My truck is making a metal on metal rattling noise when going over undulations or the type of vibration when you drive over a rumble strip.
It seems to be coming from underneath the engine area, but not quite sure. The sound is like a kettle lid clanking on the actual kettle when the water's boiling if you can hear what I mean. No noise when just driving.
1988 Ranger, 2.9, 5 speed, 2wd, 7.5, 3.42:1, 190K or 290K on the odo.
I've been hearing this rattling, sometimes kind of a metallic ping, from the rear the last week. I thought it was probably the universal joints, didn't do it often, only under load between 1500-1900RPM roughly in second, third and fourth. I planned on working on it this weekend.
Today it started really making noise, sounds like valves rattling as though the timing was too high but it was coming from the rear end. It was making it all the way through the gears into fifth, even when cruising. Once it cooled down a bit it nearly went away.
I'm going to get started on it as soon as I can, but I can't get it in the shop to pull the differential cover and take a look right now. Dad's shop is full of crap, I live on top of a hill, not many safe places to get one up in the air properly. What is causing that sound?
I have an 04 rx 330 with air suspension. The swaybar end links have just been replaced on the front and a rattling noise persists.
The noise happens over large and small bumps at high and low speeds at normal and low vehicle height. When the height is at "HI" the noise is louder and it feels as though the front end is shaking loose over bumps at 10 km/h+.
I took it in and was advised to replace the end links, they did so and returned it claiming the noise was gone. The air compressor and struts are in working condition.
I have done a search through the forum, not extensive... I was wondering which other components come loose/wear and cause a clunk/rattle/shudder noise.
Also, tires are new and at approx. 32-34 psi.
Heard this noise from the suspension when going over bumps with the windows rolled down? It's loud enough to where i am sure it could be heard if you were a pedestrian walking next to the car. I have an IS350 Fsport (AVS), sounds pretty junky.
View 14 RepliesWhile driving through a tunnel today I noticed a metallic rattling noise upon acceleration. It goes away immediately when I let me foot off the gas and when I park the car and rev the engine the sound does not occur.
A few days ago, I had to rapidly accelerate and it felt as though I lost power for a split second. I am not sure if these are related, but I am hoping its not some sort of transmission issue (unless that is covered under the hybrid warranty. What was the diagnosis?
I'm pretty sure I know what the problem is since when I hit the brakes it stops. When I took the left side tire off and right side I compared and there is a thin metal sheet that has room to move on the right, but is tight on the left. When the brakes were done before maybe it didn't seat correctly or something. Just wondering what that plate is called so I can order one and change it. Driven that way 2 years, but it bugs me when the window is down and people probably think my car is falling apart. Maybe I'll search for a brake diagram.
Edit: I think they might be called "anti squeal shims". I saw a picture of them, so maybe they didn't put enough high temp grease, but the left side is tight and the rights side you can move a couple milometers side to side so I'm sure that's the jingling noise.
I am a brand new VW owner and new member of this site. Just recently I purchased a '02 Passat GLX 4motion (w/97k miles) for fairly good price knowing that it was involved in a rear end accident.
Now I am finding multiple issues with this car. It looks excellent from exterior or interior. I have three different issues (front and rear axle pinion seal leak, broken spring, gas leak only when tank is full) with this car but I would like to discuss the Broken Spring issue here.
When I go through rough road or bumps I hear a metallic noise (noise like key chiming) from the rear driver side along with a rattling noise (like wood or plastic board rattling) at the same time from the rear middle part of the car. I researched online and found few forums talking about the brake pad caliper spring making similar noises. I called a mechanic and I was told that it could be the muffler.
I took the wheel off and kicked and hit the axle area with rubber mallet, kicked the muffler - but no similar noise was produced. However I noticed that the spring coil (rear driver side) was broken right at the bottom. When I did online research I saw one forum talking about broken spring making similar noise. I did more research and found the part (OEM# 4B0 511 115 B).
My question is:
> Does this sound like what causing the noise? Could a broken spring cause metallic chime and a hard board rattling noise?
> Is it necessary to replace the spring along with the shock absorber? Can spring be replaced by itself?
> How hard is it to replace a spring?
> Do you have to have spring compressor to mount and unmount? Can you simply take the whole assembly without compressing it?
So I noticed this when I had my windows down and the music off (or very low) for the past few weeks (at this point). About 3800 miles on the car, and maybe once or twice during a drive It is an occasional clank/ metallic noise that sounds like it is coming from either the left or right side depending on which tire hits the bump. But I can go over any number of bumps before and after with no noise at all, and it's not like I'm hearing it on just large bumps/ potholes. I've never heard it on any speed bumps.
I have a feeling it is when only one tire drops down a bit from a small bump, but that is only a feeling, and it's on small bumps. I tried looking up other threads on here for suspension noise, but mostly only finding things dating back to 2011 or so with brake caliper pins, possibly motor mount but nothing really recent.
My '99 Legacy is far from quiet, but yesterday I heard a new -- and somewhat alarming -- noise.
Roughly two-thirds of the way through a four-hour drive, I started to hear a rattling or grinding sound coming from the front of the car, perhaps closer to the driver's side than the passenger's. It sounded as if a tin soup can or paint can were hitting the road, but when I popped my head under the car, nothing was hanging loose.
