I may have an issue with my engine. My car is beginning to blow some blue smoke when I romp on it. It doesn't break up at all, there isn't any loss of power. It's just blowing some smoke and I noticed a light oil build up on my exhaust tips. I don't think I need to be hugely concerned yet, but I am bringing it to the dealership tomorrow just to make sure.
View 9 RepliesI am only at 141,000 miles and I'm seeing blue smoke while I idle! It started as a small puff of blue smoke when cold starting up...now it is much more consistent. I am also getting a diag trouble code of P0674 (glow plug in cylinder 4) can that be the cause? I'm nervous since I didn't watch my tech put oil in the truck at the last oil change...I think he put four gallons in instead of 15 quarts...is that a prob?
View 1 RepliesMy turbo started to have oil on the top of it. I don't know where it's coming from at all, it started to blow blue smoke but not all the time. You can also smell the oil burning off.. someone said maybe the pcv system but not sure. Still new to the vw world only owned the car for about 4 months. Trying to add pics but it's not working.. Will keep trying
View 3 RepliesMy santa fe 125k on it engine start to blow little blue smoke when start up ...
View 1 RepliesI am writing about a 2007 Chevrolet Suburban and for the last few months, have noticed that the car is losing oil. I have to put in a quart of oil about every 3 weeks. I have brought it in to the mechanics and asked them to look for a leak and they can't find anything. They have changed the oil, replaced the evap hose, but the car is still losing oil. Just did a lot of driving this last weekend and the oil went all the way down, to the point of when I started it this morning, I got a huge amount of blue smoke out the back. When I took off the cap to add oil, I noticed this mustard yellow, foamy stuff on the lid. Never saw that before.
View 6 Replies01 7.3 247k.
Yesterday went to get on the freeway I looked back and saw a cloud of what looked like blue smoke. I'm in northern Utah and it's cold but the truck runs fine, I haven't noticed any change in performance. Turbo still builds boost. I pulled the fuel filter cap last night to check fuel color and it was clean.
I do have the CCV mod done. I also pulled to IC Pipe off the turbo and there was a little oil in there but not much, should there be any at all with the CCV mod? Where to start.
First some background. The vehicle is a 2003 Expedition with rear AC. The 5.4L engine has been replaced with a 4BT Cummins (DD since 2010), but the AC system is not altered-- other than the compressor being mounted to a different engine. The intercooler is in front of the condenser, which hurts efficiency of the AC system, but it seems to work fine in our climate.
My AC system quit cooling one day, and the problem was a hole in one of the low-side tubes from rubbing on the turbo-to-intercooler tube. I repaired this by aluminum brazing. The system held 120 psi on nitrogen for one hour. So I pumped it down overnight to 27 inches of Hg and made an appointment with the AC shop to get it recharged. I could not get an appointment for several weeks, so I continued to drive it with no AC, thinking it should be no problem since there is no pressure in the system.
I was on a road trip when all of a sudden, there was a huge stinky cloud of blue smoke billowing out from behind the truck. I pulled over and the AC clutch and pulley was smoking hot. I shut it down and cooled it off slowly with squirts from a water bottle.
So my clutch is shot but I'm not sure what caused it to fry. Is there a typical mechanical failure where the friction material can be chewed up by the pulley-hub? Or is it possible that somehow the controller commanded the clutch to engage without pressure in the system?
I think it would be prudent to replace the compressor, since there may be some bearing or housing damage from the clutch failure, so that is in the plan. I have read that when ever the system is open, the drier should be changed too. I want to do this right rather than do it again on another day.
One concern I have is that if when the clutch was failing and it managed to turn the compressor-- could there be pieces of compressor in the tube runs that I need to clean out? Other than a visual inspection of the open tube ends, is there another test or things to look for?
I have a 2003 ford escape V6 and i have notice when i start it' after setting overnight i notice some blue smoke for a little while then it's stop What could be causing this.
View 1 RepliesI have a 07 6.0 powerstroke, I had 2 bad injectors so I replaced all of them with reman's. I had a problem with them coming loose. the first time this happened it hydrolocked the motor, number 8 cylinder. so I pulled all the injectors and replaced all the seals and washers and torqued them down a little more than spec like 27 lbs. it runs great and starts great even at 25 degrees but I noticed this morning that when starting it up after it sits (cold) it blows blueish smoke until late it warms up and I accelerate. is this normal? should I check fuel filters? oil in fuel?
View 14 RepliesMost had said theirs did it intermittently and got better after awhile... Mine does it every single time. I start the car. Usually after sitting for the day at work or overnight at home... Not sure which direction to go with this (or rather my hubby) to go. What would be checked first? turbo, fuel injectors, and valve seals...
View 2 RepliesI've got a 2001 passat tdi 130, awx engine, its got 213k on the clock and has been a great car for the last couple of years, over the last couple of weeks it has been down on power and is really smokey,blue smoke, it seems to be worse if its left idling for a while then give it a good rev up and it lets out a big cloud of blue smoke, it doesn't clear and is smokey all the time, I've not noticed any drop in oil level either which makes me think it may be injectors but it still runs ok with no diesel knock and starts first time, I don't want to be wasting any money on buying a turbo or injectors if it doesn't need it.
View 6 RepliesAs the title states I have lots of blue smoke out the exhaust and the smell of burnt oil. Checking other posts it looks like it could be a diverter valve, a pcv valve or the Turbo. I checked on line and autozone and parts America say these are not required for my car. I checked my Hanes manual (yes, that's all I have) and they don't have the DV or the pcv listed.
