Passat (B5) :: 2000 - A/C Work Sporadically - Climatronic Use Outside Temp Gauge?
Jun 18, 2007
My climatronic has been goofy since I bought my 2000 v6 4mo. In the winter my heat never got really hot and now in the summer my A/C work sporadically. I had the thermostat changed along with the full timing belt service. I'm hoping I'll get full heat come september. My A/C, however works less and less often. The tech who did the timing belt change etc. said that there was a lot of pressure at the condenser, but that he thought a flap may have been stuck. he checked those and they are fine. The last two things he said should be checked are the external temp gauge(which is way off, reads 22'F when its like 85 out) or possibly I need a new climatronic head unit.
My questions are esentially these; Does the climatronic use the outside temp gauge to determine cabin temp? Do head units fail often? Are there temp sensors in the cabin other than those built into the climatronic head unit?
View 11 Replies
Advertisement
In my 2000 V6 Passat...I noticed that my temp gauge sporadically works...more often not. Is there a fuse or something that controls it?
View 4 Replies
This is my 2000 passat V6. 87k miles. Over all I love the car. It is starting to make a groaning noise in the front suspension when I go over bumps. Seems to only happen when it's about 40 degrees or warmer out side. It's kinda loud. Smooth roads it's nice and quite. But even little bumps make it happen.
2nd. The temp Gauge on the instrument panel only works every once and a while. I like the car. I can pull almost 31 mpg out on the high way. Needs some better suspension. Buts pretty damn solid for 87k miles. My jette around this time frame was crap compared to this.
View 1 Replies
Water temperature gauge doesn't work. Assumed the problem was the sensor so bought a new one. Installed it, still nothing registering on the gauge after I know the water is heated up (drove it for 45 minutes, heater blowing hot).
So crossed the ground on the sensor and the gauge shot to the top so gauge is working.
Pulled wiring diagram and that sensor is SUPPOSED to register 79ohms for cold and 8 ohms for hot.. So bought a 10ohm resistor from radio shack and attached the water temp lead to it and the gauge read correctly about 1/8 inch from the H mark on gauge. This confirmed for me that gauge is not at fault.
Next I attached the ohmmeter to the sensor itself, boiled some water, placed the sensor tip into it and it read 86 ohms, in freshly boiled water! So at boiling the sensor isn't anywhere near to tripping the gauge to even start reading cold! So I tested the old sensor that I was replacing and in boiling water it shows 94 ohms?
What am I doing wrong, is there an assumption I am making here in error? I want to conclude the new sensor is bad, but the old sensor reads nearly the same reading under same conditions.So yes maybe they are BOTH bad but that seems to be pushing probability.
If it matters this sensor is the type that is inline from radiator to heater core, not the type that is in the engine block, at some point ford changed their sensor setup but didn't change the schematic drawing. Which doesn't matter the only difference is the one in-line has a ground wire to it rather then grounding off the engine block.
Vehicle is a 97 Ford Ranger with the 2.0 liter engine.
View 4 Replies
I just picked up a Black 20th tonight. All stock with 48,000 miles. I'll get some pics up asap. But for now I'm gonna be lurking around trying to work out the kinks of the car. The Temp gauge doesn't work and the passenger door only opens from the inside when first unlocked.
View 15 Replies
Bought this truck, and the engine coolant temp gauge does not work, so I replaced the sender, still don't work.
View 8 Replies
I have a 2000 Accent GL with the 1.3
I was driving home with a known overheating problem, when the temp gauge pegged and a heard a distinct rattling. I knew right away what happened. as I pulled over the engine stopped turning. I opened up the hood, and my suspicions were confirmed. I blew a headgasket. I went back into the car to call AAA, and I heard a loud POP!! the radiator blew from the heat and pressure.
after it got home and cooled down I tried cranking it over and it has NO comression. it just spins.
should I take the time and money to replace the headgasket, or should I just get a junkyard motor?
I know I need a new MAF. I had a "multiplicative fuel system running lean" code for a LONG time. I regrettably assume this is what caused the failure in the first place.
View 18 Replies
2004, 3 door Accent, 150K miles. This has been going on for many summers now (had an idea when driving from work). Well when I got home from work, gauge still read E, turned the car off, then back to ACC, still read E.
Opened the fuel cap, didn't hear any hissing noise or any indication that there was alot of pressure build up, put cap back on, turned to ACC, and gauge read normal.
