Passat (B5) :: 1999 - Coolant Temperature Gauge Reaches At 190 Within 5 Minutes And Stays?
Nov 5, 2010
I have a '99 1.8T Passat. The coolant temperature gauge normally reaches operating temperature of 190 degrees within about 5 minutes and stays there. For some reason, after reaching 190, it sometimes drops by 20-30 degrees and is running cooler than normal. Once time it dropped down, then came back up again, while driving a steady 65 mph. The coolant level is full and nothing else has changed.
I guess there are a few possibilities: a thermostat stuck open too far, a failing temperature sensor, bad gauge, or loose connection at the sensor. The car has 145K miles and the thermostat and water pump were replaced at about 100K miles. What is going on? If it runs a little too cool, is that a big deal? How would I diagnose it? Where is the temperature sensor?
View 2 Replies
Advertisement
Since I bought the car I noticed my temperature gauge has never even touched the middle mark on the instrument panel. Is this normal or is my thermostat hung open?
View 4 Replies
I have replaced radiator and thermostat, awhile back.. I checked and there is antifreeze in the radiator and the reservoir. I don't drive it unless i really have to. and not to far,lots more work to do on it. But the coolant light started blinking the other day. Temperature gauge inside is ok. What could this be? what should I do? Still haven't got the blower working, heater / ac / defrost.
View 5 Replies
Basically my coolant temperature gauge either reads as the hottest it can be, or the coldest. It doesn't jump around a whole bunch, but it's always all the way to one end or the other. From what I've read there seems to be a lot of different temperature sensors, so I get a little confused with all of the abbreviations, but I'm fairly certain I checked the correct one, next to the thermostat housing.
Using a multimeter I checked the resistance of the sensor, and it was around 600 ohms about 30 minutes after it had been driven. I'm not sure if this is where it should be or not, but it was rising as the truck cooled off.
Anyway, I'm not sure if I just tested the sensor incorrectly or if there could be another issue. A friend of mine suggested that the thermostat may have gotten stuck or something, but it doesn't seem like the gauge would switch at all if that were the case. What I should check to try and fix this.
View 7 Replies
I have a 2001 ford ranger xlt 2.3L and the temperature gauge has been staying a cold. And my heat doesnt heat well. I'm guessing I need to replace the thermostat. Before I do that could it be anything else?
View 9 Replies
I got an 88 celica convertible from my neighbor. This is a fixer upper. It needs a battery and an alternator. But i jumped it and after idling for 10 minutes, the temperature Gauge was almost in the red. Yes the radiator has water in it. Is it the thermostat? Or the head gasket?
View 2 Replies
2007 Honda Odyssey. 105,000. Temperature about 0. 6 hour drive. About 15 minutes from destination, no heat, car starts blowing cold air. Temperature gauge still registers in normal range. Arrive at destination. Later that night, drove about 15 minutes to local ER, and drove back from ER about 2 hours later. No heat, but car otherwise fine. Next day (happened to be Christmas Day), begin drive home. Drive a little more than 15 minutes (about a minute passed the hospital), stopped at a stop light. Car stalls and dies. Restarts, but immediately temperature gauge shoots way paste "H" in a bad way.
Over the next day, local mechanic (in Petoskey MI) checks car, says it is low two gallons of coolant. He says radiator leaks, but he has no radiators there. Everything else works fine, and he says it is safe to drive back to Chicago, as long as I stop to check coolant. Drive home to Chicago, no leakage. Everything works fine. Get home, take car to local Honda dealer. They do "pressure test." Find no leak. Head Gaskets are fine. They see evidence of massive coolant leak (dried coolant all over catalytic converter closest to radiator, and over lower portion of radiator) but find no leak, and coolant level is fine. No sign of any leaks at top of radiator. So, what gives? Car is since running fine, no leaks. Everything works. Still driving in extreme weather in Chicago. Coolant level normal.
View 7 Replies
so on last saturday while i was driving my coolant gauge went from "operating temp" and dropped to cold. I was at cold for a few seconds and then bounced between cold and "operating temp" a few times before.
Now this morning driving to work the car warmed up fine to "operating temp". I was driving to work and all the sudden the gauge just goes straight to cold and stays there. I tried messing with the heater control buttons, turned on the a/c, defrost, heat, blower on high, blower on low... everything. Needle never moved from cold. I had heat at every temp desired, a/c got cold when i turned it on. I don't have a cel or any error codes showing...
