Passat (B5) :: 2002 1.8T Wagon GLS - No Air Coming From Bottom Vents
Dec 12, 2011
I have 2002 1.8T Wagon GLS with a manual climatic (with 3 big dial buttons). The weather is now getting cold and yesterday I started to realize there is no air coming from the bottom vents (both passenger and driver side) when the air flow dial button is set to bottom vents. All other positions (windshield and front vents) are all working. The air flow dial button appears to be mechanically controlled.
View 1 Replies
Advertisement
Notice a leak at the bottom of the Line coming out of the reservoir and turning under at the bottom of the radiator... Not sure at this point whether this is the suction return or supply , probably return, from the looks of the spring clamps used.
It appears that some steel line is used to make a 2 ft or so loop under the radiator before it goes back to the rack.... Cooling??
This line app. 3/8 " in diamater is supported by some rubber isolators, and no doubt there is some rust which has formed in there where the line passes through the rubber, small pinhole maybe??
View 39 Replies
Our brakes froze the first cold day this winter. My mechanic says that the brake booster valve filled with water and froze. Also, last winter our tiptronic just quit working. We never fixed it. Should we bother to fix it?
View 3 Replies
I have a 2002 SuperCrew - I've recharged the coolant - I can fill the air coming from the top defrost vents.
No matter what button I press on the air controls and can't get the air to switch to the vents. What the problem could be?
View 2 Replies
The vents in my 2002 Prius are starting to become problematic. When I turn on the heat, the air is not coming out. When I hit the glove compartment, the air starts to come out, but it is very low and stops after a minute or two. I just want to know if the blower motor is dying, and how to replace it, if it is really the blower.
View 1 Replies
Ok, so, my heater works, I can feel the hot air coming out of the vents, but no matter what setting I use, I can't get the blower to kick on. The hot air just trickles out. What might be wrong, and how much, or how hard it would be to fix? The weird part is that sometimes the fan will work.
View 2 Replies
The other morning I started my car up and no heat or air would come out of my vents. The night before I had to drive through a blizzard and my car was completely packed with snow. The climate controls function normally, everything is lighting up when i select a button, but no air is coming out of the vents (rear defrost and seat warmers work fine). There is no sound of the blower starting when I turn the air on, hot or cold. I live in Northeast Ohio so we currently have several inches of snow and it's well below freezing outside. I live in an apartment so my car is outside 24/7 between being here and at work. I looked up a bunch of posts on here and other websites to try to figure it out. I ended up taking my cabin filter out and it is completely packed with snow. So i vacuumed out the snow that was left in the cabin filter housing as far as i could reach. I also unpacked as much snow as possible from wheel wells seeing as the HVAC vent goes to there, and the blower still doesn't work.
What I am guessing, which I could be completely wrong, is that the HVAC vent is completely packed with snow and it's not letting the blower turn. I guess my question is does that seem remotely possible or is it something else completely? My climate control doesn't work on the highest setting so I don't think its the relay I read about and my heater has been working fine with no noises or anything and I don't believe it would just go bad out of the blue.
2012 Passat SE 2.5
View 4 Replies
I turn it up on any fan speed, and set it on the floor setting, and nothing blows out the bottom vents. pretty much no air is getting to the bottom vents.
I do feel some air blowing out of the windshield defroster vents when I put it on the floor setting. seems like something is blocking it maybe?
View 14 Replies
Have a 02 with climatronic. You put it on vent and it blows out the vent. You press floor and it goes ape and the fan goes to max and nothing comes out the vents and nothing comes out the floor. IF you put it on floor only there is flow like normal. You can not have it on floor and vent. I drove 2 other passats and they both allow floor and vent. Havent been able to check codes because car has been at dealer for a week.
View 8 Replies
So, at 14k it looks like I have that musty smell coming out of the AC vents. I've seen a TSB on here that addresses it. Hopefully my first trip to the dealership for anything other than an oil change doesn't present me with any other surprises.
View 8 Replies
When the car is warm with the A/C off(vent air only) you can smell an oily smell coming from the inside air vents. The smell is also evident from the engine compartment when exiting the car. I do not have any oil leaks that I can find and have been good about cleaning up spilled oil when changing the filter. I've had the car when new and it currently has about 63k miles on it now. The smell seems to be getting worse. No mods to the engine and everything else seems to be running well otherwise.
