Passat (B5) :: Coolant Reservoir Empty And Has Brown Residue All Over Inside
Dec 8, 2007
Today, I was greeted by a big red STOP! warning from my 2000 Passat 6 cylinder. The car drove fine last night. The coolant reservoir appears empty and has brown residue all over the inside. I notice for the first time that there is pink fluid on the floor -- I'm assuming this is the G12 coolant.
It's not a hot day, so I put in distilled water, turn up the heat and drive my Passat (trying to stay under 2k rpm) down to the dealer. They say that the coolant from the oil cooler leaked into the oil (and presumably, vice-versa).
View 1 Replies
Advertisement
been working on my passat for the last year oil cooler went bad and also my CCM fried. Anyways got the car running good or so i thought drove the car up the road today and my coolant sounds like it's boiling inside the reservoir.
View 11 Replies
On the 06 Prius I have been working on, I noticed a light build up of pink coolant residue on the inside of the ICE water pump pulley. I assumed that this was due to a coolant leak from the weep hole, which points to an impending water pump failure.
View 16 Replies
It has happened to me several times.. The car asks me for coolant but today the reservoir was almost completely empty... I have no leaks and my cooling systems is working fine so where does the coolant go?
View 6 Replies
I have a 2006 3.5L Sante Fe. and i noticed there were coolant drips under the car and that my coolant reservoir was empty. In the engine bay below what i assume is the water pump i noticed the coolant pooling (See Photos). I am not sure if the seal is bad where the top radiator house connects to the water pump (circled in red, or if the thin metal line (circled in Blue) sitting in the coolant pool would have anything to do with it, since it seems to trace back to the radiator.
View 4 Replies
Back in February, received a light and discovered that the inverter coolant reservoir was empty. I refilled the reservoir and cleared the code. Today, only 3 months later, the same thing happened. I don't see any wet hoses, puddles, or obvious signs of leakage. Where all my coolant is going? What steps should I use to properly troubleshoot...
View 8 Replies
I just purchased a 2015 sonata last Friday from a large non Hyundai dealer. An hour ago while upgrading my headlights i noticed the coolant reserve tank was completely empty. I am going to check the main radiator level tomorrow because the engine was still hot at the time. I am hoping it is not a blown head gasket, i did remove the oil cap and noticed a very small amount of greyish oil in the cap threads other than that it looked good directly under the cap and inside the hole. Should i call my local Hyundai dealer or just fill the tank back up? I am wondering if it just burned off over time and the original owner never filled it back up. Also what type of coolant is compatible?
View 6 Replies
2008 Santa Fe 2.7 105k miles Timing belt replaced two years ago at 80k miles I have no smoke, no sweet smell, no milk on oil dipstick, oil looks as clean as honey, no crustiness anywhere, no wet spots under hood or car. Yet my coolant reservoir was empty when I did my last oil change two mos. ago. I filled it up then. Today I checked it was just below the min. line. Car runs like a top, but I'm going to have a pressure test done today. I thought head gasket issues were very rare in these cars.
View 17 Replies
1999 Honda CRV. Just took a 3-hour highway trip. Before trip I topped up coolant reservoir which was a little low, but radiator was full. I did notice some dried white spots on the front of valve cover and spark wires. Wasn't sure what it was, but now realize it was coolant residue. Probably only 1-2 cups were missing from the reservoir, so the leak had just started.
After 3 hour trip, checked engine compartment again. This time the reservoir was totally empty (radiator still full) and the engine was well sprayed with greenish coolant residue. The radiator was cool by the time I checked it, so the leak source wasn't obvious, but it looks to be coming from the seam where the plastic top meets the aluminum.
I will replace the radiator when I get home, but first have to drive the 3-hour return trip. Will it be OK as long as I start full of coolant and keep an eye on the temp gauge?
View 9 Replies
I noticed recently that I have a coolant leak in a used car that I got a few months ago. I've been driving this thing pretty regularly at this point, but I haven't noticed any overheating. The engine temp stays shy of the midpoint line on the meter, both at speed and in idle.
The coolant reservoir was empty a little over a month ago, so I filled it up. A few days ago, I took a look at it, and it was empty again. I refit a hose that was a little loose and decided I'd just wait and see what happened after driving it some. Over the past few days, I've noticed slight decreases in the coolant level each day.
Today was no different, except that after I drove for about 15 minutes on probably the hottest day of the year so far (about 95 degrees, don't know if that matters at all), I noticed there was coolant sprayed on the hood. I opened the hood and there was quite a bit of coolant pooled on the far left of the radiator top, right between the coolant reservoir and the radiator pressure cap. What's going on here?
View 19 Replies
1,500 miles ago my car had it's 30k service. Today, i got "CHECK...". At home this evening i checked the inverter coolant reservoir, it was empty. I've added 1L of de-ionised water (which got it to full, and i see turbulence in the fluid) until i can get the correct fluid.
View 13 Replies
Had overheating issue with the wife (she doesn't monitor fluid levels like she should). Now you can't operate it for more than a day or two before the reservoir is super low to empty. Mechanic coolant is going into the engine, probably through the intake manifold. Says investigating further will cost a ton. What can I do cheaply to figure out what's going on before I give up? I followed her when the engine was started from cold & could see water vapor (more than I would expect) in the exhaust until when I figure the engine reached full operating temp. It has about 225k and is the 6 cyl engine, btw.
View 1 Replies
I was driving my 2008 Santa Fe last week (before I went on vacation) and noticed the the A/C wasn't coming through quite a cool as usual (almost felt like the vent was on w/ no AC). Then after about 10 minutes of driving I noticed the thermostat on the car get to about the 3/4 line pretty close to the red lines.
