head gaskets while I have the intake out. Is there anyway to be certain the head gaskets are fine? I'd hate to change the intake gasket to find out there's a small leak in one of the head gaskets.
One other thing: I failed emissions because my CO was too high, but my HC and NOx were very low. Could this be an indication of coolant entering the combustion chamber? Just wondering why my CO was so high yet everything else passed (Massachusetts emissions).
View 8 Replies
I was driving my 2005 RX 330 (138k miles) North on I-75 through Atlanta in rush hour traffic when the car completely died in the left hand lane w/ no shoulder. GDOT stopped six lanes of traffic to push us up and over a couple of hundred yards to a right shoulder. It was determined that due to a coolant leak from the water pump the timing belt malfunctioned and shredded.
I had heard that the water pump should be replaced during the 90k maintenance when the timing belt is changed, but my water pump was not replaced according to my maintenance records. I understand from reading a couple of posts that this isn't always required but that they do check the water pump. Is this correct? And if so should they have noticed that there was a potential problem?
View 9 Replies
One last issue with my 2000 B3000 3.0L. The leak seems to be on the left (passenger) side of the water pump very near where the bottom radiator hose connects to it. I can't find any loose bolts. It does not leak while driving the truck or soon after. It has to sit for several hours or overnight before it shows up. There are usually 3 or 4 wet spots where it drips from the water pump to the frame to the driveway. It is small enough that I only have to fill up my coolant tank every 1 or 2 months. Could this just be a small gasket leak? It's been happening for about a year or so I think. I replaced the radiator about 2 years ago. I've been expecting it to get worse or bust loose and have been checking it very often. I've never seen one not leak while running like this-has me puzzled.
View 6 Replies
A little less than a year ago I decided to change the timing belt & water pump on my then 61k miles '05 V8. I bought the BlauParts timing belt kit and rented the tools from them also. The install went without a hitch, the old water pump gasket came off nice and clean and I installed the new water pump gasket without any RTV as per the instructions.
A couple of weeks ago the Phaeton hit 65k miles so I did an oil change and while I had the belly pan off I noticed a small whitish pink spot on the belly pan, right below the crankshaft pulley. Looking closer I found coolant traces that came from the water pump area. I cleaned it all up and decided to drive it for a few weeks to see if it's an actual ongoing leak or if that was maybe just an old leak that might have happened just after the install. Unfortunately it's an actual leak ..
First I thought maybe it's leaking out at the gasket but closer investigation shows that the leak is actually right below the pulley at the bottom of what looks like a freeze plug at the front of the water pump. Is this a common area for a leak with this type of water pump? It's only been installed for 11 months and 4,500 miles. Btw, the pump in the kit is a Saleri model GD42107.
I'm really bummed about this because it's a lot of work to swap a water pump out and I'd hate going thru all that work again (and having to rent the tools again). Question is, can I swap the water pump out without putting the front bumper into the service position? From what I recall the only clearance issue might be finding a puller that is short enough to pop off the camshaft sprockets with the radiator that close.
Here are a few photos from when I found the leak:
This was after a 200 mile trip, fresh coolant:
This is were the leak is coming from:
View 15 Replies
So after saying "We don't work on that model" when I asked for a timing belt / water pump change (yup, they actually said that), I went in today to try and get a second key made since the guy I bought the Phaeton from only had 1. I do not have the little code. I was told that there was nothing they could do without the code. My only hope would be to contact EVE directly.
View 2 Replies
I replaced my timing belt, tensioner and water pump last weekend because I noticed I was leaking coolant from the water pump. The other day I popped my hood after driving and notice the reservoir bubbling a little bit because it sounded like the coolant was boiling and the line coming into the top of the reservoir felt hotter than normal. I opened the cap slowly and never heard any pressure release. I figured it was air in the line somewhere so I tried to work the air out. It sounded like the air came out and I took it for a drive and I finally heard pressure release after 3 different attempts. I opened the cap later when it was cool and noticed that the coolant was still at the original level.
Then the next day I was driving and came to a stop and noticed white smoke coming out when I gave it gas. It still drove fine though. I pulled over and opened the cap slowly but didn't hear any pressure release. I put in a little bit of radiator sealant and it seemed to do the trick.
The car has never overheated and there's no oil in the coolant or coolant in the oil. The heat also seems to be working correctly and my fans come.
View 6 Replies
Four cylinder, 2004 Camry (2AZ-Fe), Auto with 98,000 miles.
I had to replace my water pump after driving with newly replaced Toyota Red antifreeze from the 8 year old Pink. I drove only two weeks and 1000 miles on it.
I believe that was just a coincidence. Some Camry's water pumps do not last even that long. Even if the coolant was not compatible with Toyota specification, it still could not destroy the pump seals in two weeks.
View 10 Replies
My 2006 Prius with 120k miles has coolant seeping around the water pump. I called around to get quotes on replacement cost, but one place said the thermostat should be replaced at the same time, while the other said it shouldn't. (BTW, I will have the belt replaced at the same time).
