Hyundai - Santafe :: 2008 - Stalls After Filling Gas Tank?
Nov 16, 2013
I have a 2008 Hyundai Santa Fe. Runs great, except for the last two months, every time I fill it with gas, it tries to stall out when I start it. Once I get it running for a minute or so, it is fine until the next time I fill it with gas. Tried filling it with premium gas a few times to see if that made a difference...it didn't. Took it to my mechanic; he said the car was fine. This only happens at the gas pump and no other time.
View 5 Replies
Advertisement
I have a 2008 Hyundai Sonata that overflows at most gas stations when filling. To fill the tank, I set the pump on autofill and walk away. The pump clicks off and then the car "burps" and gas comes out the filler neck and runs down the outside of the car and out the bottom. It does not do this at one gas station by my house but seems to at all others almost every time. The car is still under warranty (42,000 miles but the issue started at 29,000) and I have brought it to the dealer 3 times. Each time they claim to have found something new wrong and fix. The first time they replaced the fuel filler neck, 2nd time fuel filler neck assembly (and tested at a gas station and it worked), 3rd time the vent valve. Each time I try it and it overflows for me (except at that one gas station). I have never had this issue before with any other car including my wife's current car. I'm truly stumped, but feel that a car should be able to fill up at a gas pump without overflowing.
View 3 Replies
I have a 2003 hyundai Santa Fe that has had a problem for a few years that I can not figure out, nor can the hyundai dealership. (Though they seem to only want to hook it up to a computer, which tells them that nothing is wrong.) After filling up the car with gas, the car will turn over, but will stall immediately. You can press on the gas and it will stay going, but once you take your foot off the gas it stalls. It act like when you used to flood the corroborator. It takes about 4 times of turning over the car and stalling before it runs normally.
It is a GLS 4-cyl automatic AWD.
View 9 Replies
I have a 2005 Hyundai Santa Fe, about 128,000 miles on it. For the past 5 months or so, the engine simply won't start after filling with gas - and only after filling with gas. I've tried filling partially from near-empty, as well as filling full from halfway or more full...it consistently won't start up after filling with gas.
After turning the ignition, the engine will turn over, but quickly quits. Lately it's had more trouble turning over at all. To get the car moving, I need to actually feed it gas with the pedal, and "simulate" idle. Even after a couple of minutes, if I let off the pedal it dies right away....as if gas just isn't getting to the engine on its own.
In order to get the car moving, I just have to keep feeding it a bit of gas while shifting to drive (and stepping on the brake), then I give more gas and let the brake go almost as if it's manual-transmission....off it goes.
Oddest thing: as soon as that happens; as soon as the car moves forward (even just to get out of the gas station), everything's back to normal. The car idles healthily at the next stop, as if nothing happened.
No check-engine light, no diagnostic codes come up with a scan. Same results on warm or cold days. Most recent maintenance on it was new spark plugs almost a year ago (doesn't seem related).
Of course, the only time it DID fire up normally after filling with gas was when I had the mechanic with me in the car!
View 4 Replies
I have a 2003 Santa Fe with 108k miles on it that seems to have an attitude problem. I was driving home from a Christmas get together on the highway, when my engine stalled, hiccuped, stopped and the check engine light came on. When I tried restarting the car, the engine wouldn't fire. The battery was fine, and I had a half tank of gas. After about 15 minutes of sitting, I was able to get the car started and driving again. After about a day and a half and a refueling, the check engine light went out and the car behaved as normal until this evening.
I went to the gas station, put $15 in the tank (brought the tank up to about half), and as I was stopped waiting to pull onto the road, the engine died. No hiccuping, rough running or anything, it just plain stalled and shut off. Again, after ~15 min, it started. I turned back up the road to head home (Was going to head about 30 miles west to see a friend but decided against it), after I stopped at a stop light, it stalled out again same thing. Waited ~15 min, it started back up with the check engine light back on. (But wait there's more!) Another stoplight, another stall. This time however, it would not start at all after 30 plus minutes. By this point, my battery was pretty run down, so I managed to get a friend to give me a tow.