2000 T 1.8 B5
I own a 2001 Passat, engine code AVF, the problem is that I have blue smoke on the exhaust, lots of it. The turbocharger has been tested and has almost no play in the rotor, but I have tried to blow some air into the oil intake and the air flow is very low, I have to blow quite hard so some air can go through. I also get allot of smoke and oil from the Crankcase Ventilation Filter and also I could see some oil around the dipstick pipe.
Now I don't know if there is a turbocharger oil return pipe problem (maybe it is clogged), the turbocharger itself or maybe some other problem.
I was watching my wife drive off yesterday, and noticed a puff of blue smoke (oil) from the exhaust when she started moving.
This is a 2000 V6 passat. The car has a valve clatter when you first put a load on the engine that goes away quickly. I've read that this is likely the cam tensioners leaking down - is that right.
Occasionally I get blue smoke in the engine compartment with a sweet smell after a long drive. No malfunction lights, oil, brake, coolant, power steering fluids all are normal level. VW service doesn't have a clue, says just drive it until it breaks down. He also informed I should never use Tiptronic for braking since it could damage the transmission(we live in the mountains). What is it for anyway? We use Mobil 1 synthetic oil, and it is not overfilled. Car has 120k miles.
View 5 Replies1998 Passat 1.8T Sedan, Manual, 118k miles, new head at ~ 87k due to broken timing belt. (Changed oil approximately 1.5-2k miles ago, no loss of oil evident). No noticeable loss of power. No MIL and no DTCs in storage.
But there does seem to be a bit of exhaust (puff....puff.....puff...) that seems to be coming from under the turbo side of the engine, but it is hard to tell.
Recently - over the last couple of weeks - noticed at start-up in morning, significant amounts of blue smoke from exhaust - eventually subsides to nothing after a couple of minutes. BUT, it only seems to appear when the car is angled with its nose slightly up in the driveway and not with its nose down. Lack of it occurring with its nose down was only tried twice; I may need to check it again.
After reading many posts, I thought it might be:
1) Oil overfill at last change - I noticed that my oil was less than 1/16" above the top bend. I doubted that would be the problem, but I siphoned off the small bit and it is within or just below the bend now (hard to read). It might be the oil since I used the Valvoline full synthetic MaxLife that is VW approved for the first time, but I find that hard to believe since I have been using synthetic for a couple of years now.
2) Oil getting into the combustion chamber via oil in the turbo system. Checked the low spot in the hose just before the throttle body. Seemed virtually dry; that's not the problem.
3) I guess it could still be oil gathering some place due to the failure of the turbo, but power seems quite normal.
4) Problem potentially with the PCV (actually called the breather and bleeder valves) and/or vacuum system being plugged up. After reading all of the posts regarding that I am starting to think (HOPE) that is it and not the turbo. While I do understand that flapper valves that are stuck would create greater pressure which could result in oil being forced into the chamber past the valve seats, I am not sure why the angle of the car while parked would matter since the higher pressure would only be occurring while driving; and the blue smoke goes away after driving and doesn't appear until next morning. But perhaps I am missing something.
Particularly which valves I should check/clean if I am seeing this smoking exhaust at start-up, but only when the car is parked with the nose up?
5) Sticky valves at the back-side (cabin-side of the engine)?
2.0t's smoke alot at WOT. I haven't seen it first hand from behind the car, but when I floor it and look in the rear view I see a little bit of smoke. Not black or anything. It has always been this way. Bought the car new (2006). Is this natural for the FSI?
View 6 Replies2001 1.8T ... using oil 500ml/100km
- Blowing smoke-intermittent
- Power loss-intermittent
Some jelly white stuff in oil may not be related... Service techs looking at turbo....
My 96 Passat GLX-VR6 Wagon is blowing a white smoke that smells like maple syrup if I do any temp adjustments on my AC. It's also not blowing any cool or cold air in the coldest setting. Any thoughts? Heater Core? Just need freon?
View 3 RepliesI was on 285 tonight in Atlanta and had a very hard time seeing because of all the white smoke. I thought some old GM car or Ford was billowing white smoke through the exhaust.
When I finally caught up to what was the cause I was shocked to see it was a Passat. A 2014 at that! 1.8 Turbo. I followed her into a Kroger Grocery store parking lot and parked as close as I could. She was unaware that her car was smoking out of her exhaust. I told her she needed to bring her car to the dealer asap and have them look at it. The white smoke was coming out of her exhaust even after she turned the motor off. She had no clue. I would say she was in her middle 70's age wise. It think she talked to me because I was in a Passat that "looked" like her car. Interesting to me to say the least. What could this possibly be?
Ok so the wife and I were heading home, she was in her 2.0t sedan, I was in my 3.6 4motion wagon. I got stuck behind a slow driver on the highway (doing 50 in a 70 mph zone) so I get in the passing lane and I floor it to pass him. When I get home, my wife tells me she saw a good amount of black/blue smoke coming out my tail pipes when I went to pass the other driver. This is on a engine with 2400 miles.
I take a look, and the chrome exhaust tips I had installed not long ago are now all black, covered in a oily thick residue. These same exhaust tips were on my previous 07 3.6 4motion wagon for 10k miles and was still shiny when I took them off. but after about 1k miles on the 08, they are now all black. I check the oil and it still reads full.
So what could this black smoke and this oily residue on the exhaust tips be caused by? should I be concerned? Engine runs fine with the exception of sometimes stalling when trying to start it after a short stop. (VAG-COM doesn't show any error codes logged.