Luckily I was home so turned the car off and popped open the hood. I noticed the reservoir tank was empty and there was some coolant that dripped down on the fans & a small pool of coolant on the engine block right under where the oil is poured. (nothing has been dripping under the car)
I added a little coolant to the reservoir tank and the next time I turned it on and let it run for ~10 minutes, it was the same thing.
Anyway, I came back from vacation and opened the hood to try and identify exactly where the leak was, and ran the car for ~30 minutes, with A/C on full blast and the car didn't overheat or leak anywhere. Coolant tank was still full from when I filled it the first time.
What could have caused the leak/overheating in the first place?
View 12 Replies
I've got an '08 Cobalt. There is a large leak in my coolant system. The plastic reservoir is empty and if I add coolant and start the engine it all gushes out of a hole in a piece of plastic on the side of the radiator. Can I drive it to the shop if I watch the engine temperature or should I have it towed? Is the engine temperature measurement affected by the lack of coolant?
View 6 Replies
Why my 96 dodge neon is leaking coolant. I was checking my oil and I noticed the reservoir tank was half empty, so I assumed it was nothing out of the ordinary since it's a 17 year old car. When I filled it though, it came pouring out of the tube that sits right under the tank. I'm capping it off every day before I drive and it holds, but it's definitely got a slow leak. It seems to only hold it for 4 days of driving for an hour. My temperature gauge stays at the normal level, but you can smell the antifreeze burning and the engine's running hot. I'm not too mechanically inclined, but what could be wrong with it? I've recently installed a new alternator and clutch cable and found out my valve cover gasket is leaking. I really want to save this car instead of getting a new one.
View 2 Replies
While servicing the bosses 121k 6.0, I noticed the coolant resevoir empty. It took 1 1/2 gallons to bring to proper level. Returning under truck to install drain plug, I noticed coolant coming from rear of the engine(right side). And of course Ford has changed the cooling system cap, so I wasn't able to pressure test it to pinpoint the leak. Started the engine and seen coolant coming from the left rear as well. I've been reading here to see what others have been seeing, (EGR cooler, head gaskets). With all the heat shields,not much room to look.
After work I did go and buy the adapter to test the cooling system. With any luck I will be able to see leak better.
View 14 Replies
I always check the fluids, every 2 weeks or so just to make sure everything is fine, yesterday I found oil inside coolant reservoir.
The last oil change was performed 2 weeks ago and the oil that came out of the engine looked normal to me, no coolant in it.
I want to keep this car because is more than a car for me, I have a lot of plans to do with it but damm it getting annoying.
View 13 Replies
I checked the oil it does not have coolant in it, so that eliminates the headgasket.
View 3 Replies
My buddy has a 2000 1.8T Passat and he has oil in coolant reservoir. It does not blow out any smoke. It runs fine, and does NOT have coolant in the oil. We pulled off the oil/coolant heat exchanger on the oil filter and it appears to be good. We blocked off one end and filled it with coolant and put compressed air to the other end. Nothing came out. He took it to the shop and they said the turbo seals were good. I can't verify that though.
Head gasket? Worse yet cracked head or block? The car does have 170,000 miles.
View 9 Replies
Long story short, I got a 2001.5 1.8t M5 Passat with 63k miles 2 weeks ago.
This weekend I was driving around and pulled into the driveway and noticed the coolant was boiling in the coolant reservoir. It also looked like there was some oil in the reservoir. Take it to the shop, turns out that the plastic impeller on the water pump broke at 64k miles. This is wierd because the car never actually overheated. The mechanic doesn't think that the head gasket is blown or i have a cracked/warped head because the car still runs fine. He suggests I replace the water pump, timing belt, coolant reservoir, thermostat and obviously flush the coolant. I go ahead with the repair since its almost time for the TB anyway.
After bending over and taking it from the shop on a timing belt and water pump repair, I think I am all good. Today I open everything up after a few days of driving around just to check up on stuff. I open the coolant reservoir and there is telltale signs of oil in the coolant. Now i think this was an issue before the water pump went. Searching the archives I see that the oil cooler is a common failure. This could have also contributed to the failure of the water pump and maybe the thermostat, I don't know.
So instead of bending over for the mechanic for a second time in a week , I think I'm going to replace the oil cooler and flush the coolant system again and change the oil myself. Poked around looking at the oil cooler and it seems as if there is the slightest sign of an oil leak on the outside, which could mean there is a leak inside. I don't have compressed air so I'm not sure how I can test the oil cooler for leaks.
I am thinking i need:
-Oil cooler (some suggest S4, some suggest TDI one?)
-Oil cooler gasket
-Feed and return lines
-Hose clamps
-g12 coolant
-Oil filter
-Synthetic oil
Should I replace the upper and lower radiator hoses while I've got the coolant out? What else should I replace while the coolant is out. I see people suggest flushing the system several times. Should i use G12 everytime or can I just use water to flush until its clean and fill with G12?
View 3 Replies
I own a Passat 2004 V6 Wagon ATQ and I noted that the coolant reservoir was low on coolant almost empty but i did not notice any overheating issue. I took the car to the shop and the Cooling system was pressure tested no leaks no problem then after a week I found that after a 20 minutes drive I pull into a parking lot and coolant was dripping from the reservoir my a/c fan works and the fan clutch spins slow and I'm able to stop it with my hand. I just replaced the clutch fan last but the problem still present.
View 1 Replies