I hear the rattling sound as I begin to accelerate, and only when I have my foot on the gas -- when I let off, it's perfectly quiet. What I haven't been able to determine is whether the noise goes away after I reach a higher speed, or whether the sound of the usually loud engine drowns it out. The noise is most acute around 1500-2000 rpm whether it's in gear, or whether it's in neutral and I'm revving the engine.
My R32 has got about 9,400mi on it, and for the past 3k miles or so, i've been dealing with this metallic scraping/rattling noise coming from underneath the car. When I took it to the dealer, they said it was the exhaust flex pipe, so they replaced it under warranty. Next day after picking the car up, same noise. So i took it in again this morning and they are saying its the flex pipe again, and they don't know if it is fixable.
They are talking to VW tech assistance, and trying to figure something out. I really love this car, but if VW says there is no fix for it, I'm weary about possible future issues without fixes too. Apparently it has something to do with the length of the flex pipes and the material its made out of. He was saying one possible solution is stiffer engine mounts. We'll see where this goes.
Noticed a weird metallic rattling noise coming from the transmission when switched to N with the engine running and the car is stationary? Almost like the gears are rattling inside while in N position. I took it to the dealer and their Prius guru said this is normal characteristic of eCVT....
View 4 RepliesI replaced my fuel filter on my 2003 2.4L toyota tacoma 2wd. 65k miles. At the same time I checked the valves. No valve adjustment needed. Then i started hearing 4 to 6 rapid metallic clicks from the engine compartment when I start the engine cold. Clicking lasts 1 to 2 seconds. Sometimes happens when engine warm. This fuel filter is not original equipment.
View 1 RepliesWhen i go over bumps at slow speed (such as speed bumps) i hear a rattle in the trunk like something is loose. Its a deep sound like ceramic plate or a brake rotor kinda flopping around back there (not plastic creaks). Sounds almost exactly like a loose spare tire or something. So i checked it, and it was tight. Sound still there. so then i jsut removed everything, jack/tools and spare tires. Sound still there. So then i ran with both the seats down, and up in the locked positions. Def more noticable with the seats down.
It doent seem to make the noise on small sharp bumps when im on the freeway. Usually only rolling slowly (less then 15mph) over large bumps and when the suspension comes back down in rattles. I plan on bringing the car in when my work weeks over, but im wondering if theres anything else i can check in teh trunk area that might be rattleing around.
Ive got an 07 Malibu ls. For quite some time now I have had this frt end noise. Its a tapping rattling noise on fine bumps. Here is the strange thing. It only happens in the winter and then only for a while when I start driving. It kinda goes away as I keep going. When its very cold it doesn't quite go away but gets lots less as the car is driven for a while. Ive checked everything in the front end including sway bar links. Ive made sure the brake calipers arent loose. Ive had it checked out at a reputable shop. Of course as soon as the car is inside a warm shop, it wouldnt make the noise anyways. They have not been able to pinpoint it either. What was the solution?
View 2 RepliesI did my pads and rotors this weekend. On the fronts I had some difficulty with the passengers side retaining clip. It was stuck in on the bottom. I wound up bending it out of place trying to get it off, and eventually just removed the caliper without it.
I took it out for it's first regular drive today and there is a rattling noise when the passenger's side goes over bumps (could be front or back, hard to say). I have theorized that the clip is deformed enough that when it gets jostled, it bumps out onto the rim which makes it go twang (which would be consistent, it's a relatively high pitched rattle. I'm going to look at it tomorrow, but I'm not sure what I should actually do. Can I just clip it off? What purpose does it serve? I might be able to get it out with WD40 and bend it in to shape.
Whenever I go over bumps or a rough piece of road there is a faint rattle coming from the drivers door. It just started doing it about a week ago and its driving me crazy . I am thinking door seal? I've called the dealer and they told me to come in to check it out.
View 7 Replies2008 GX 470 ... Experience noise that sounds to be coming from the back hatch/toolbox area when going over harsh bumps? If so is there a known fix for this? I was thinking of adding weather stripping in a couple of strategic locations.
View 4 RepliesAll the body bushings have dry rotted away on my 08 Superduty. Are these hard to replace?
I am starting to hear and feel more road noise and rattling when going over bumps or a rough road. U think they would have used polyurethane bushings instead of rubber.
When I'm driving over sharp bumps I hear what sounds like a small chain jingling around. I took off the hubcaps and jacked up the car to see if anything loose. I grabbed the exhaust pipe and shook it, but it didn't make any noise. I couldn't see anything that would cause it. The front right strut's rubber cover is off so could the strut make that noise?
I just read a few posts with similar problems, but one was a compression sound and another was a knock, and another was a metallic hick up. Mine is literally like a loose high pitch chain noise and change rattling in your pocket. No uniformity to the sound. But it also only happens over quick small bumps not large ones like speed bumps.
Our 07 RX350 has 47,000 miles and I just starting to hear (I think from the front) a faint rattling noise while driving. It's hard to describe but it sort of sounds like what you might expect if an empty plastic bottle was slowly bumping around in a plastic box. It is not a metal on metal type of noise. The shocks/struts appears to pass the old bounce test and the car does not seem to display any of the handling issues you get when you have worn shocks/struts.
I also checked the upper engine compartment to see if any plastic shrouds or covers were loose - they weren't.
My '05 Lexus RX330 has developed a vibration and rattling noise, that I believe comes from the exhaust system. Looking for info on trouble shooting or quick repair?
View 10 Replies