View 8 Replies
This is an update to my Heater Hose to Water Pump Failure post. As it turns out, the water/coolant pump seems to have failed at the same time as the heater hose. I think Ford secretly installed an internal time mechanism to deconstruct certain parts at the same time.
Anyway, in desperation I took the van to the local Ford dealer for an inspection. NOTE: I don't trust most of the locally owned small time shops and national franchises. Half of the time, they don't know what they are talking about.
They said the water pump is toast. And I already knew that! Then they said, because the water pump is attached to the front timing chain cover, they need to replace the gaskets there also, and also the oil pan is attached to the front chain cover, so that needs done, and then they said the radiator is also leaking. What!!!
Then they asked if I would be interested in buying a new or used vehicle. This tool works great. Mine happens to be a left hand fan. The tool is used with the handle on the left. This tool is used to hold Water Pump pulley stationary, while unbolting the fan assembly.
Tomorrow morning is when I finally replace the water pump. Not a lot of tool are needed, except for the stubborn fan clutch. Sockets: 8, 10, 13, 17, except a 22 mm open end wrench for the fan clutch.
View 8 Replies
I have a Gen 6 2007 Camry SE V6 that I bought new in 10/2006.
Over the last few months, I've had an intermittent loss of coolant as evidenced by sometimes finding a small puddle of coolant on the floor in the garage.
I also often hear a noise under the hood for a few minutes upon first starting the engine cold. I've been just adding a little Official Toyota Coolant to the coolant reservoir.
I'm unable to see where the coolant is leaking from, but with the water pump problems others are having with this engine, and the noise I sometimes hear when starting the engine cold, I suspect it's the water pump.
I have 70,000+ miles on the car with the extended warranty which runs out in mid 10/2013. These symptoms led to a water pump failure?
View 12 Replies
I've got a 07 LS460 with 95,000 on the ODO and took it in for a harsh ride. The tech called back and said the upper and lower control arm bushings are bad along with a water pump leak.
If the water pump is leaking, shouldn't I have known? I haven't had any low coolant issues, smells or fluid on the ground.
I'm covered by an extended service plan, but would like to have known (otherwise I could have gone bust!)
View 12 Replies
Bought an 07 ES350 from a reputable dealer in March 2013. Had 65k miles when i got it. Had it about 6 wks and 2400 miles and noticed some reddish leaks under the engine. Thought it was trans fluid. I was driving to the dealership to get it fixed - when i noticed the temp guage up near the red zone and the heater (was 39 degrees F out) was blowing cold air. I started to get in the right lane - when all of the lights on the dash lit up - including the "check engine" light. I was able to get over - i think the car actually stalled.
Anyway - after a tow to the dealer - it was the water pump had leaked out "all" of my coolant. At 67k miles having a water pump fail on a Lexus? Did i do permanent damage to the engine?
View 7 Replies
Have air trap in coolant after water pump replace.cannot get it out. Do I need to drain coolant again and start over. 1997 nissan pickup 2.4 liter.
View 3 Replies
2004 Lexus rx 330 with 53000 miles, I took it to the dealer for 50,000 mile service when he requested me to change water pipe for coolant because he found heavy coolant residue under the water pump. My question is do I need to change timing belt also right now. when I called the mechanics some of them recommending me to do the timing belt also.
View 4 Replies
I have a 2013 GTI manual 6 speed with 18K very gently driven miles. Yesterday I noticed coolant on the garage floor and checked the reservoir which was below the fill line.
Went to dealer this morning .....bad water pump. I asked if this was unusual for such a new car with low miles and service writer said yes. After googling water pump failures of GTi's I learned this was not the case.
View 2 Replies
Today afternoon I started the Touareg and got a noise, check the hook and there was a lot of antifreeze on the front of the engine and the belt splatter all over the front of the engine.
Could not see where the leak was coming from, re started the engine there was a lot of antifreeze.
All temp where ok and oil showed no water on it.
Drove to dealer only a few miles away and when showed the engine the engine was dry just the splatter. Left it there for them to check tomorrow.
Could the water pump go bad, never replaced or noise? Have 110,000 miles on the car and just replaced belt a month ago.
I am hoping is not a leak on the head.
View 2 Replies
1) It's a very slow leak.
2) I am under Power Train Warranty for another year (Certified Pre-Owned).
3) My friend is a mechanic who will fix it for free as long as I buy the Water Pump.
But I worry Toyota is going to give me a hard time and say it's something else not covered by warranty or say it's not you water pump but the radiator, which shows no sign of leakage and is not covered by warranty.
My friend showed me the bolts that were corroded white on the pump with a mirror and flash light. I buy the water pump and he installs it for free or go to a Toyo dealer where you don't know what to expect?
2006 Camry LE 4 Cylinder, 48,000 miles---I know Toyota makes junk Water Pumps.
View 1 Replies
