I got a 98 passsat and my clutch was recently replaced.... my car doesn't start but my battery and starter are good... it must be something with the clutch that the mechanic left out... i have to push start the car every morning and its hard to just even get it out of the driveway and onto the street by myself.... is there any way to turn off the clutch sensor so i don't have 2 clutch in for the engine to turn over....
View 1 RepliesI'm still trying to get a feel for the car and I've noticed that I have to slam the hatch door in order to get the sensor to turn off. I'm hoping I can adjust the sensor or latch. Thought I'd post this while I'm free to do so. its not really a big deal. I'm just curious what others have to say about it since I'm new to Passat wagons.
View 5 RepliesI have a 93 subaru impreza manual that when I turn the key on and push in the clutch it wont turn over. The coolant fans kick on and stay on and so i retrieved the codes and the coolant temp sensor was the dtc so I replaced the sensor and cleared the code but the fans still come on and the engine still does nothing. Also I can gear clicking noises throughout the engine compartment and dont know where its coming from.
View 8 RepliesOn my 2001 Excursion the ac clutch went south over the weekend. I replaced the clutch with a factory clutch kit. Now the problems are baffling me.
I set the air gap at .020. The problem being when I turn the ignition switch on and turn on the ac switch the clutch does not engage. I still get cold air. When I start the truck and it runs the clutch is engaged without any problems, I turn it off and the clutch disengages.
Got a weird issue that I've never encountered before. I tried searching but you can't search for just "A/C", so the search was pretty generic and I couldn't find anything similar to my issue.
Hot or cold, doesn't matter. When I turn the A/C on the clutch try's to engage and slowly starts to spin with the pulley until until it finally engages then the a/c will blow out cold air just fine. Also noticed a burning smell coming from it.
01 Jetta 2.0
I have an issue with my 2003 golf 2.0 ac I've done everything that I cloud thing of to check but I still have this issue so here it is. The air coming out of the vents is warm, compressor Clush turn on but doesn't kick off. I hook up ac gauges and it reads 70 on low side and 155 on high side with an ambient temperature of 80. The system has freon, I check fans and they are on when compressor kicks in all relays and fuses are fine.
View 8 RepliesSays A/C Compressor Clutch Circuit open. A/C blows hot air....go to VENT and the EATC controls the temp fine (ambient air only). It's on a '97 Lincoln Mark VIII if it makes any difference. Pulled code # 1530 ...
Clutch does not engage but the compressor does turn. Also the EATC will NOT go into the test mode. Push OFF and Floor at same time, then AUTO within two seconds. Nothing. Is this a clutch gap problem? New clutch was installed about a year ago.
2000 Explorer Sport with 4.0L SOHC engine. When I turn on the A/C the clutch on the compressor cycles off and on every 10-15 seconds. The A/C cools and the gas charge is checked as OK. Is this normal?
View 1 RepliesLast night when I turned my car on (cold engine start so let it warm up) and by accident when i was starting off on 1st i released the clutch to fast and not adding much gas causing the rpms to drop down and the car jumped and not sure if it shut off cause when it turns on it beeps once due to my tpms needing service and i heard the same beep but instead of shutting off the rpms jumped to 2k as if i was revving the engine and i began driving. What gives?
View 4 RepliesMy 02 Camry(auto tranny) just started shift hesitating after a stop or on a turn. Engine revs and then slowly grabs. After that, does everything fine as far as normal shifting is concerned(up and down through the other gears). Fluid level is full after a change out last month.
I bought this car used this year and the tranny fluid was dark brown. Didn't smell burnt, but compared to other fluid I've seen looked roasted or old. Like it had never been changed. This Camry has 150K.
So, do i have a transmission issue or has a sensor gone bad?
Normally my head light turn off automatically when I turn off the engine and open the driver's door. Now, it works randomly which caused my battery to be drained.
I feel that the sensor on the door does not trigger to tell the car to turn off the lights.
I have verified that my AC clutch does disengage (and re-engage), but it seems like the AC is on all the time. Normally you don't notice this in the Northwest because I always overpower it with the heater, but now that it's above 70 on occasion, in vent and full cold, it still blows 20 degrees colder or more than outside air temp.
Is it possible that the clutch disengages but that the bearings are bad and its somehow still turning the compressor? Would a mechanic be able to diagnose this or would I just have to throw money at buying a new compressor? My first indication should have been that I get about 15-16mpg when I used to get 18+ occasionally.
My AC clutch, radio, cruise control, and turn signals are not working. I have checked all fuses and relays that I can find, all good. From what I have read, these are not part of the GEM function. What I need to check next!
View 7 RepliesWhen I bought my 2004 Passat three months ago, I was told that the clutch was brand new. Lately when I take a corner in second gear, I get a "whole car seizure" if I am hitting the gas a little hard while not letting up the clutch enough. I've never had this happen before in ANY of the other standards I have owned / driven.
View 1 RepliesI have a 02 passat 1.8t 5sp so my question is does clutch catch all the way at the top. this doesn't seem right to me because my brother has had a jetta and the new mk5 gti and they both catch low.
View 1 RepliesMy clutch just went out on my 1.8t B5 1999 Passat today. My car has 165k miles, so I'm not super worried about longevity, so I want to know the cheapest results given my circumstances. My car is bone stock other than lowness and rims, so I'm not worried about performance.
View 3 RepliesMy Mom's 1998 Passat 1.8T has 340,000 miles on it. I was unaware of it until today, but apparently when it reaches around 97 degrees the clutch starts malfunctioning. She says the pedal will go to the floor and the clutch stops working. My Step-father does not think the clutch itself has ever been replaced. Sometimes she even has to pull it back up with her foot. I'm not well versed on this model as I'm primarily an A-1 guy.
View 4 RepliesSo I was on a road trip pretty far away from home on some winding roads in the mountains enjoying a new chip I put in my 1.8t and when I down shifted to 2nd, my car all of a sudden felt as if I went into neutral, needless to say, I wasn't, my clutch just stopped working. I can shift through all the gears, and nothing grabs, not even slightly, I don't hear any grinding or anything. It's just as if I'm in neutral. My clutch was pretty worn to start with, I've got 130,000 on an original clutch I just never had a clutch got out on me like that.
View 6 RepliesMy B5's clutch started not returning by itself when the really cold weather started. When it gets warmer it starts to spring back up. I called the dealership and the initial cost of looking at it takes me somewhat aback. I've already spent quite a bit on it last year. Reading some of the threads on other car models I've seen mention of clutch master/slave and fluids.
View 10 RepliesNeed to replace the clutch on my wife's 2001 AWM. Its for her, no mod's, driven daily to work etc. I just want a stock style replacement that will last as long as the original (165k). Should I go with the stock replacement from Sachs or go with one of the Valeo style dual mass conversions? Does my car even have a dual mass? Can the OEM flywheels be resurfaced/turned?
View 1 RepliesI have a 1996 VW Passat TDI which has a 5 speed stick (they all did). Yes, it's really old but it runs great and gets 45 mpg. However, the model is probably not relevant to this problem. My question has to do with clutch performance. When the car is cold (and it's cold outside), the car sometimes shudders starting out in first gear for a couple minutes. I have tried to be extra careful letting out the clutch in these circumstances. Sometimes that works, but it doesn't eliminate the problem. After about 5 minutes or so the clutch starts working well as it usually does.
View 10 Replies