View 8 Replies
Last night I went to drive my car and my coolant light went on. I checked the overflow and it was very low. There was barely any left in the overflow. I thought this was strange because I had just checked the coolant a couple days ago. The coolant that was in my car was an orange color (after searching I realized that I think this is g12 which I was unfamiliar with). Before searching I added Prestone 50/50 pre diluted green coolant. The bottle said it was mixable with any type of coolant color or kind. After reading more threads I'm seeing that I think the g12 just contracted with the cold weather and I should of just left everything. I have barely driven the car since adding the prestone. Am I doing harm mixing in the prestone? If so, How can I fix this?
On another note, With the cold weather my temp gauge seems to be acting a little funny. Once the car is up to operating temperature the gauge will then drop around 40-50 degrees. It will then stay like this while im driving, but then will go back to normal once the car is stopped and running.
View 3 Replies
I was driving and noticed that my temperature gauge went close to the warning zone so I blasted the heat and it went back down. When the car cooled I popped the hood and noticed that the coolant reservoir was pretty close to full but I couldn't see any coolant in the radiator. I filled the radiator with water for now but it looks like it gone again. I cannot spot any actual cracks or leaks on the hoses but I did spot a puddle of coolant in the groves on top of the transmission. The closest hose I can spot next to the puddle is the lower radiator hose but I really do not know too much about cars. I also noticed a hissing sound today coming from the radiator cap, which I am going to replace. Where the leak could be which is causing the puddle on top of the tranny?
View 4 Replies
Temperature gauge quit working after changing the thermostat and coolant.
With the engine off, I disconnected the single wire from the temperature sending unit and switched on the ignition without starting engine. The gauge pointer stayed in at the Cold mark. Using a Jumper wire, I grounded the sending unit wire and the needle on the gauge went to the Hot mark.
I quickly turned off the ignition, and replaced the sending unit with a SW-2328 (F1SZ-10884-A) Temp Sender. Warmed up the engine, but still no reading on the dash gauge.
View 8 Replies
Just about every trip i take my temp gauge pegs and dinger goes off and check gauges lights up in the message center. It eventually will go back to normal or if i shut key off and restart truck it goes to normal. im guessing it is the temperature sensor for the gauge but not sure?? If it is, where is the gauge sensor located?
View 14 Replies
The needle has always stuck dead on 190f when it gets up to temp. About a week ago I took the center grill of to paint, I put it back on and the check engine light came on ... code p2433 secondary air pump problem. I figured I had just disturbed something etc. Now the coolant gauge is going up to around 240f during normal driving, the fan stays on for about a minute when I turn off the ignition.
View 16 Replies
2005 Hyundai Tiburon Keeps Overheating
I live in Washington State and have a 2005 Hyundai Tiburon with less than 110,000 miles. I have had it for 5 years, and have not had any issues with the car until recently (last 2-3 months). My car overheated on me back in May while out running work related errands. I was able to leave it parked downtown while my husband took a break from his job to come pick me up. Since then, it has continued to overheat every time I drive it.
The temperature gauge climbs into, or dangerously close to, the “red Zone” within the first 10 minutes of driving. The first couple of times the car overheated, if I was using the air conditioner, it would start blowing hot air instead of cold air and the air would stay hot. Now when I drive the car with the air conditioner on and it over heats, it continues to blow cold air (if that matters at all).
My super handy husband (a certified motorcycle mechanic) has done the following in an attempt to fix the car:
•Checked coolant levels
•Topped off coolant
•Bled coolant system and added yet more coolant
•Replaced the thermostat
•Replaced the radiator cap
•Water pump was replaced November 2012 (not even a year old yet)
The radiator cap was the most recent fix. It was replaced on a Wednesday evening after testing it and finding that the existing one was not maintaining the proper PSI. The car drove great around town for two whole days without any issues (Thursday & Friday). Saturday, I decided to take it on a longer drive out of town to see if my good luck would hold…it didn’t. I drove a total of 30 miles round trip and my car started overheating after about 20. I limped back into town and barely made it back to our apartment.
My car continues to overheat!! What is going on?! So confused and frustrated I’m hesitant about taking it to a mechanic who, my husband is convinced, will just charge me to check all of the things he has already fixed.