I have to bring it it for servicing tomorrow anyway for a completely unrelated issue, and just towed it over to the dealer.Any clue what gives or what I should make sure the dealer does?
The internet seems to want to point me towards a bad ignition coil or a bad crankshaft sensor, but my mechanically inclined friends are leaning towards an electrical issue or a problem with the fuel filter/pump/line.
The check engine code is P0335
View 5 Replies
After driving the vehicle on the highway (30+ minutes at 65+ mph), exiting highway on an exit ramp and coming to a stop (at stop sign or traffic light), the engine will sometimes stall and shut off. Immediately thereafter, vehicle can be restarted and driven. There are no other symptoms, abnormal sounds, vibrations, etc.
I thought problem might be caused by vapor lock. However, Hyundai dealer service center checked fuel pump, fuel lines and vacuum hoses, etc. but can not duplicate, identify or repair problem.
View 1 Replies
Having trouble filling gas tank, the pump nozzle keeps cutting off. Have to fill by dribbling the fuel in until filled. What the problem might be?
View 5 Replies
After over filling my fuel my car stalls (sometimes) on going back to idle. Not sure what to checks, check engine light is not on.
View 2 Replies
I have a 2008 Hyundai Santa Fe . Since January 2013 I have had the heater core replaced 3 times. The repair shop has done the last 2 at no charge to me. The dealership ran a diagnostic and could find no reason for the repeated heater core failures. I feel there has to be something going on with the car that is causing the heater cores to keep failing. When the original one started leaking I had around 70,000 miles on my car. I bought it new.
View 6 Replies
My daughter's 2008 Elantra starts fine and seems to be idling okay. But recently at seemingly random times the car will stall within a few yards after she starts driving from a cold start. She will start the car, start to drive and then all of the dash lights come on and the engine shuts off. So far she has been able to turn the key and immediately restart the car and then it is fine after that. The problem always seems to occur after she has driven somewhere, let the car sit for a couple hours and then tries to drive again. We took to our mechanic and they said there are no diagnostic codes and the fuel pressure seems good. They did identify some kind of voltage drop/issue with the mass airflow sensor and replaced it. But a day later the problem occurred again. Mechanic seems stumped. I'm very worried about my teenage daughter driving a car that randomly stalls.
View 2 Replies
My car pulling to right significantly at all speed. Alignment checked mechanic says its normar to have car goes to right. I have similar car for 10 years 140,000 miles never have this kind of pull with many tires changed and rotation of all kind. While mechanic was doing wheel alighment white brown greese / liquid came out from steering rack on right side. Mechanics says its just oil seal from steering rack oil seal. Car was pulling to right before this rack leak as well. Mechanic says need special bolts for this car to adjust some camber on this car and can make this better.
View 9 Replies
Trailblazer 2008. This has happened 6 or 8 times. When fuel tank is 1/4 full or less, decelerating downhill from 50 mph to make a right-hand turn, the engine stalls as I reach the turn. Of course I lose power steering and brakes.
If I stop in that downhill position, the fuel gauge reads ZERO but the Low Fuel light is not showing. Turning the key to restart does not restart the engine but if I roll to a flat piece of road or to an uphill position, the engine starts immediately on turning the key. The fuel gauge continues to show ZERO until I turn off the ignition completely and restart. Then the fuel gauge immediately returns to indicate 1/4 full.
No warning lights of any kind show on the dash. There is no question of the gauge showing a false 1/4 indication when the tank is actually empty, since I can drive for 30 miles after the incident while the gauge slowly drops lower until I fill up again with gas.
SOMETHING tells the engine it has no gas so it stops. No stutter or indication of fuel starvation. Simply an engine shut-off.