So after a long story my question is this, is there a pressure regulator that when it over pressures, lets it vent, and what is it called and where is it located? I am thinking that regulator might be stuck closed.
View 1 Replies
Today was drive my x 2000 v10 limited 4x4 114k miles). It was 90 degrees Out and was driving in light traffic going 40 and noticed my temp gauge almost up to h then dropped fast. So shut the ac off and it continue to rise and drop fast I went few more miles to where I was going checked everything could see no problems it sat for about 30mins then left on my drive back home 36 miles and had ac on and no problems stayed where it normally is. I am thinking of just replacing the belt cause I never have. No weeping from water pump. Or any smell.
View 6 Replies
My outside temp gauge will go down to -33 degrees cutting off the A/C. A little later it will go back to normal and the A/C comes back on. Could this be a sensor etc...
View 1 Replies
My temperature gauge on my car sometimes ill notice is being a little over the middle and sometimes till be a little under the middle is this normal for it to do that or should it stay in the middle ?
View 2 Replies
I recently purchased an 03 GLX wagon 4 motion from a dealer as is. It had 84,000 on it when I got it and needed a timing belt. The work was performed by a VW dealer and all has been well until today. I was on the highway, had been working the car pretty well for about an hour and i noticed that the temp gauge which is at 190 religiously is now dropped down as low as 120- 130.
I continued to drive, thinking maybe just a bad sensor/gauge considering I had no check engine light yet. I still have good heat but when I got home I noticed that the coolant reservoir was bubbling pretty fierce. Couldn't tell if it was boiling or if it was compression coming back in from perhaps a head gasket failure.
View 2 Replies
I have a 2000 monte carlo ss. A few months ago the check engine light came on, the temp gauge stopped working, and after shutting the car off you can hear the fan running for about 10-15mins after i shut it off. I assumed it was the thermostat, so that was the first thing i changed. For the first few weeks everything seemed fine. No check engine light, temp gauge worked...then today suddenly it all started happening again. What could be causing it if the thermostat has already been changed? what should i try next?
View 2 Replies
Have a 2000 subaru outback 2.5l, automatic, with about 245k, I replaced the thermostat,water pump, the radiator and the car is still overheating. both fans are working. no leaking coolant. Maybe this is related- over heats mostly when driving on the highway. But if a shift the gear to neutral and coast for a minute the shift back to drive the temperature gauge goes down. Whats wrong, running out money fixing the car, but love it driving it in the snow.
View 2 Replies
I've notice sometimes when i first start the car the outside temp gauge blinks. What does that mean?
View 6 Replies
Alright so noticed the other day that my temp gauge was staying pinned at cold. every once in a while it will jump up to the normal range but not for more than a few seconds to a minute before it drops back to cold. I just bought the car so I've still got a warranty from the dealer and im fairly convinced that I don't have to bee too concerned with it over heating because when the gauge DOES register its saying normal. just thought id ask here before i drive the 2 hours back to where i bought the car.
View 11 Replies
My 01 passat is telling me to check my coolant when it's working fine and its not overheating I think it might just be a sensor because my check engine light is on and it's reading thermostat.
View 6 Replies
This past Saturday afternoon I'm out driving on the highway when the temperature gauge on dash maxes-out and the overheat warning light comes on. I get off at the next exit and stop at the nearest repair shop. (Which happened to be not too far from the exit.) During these moments of driving the car is not behaving as if it were overheating. No steam/vapor coming from the engine, it's performing okay, A/C runs cold, running heater on full-blast seems to do nothing to ease the gauge and the temperature in the engine bay feels about "normal."
So, since this is a Saturday at almost 5PM most of the repair shops are closing (it's a known fact cars don't break down past 5 o'clock on Saturdays.) So they say the'll look at it on Sunday.
I get a call on Sunday and I'm told that as near as they can tell the car is not overheating, the overheat light or check-engine lights weren't coming on and the car is behaving normally. The thermostat is "gunked up" and they recommend new coolant or a coolant flush." I just opt for new coolant, forgoing the flush, as I didn't really have the funds for it, an additional $100 or so. They say there are no codes in the system.
They do it and end up having to keep the car overnight so that the... air bubbles will work out of it? (?!)
I pick it up this past Monday evening and on the drive home the temp-gauge does as it was doing when this process began. It started creeping "hotter and hotter" meanwhile the car is behaving otherwise fine. (No overheat light this time.) Get home, open the hood, no vapor, no excess heat. Nothing.