View 2 Replies
I recently purchased a 01 Passat 1.8T and noticed a strong 'used oil' smell coming in through the vents, especially at stoplights; the vehicle continued to smell badly when parked and turned off.
After looking around the PCV system, I found a small check valve near the airbox that was dry-rotted and non-functioning. As I continued to search, I found a large PCV hose directly under the intake manifold closer to the firewall. This appears to be ~3/4" hose that appears to be missing a connector. It appears as though there was supposed to be some sort of male/male insert and some clamps that are supposed to connect these tubes.
Any diagram or a DIY replacement walk-through for the PCV sytem on the 1.8T? Now that I've found the pcv break, I'd really like to get it changed out.
View 3 Replies
When stopped at lights I start to smell burning oil coming from the vents when I have the heat on. It only happens every now and then and only when you are stopped at a light. I tried letting the engine idle after driving once and I can't smell it when i open the hood. I do synthetic oil changes every 5,000 since the car was new. I don't know what it could be? My last oil change was about 2,000 miles ago so I can't see it being burn off from the last change still.
View 4 Replies
Noticed a deodorized smell coming from dash vents when heater put on? After my 30k service I noticed the smell of deodorizer.
View 6 Replies
My check engine light has been on for 3 days i get my appointment with VW and then today i start it up and it goes off. Also, having a problem with very loud squeaking coming from the front bottom left of the engine ?
View 17 Replies
My wife was driving the car on the freeway and flames started coming out of the hood/vents/etc. We just picked the car up from service on Friday...Today is Monday. Whats the standard protocol for a car that's is still under warranty that goes up in flames?
View 24 Replies
My 2001.5 Passat traditionally does not start easily when it is less than 6degrees outside. Today it was that cold..it started easily..but about 30 minutes into my drive to work..I realized it was a little smoky and exhaustish smelling in the car..once I realized it wasn't the car next to me..i realized if I turned off the heat..the smell went away..but at the stoplight..i could see smoke coming from under the hood..out the corner by the passenger/dashboard... Car has 80,000, recent oil change, what it is?
View 1 Replies
Truck is a 02' F350 xlt crew cab, 7.3l, 4x4, 4R100, manual transfer case, 125,000 miles.
So me and the family were pulling out of the driveway tonight and electrical smoke starts blowing out the vents. My wife had just plugged a cheap USB charger into the auxiliary outlet above the cup holders for only 30 seconds. I immediately pulled back into the driveway, yanked the charger out, and found it had melted a hole in the side of it. No smoke had come from the charger or the outlet. The outlet looked fine and wasn't hot to the touch. I pulled the dash off real fast and started grabbing wires, feeling for anything that was hot or melting. I couldn't find anything.
I pulled the cover off under the steering wheel and couldn't find anything. I never turned the truck off while I was looking. After a few minutes, I noticed that the cover over the fuse panel was warm. Pulled the cover off and felt every fuse end and they were all cool to the touch. The relays in the middle were all pretty warm(almost hot to where I couldn't touch them). I was still faintly smelling the burnt smell and I couldn't tell if it was just stuck in my nose. I disconnected the batteries and we had to switch cars(heading to a bbq).
So I just got home and I'm going to start looking for any obvious signs first. What could be going on at the panel? So far, everything is still working. I haven't found any blown fuses.
View 7 Replies
Would having the cup holder replaced on an 08 Wagon with the non climatronic ac system require the disconnection of the right hand side selector that controls where the air comes out.
Just noticed today that no matter what position it's in the air only comes out on the windscreen vents and the two side vents on either end of the dash.
View 1 Replies
I've recently bought a 2002 toyota corolla wagon. I noticed the transmission fluid of the automatic gearbox has been overfilled. This measurement was with a cold and switched off engine and on a level ground. Is this something I should be concerned about and can it cause damage? Should I have it drained to the normal level or is it ok to keep it this way? I didn't come with a manual so I'm not sure if i measured correctly.
View 1 Replies
I have a 01 passat wagon here that wont crank. I would like to know where i can locate the neutral safety switch. Also the only light that works on the gauge cluster is the traction control light until you press the switch and then it will go off too. Would the cluster being broken cause the car to not crank????
View 4 Replies