View 7 Replies
2002 ford sport trac.I have been having an ongoing issue that started with the engine cranking but would not turn over until an hour passed. After replacing multiple parts (cam shaft sensor, crankshaft sensor, ignition pack) I am now down to poor fuel economy as the last of the issues (roughly 12 in the city and 15 highway). I was told the issue may be the engine coolant temperature sensor going bad so I decided to replace it. I found this was very difficult due to it being a plug and locking pin design and in a very tight spot in the engine.
I tried to purchase a replacement and the parts store kept trying to insist on selling me a part with threading. I finally found someone that figured out the issue and found the part for the 2001 sport trac had the same plug style with clip that did fit but was shaped a little different on the sensor end which I assume was due to being aftermarket. I noticed that there were two plugs side by side and the one easiest to access was on the left and I was told the one on the right was the sensor that gave the temperature reading to the gauge.
After installing the engine coolant temperature sensor I found the temperature gauge on the dash now will not respond and is sitting below the cold end of the gauge completely off. Is it possible this is because the part was for a 2001? Is the sensor on the left (passenger side) the engine coolant sensor?I would hate to put the old sensor back in just to test if that's the issue due how difficult it was to put that locking pin back on. What to check that could resolve the gauge issue before pulling this sensor back out?
View 3 Replies
My 2001 1.5l works fine when cold however once it reaches temperature it will hiccup and then stall! It WILL NOT fire up until it gets cold again. Usually happens when we are coasting to a stop. I'm not a mechanic but can am mechanically inclined. I brought it to Autozone and had the computer codes sent (yes check engine lt was on) One code was a fuel lean code. Cannot recall the exact number. When it act up it sounds like there is either no fuel or no fire. I cleaned the mass air sensor and put fuel treatment in it and I replaced the fuel gas cap.
View 1 Replies
Recently my car had a stroke.... the fuel gauge (analog) stays on zero (digital-miles remaining in tank) says ---- even though i just put gas in, the ac isnt working the outside temp reads -- celsius when it should say something and fahrenheit, driver side switches only puts down driver side window, i can't move the side mirrors the controls are unresponsive. the radio won't turn off on its own when i turn the car off or start on its own when i turn the car on. the car is driving fine no change in how it responds. the only thing wrong is 95% of all the electronics.
View 4 Replies
I have a 99 Passat GLX VR6 and the temperature gauge basically works when it wants to. Of course the darn thing works when I take it to the dealer to get checked.
View 3 Replies
My 1989 740 Turbo wagon cuts out while I'm driving. It only ever does it at about the point when the engine first reaches its normal operating temperature. It can cut out while idling or when driving at normal speed. I'm not sure if it's related to temperature or time (it usually cuts out at about the 5-8 minute mark), or if this is simply coincidental. It does it nearly every day.
It's definitely caused by the fuel pump relay cutting out. I've replaced this already, with no improvement. Something is causing the relay to suddenly lose an input.
Once cut, it takes a few quick flicks of the key to the START position for the fuel pump relay to receive power again. It will then drive faultlessly for the rest of the day. Although, if allowed to sit and cool for many hours, it will sometimes do this again.
View 7 Replies
Recently (3 months ago) I had the timing belt, thermostat , water pump changed . Just yesterday I noticed that the engine temperature gauge was all the way to the left and did not seem to be functioning. I do not know if it had been like this for the 3 months since the maintenance work....maybe not. But, the guage is not working.
View 4 Replies
I have a 2012 Passat 2.0 TDI (140) DSG
Sometimes the engine temperature stays low for an entire drive. Regardless of speed - it has happened while sitting in traffic for hours or while sitting at 70mph.
When this is happening, the engine temperature gauge will go up and down, but never reach 90, and the oil temperature reading fluctuates from around 60 to 80. Also the air into the car doesn't get hot enough, but now we're out of winter that doesn't matter too much.
But then other days it will be 100% fine - it rises up to 90 within 10 minutes of a cold start and stays there the whole day - and the oil temperature sits between 90 and 100.
I've taken it to a couple of VW dealers but obviously it behaves perfectly on those days! I remember reading something about a thermostat that circulates coolant to the DSG box, which can cause these kinds of symptoms?
View 5 Replies