They spend quite a bit of time running it, hooking it up to a diagnostic machine, etc. While the temp-gauge is sort of "floating around" between normal and "hot" it doesn't reach an "overheat" and the diagnostic machine registers normal temperatures. This time they find a code in the system, though the check-engine light has never come on. They recommend, again, the coolant flush so I go ahead and do it (they give me a discount), and drive the car home, again the temp-gauge "floats" around the dial, never quite getting to "overheating."
I drive to work just fine Thursday (today) morning with no real trouble with the gauge. (Though, FWIW, I had to tap on the dash to get the dash-light on that side of the console to come on.) This brings us to Thursday afternoon.
I make a couple of errands and as I'm stopped at a pharmacy drive-thru the temp-gauge is "floating." Driving home on the highway it reaches "overheating", turning the light on (again, car is not behaving in an overheating manner. A/C still cold, running heat doesn't ease gauge, no vapor from engine compartment.) When I pull in my parking spot the A/C and the car starts to "stall" some and NOW the check-engine light comes on. I shut the car off and I see vapors coming from under the hood.
I open the hood and the engine is covered in the anti-freeze/coolant and the coolant reservoir is empty. The various hoses and such that are clipped on to parts of the front engine cowling are loose (the plastic screw/"snaps" came out of their holes) and pushing on the upper-radiator some and it seems awfully loose. (Like the upper mounts aren't properly seated or something.)
Call the shop ask them what they are doing to me, they say they'll have another look at it and pay for the tow to get the car back to their shop. Awaiting word on what is going on, likely sometime tomorrow.
All of this strikes me as very, very odd and all seems to pile up quickly from taking it to this shop. With a replaced thermostat and flushed coolant I have a hard time understanding how the engine could genuinely overheat. All of the hoses and such seemed fine, and running the engine for a while at the shop the other day generated no problems to the techs working on the car. Yet, they're the only ones who have messed with it. Assumptions on their part Tuesday afternoon were something to do with the water pump (replaced at 100,000 miles with timing belt. Car is now at 145,000 miles.) Or a faulty temperature sensor (or what passes for it on the car) sending false readings to the gauge.
Car is a 2000 Ford Focus ZTS with a 4-Cyl, 16V, 2.0 Liter engine. It has 145,000 miles on it, timing belt and water-pump were replaced at 100,000 miles have had regular oil-changes on (more or less) every 5,000 miles or so. I will admit to not getting coolant changes/flushes as often as one should but the car never really had an overheating issues or problems starting in the winter.
View 19 Replies
I am at work and dont have access to my manual. I was driving into work today and the outside temp gauge dropped from 40 to 39 then chimed and flashed as if to say "he it dropped below 40 outside" then it showed a little snowflake picture next to the temp. I have only had the car since summer-so why was it telling me it dropped to 39?
View 11 Replies
I just Put an 98 1.8 T engine into a 2000 2.8 passat , Everything is working fine , But The Tachometer , The Rpm And The temperature Gauges in the cluster are not working ... The Fuel Gauge also Beep and indicate low fuel when i'm turning ... Actually , the car has the V6 Cluster , i switch those and it make no difference ....
All the wires are hooked up in the ecm compartement , each wire with good color ...
Is someone has both wiring diagram of ecm compartment plug ?? 2000 v6 and 98 1.8T
View 2 Replies
Mine is a 99 gls with the v6 and manual trans. I have 108,000 miles on it and mostly performs great except that my cabin lights are dead (moon roof still works, dash lights even the lights in the doors for the windows and locks light up but not the cabin lights and I can't find a dead fuse anywhere and the dealer looked at it for an hour with no luck). [URL]...
Mine is pretty intermittent at least over the last 6 months, but my temp gauge no longer reads anything and I've gotten a CEL twice now, this second time I pulled the code at autozone with an answer of 1106. I've had my 90k maintenance with the timing belt/water pump/coolant flush service.
I've also noticed when starting it up in the morning I'm getting quite a varnish smell out of it that my wife's 07 Rabbit doesn't produce and my mileage is still around 25 mpg for a 5 mile commute.
Now I see this is a pretty cheap part, so I'm going to wrench it myself but... where the heck is it? I've done the electrical replacement on my 96 jetta wolfsburg that had the 2.0 in it which was pretty easy but my passat seems to be hiding everything under the hood with fancy engine covers and stuff.
View 3 Replies