I tried to reproduce the effect immediately after it had happened by turning the car round and retracing the route, but it did not happen a second time at that location, but it did repeat a few hours later at another intersection.
View 6 Replies
Headlights will not go off no matter what the switch position. Can only get them off by pulling the fuses
View 1 Replies
While driving, the ABS light came on, with what felt like the brakes. That stopped, now the ESC light comes on (or blinks), still with the brakes, or something acting against the wheels. This can happen at any speed and only happens from once a week to once every few weeks. What is going on?
View 2 Replies
I have a 04 santa fe 2.4L 4cyl. I recently did an engine swap, old motor threw a connecting rod. I put my intake, exhaust manifold and head on it. Timed it. All new gaskets. Turn the key and it fires right up and runs great. But when you accelerate it sounds loud (almost diesel like) and doesn't shift at the right time, also while trying to cruise it will drop about 300 rpms and then come back up, then back down and up every 3 to 5 seconds. The transmission was fine when the old motor came out. The head/intake were fine also. All the vacuum lines are connected, cant hear a vacuum leak anywhere. But it keeps throwing a throttle body sensor code and it wasn't broken when the old motor went, i even swapped another used one on it and it still throws that code. I am thinking it has to be intake related.
View 4 Replies
My 2004 Santa Fe doesn't want to start after fueling. It doesn't matter whether it was just a few dollars worth or a full fill up. After pumping the gas and recapping securely, I have to press and hold the Accelerator to get it to catch. I had the purge control valve replaced a few months ago. And my car started mourn normally for a while. However I'm back to having to push progressively harder on the gas pedal to get it to start after gassing up.
View 5 Replies
My (mom's) Hundai will not start. It tries to turn over but never makes it. We don't smell gas, not flooded, might be the fuel pump. The code sensor device will not give a code to indicate a specific problem.
In the past, the car will give a static shock every time you get out and push door closed. Very difficult to start and gas must be pumped to start after gassing up. Also, a bell (ding sound) rings at random even if the car is driving. What to look at next?
View 11 Replies
I have a 2004 Hyundai Santa Fe with about 83,000 miles. Lately it has been having issue with the rpm's going low and stalling out while I'm driving. I've taken it to a mechanic and it has not been resolved. He said it does not need a tune up and it's nothing with my fuel. I've also heard it could be a crank shaft censor but he says no. The check engine light has come on sometimes, very quickly but then goes off.. He ran the code but nothing came up. So then what's causing my car to do this?? While the car is running and I'm in park, the rpm's will go from 2 to almost 0 then back up again. While I'm driving down the road it does the same thing and sometimes it completely stalls out while I'm going about 40mph. So incredibly scary. What this could be so I can take it back and get it fixed!!!! I'm so scared to drive it but I have to get to work.
View 3 Replies
About a year ago, I tried to top off the tank of my 2003 Hyundai Santa Fe. Since that time, the car has been sputtering as soon as a fill up. It doesn't sputter at other times. I have heard that I may have damaged my evaporation system. I have taken it to quite a few mechanics who tried to work on the evap system, but they could not solve the problem. Is there a simple and easy way to fix this??
View 6 Replies
the passenger seat in our 2015 hyundai santa fe sport is not power but the seat can manually adjust forward and backward and the back rest can be moved backward and forward. The seat cannot be moved up and down. It is way too low and it feels like sitting in a "pit". The dealer said to sit on a pillow but when I sit on a pillow the air bag light will not go off (so the passenger air bag is not activated). If I sit on a book, the air bag light does go off but who wants to sit on a hard book all the time. The air bag warning light does go off when I sit on the seat itself.
View 12 Replies
My car is a 2007 Hyundai Santa Fe GLS and does not want to start only after fueling. It will also die when the fuel cap is removed. There is an excessive amount of vacuum pressure released when cap is removed. The computer showed a code: P0441 Evaporative Emission Control System Incorrect Purge Flow. Is this simply a fuel cap issue or something else?
View 5 Replies
