Honda - Pilot :: 2006 - 2nd Catalytic Converter In 24K Miles
Feb 27, 2016
I needed to replace the same (rear) catalytic converter of my 2006 Honda Pilot LX (2WD) in less than 16 months. The first time it happened in October 2014 when the vehicle had 160K miles (Car's service code was P0420), and the second time it happened this month (same code P0420), when the vehicle had 184K miles. I have it replaced at Honda Service both times.
When it happened for a second time so quick (160k miles wth first converter vs 24K miles with the second converter), I asked Honda Service for a free warranty replacement, but they said it only has 12K miles, and 12 month warranty on repairs, they called Honda corporate to see if they would do anything extra (they did not), but Lute Riley gave a discount to do it at their part & labor cost only ($800 first time vs $550 second time).
What could be the cause of the second catalytic converter to go bad so quick? I have been the owner and only driver of the vehicle since i purchased it new and my driving habits have not changed.
View 17 Replies
Advertisement
My car had its check engine light come on a few days ago, and the engine started to get extremely loud whenever I was accelerating. I would also smell gas whenever I would start the car. I decided to take it to a mechanic, who did a diagnostic check and told me that my catalytic converter was busted. This troubled me because I had just had the part replaced a little over two years ago. I figured the part would still be under warranty, but the mechanic that I had used to replace the cat told me that it was only under warranty for one year or 12,000 miles, according to the distributor. Well, I got a hold of the distributor, and he told me that he didn't have the information for the specific part that he used (he just told me that he "figured" it would be one year or 12,000 miles because most of the parts that they receive have warranties of that length....). Shops are closed now for the weekend, and I am getting worried about my bank account here...should I be?
Well, my questions for you all are as follows:1) Have you all ever heard of a catalytic converter ever having only a 1 year or 12,000-mile warranty? My current mechanic tells me he has never heard of one being so short, and that usually they are 5 years or 50,000 miles. I did minimal research on the internet and also found similar results.2) Who do I need to get into contact with in order to find out how long the warranty is, and how I redeem the warranty?
View 4 Replies
My wife and I have a 1997 Honda Accord, roughly 260k miles. A few months back the Check Engine light came on, diagnostic came back with P0420, typically indicating the catalytic converter is shot. Who am I to argue, it was an factory part. So we replaced that with an inexpensive Magnaflow converter. (don't have the part number on me); this was 5 days ago. Today my wife takes the car in for inspection. Check Engine is still on with the same code. The guy at the testing station begins laughing at my wife when she says we only spent about 200 in parts and labour on the new converter. I'm inclined to think that since we already replaced the converter that I should be looking somewhere else (O2 sensor maybe). But I also don't want to just start throwing parts at it. Do I have a case here? I would really prefer not to spend $1000 on a car that old with that many miles on it just to pass inspection.
View 4 Replies
The check engine light on our 2005 Honda CRV (146,000 miles) came on and stayed on. After a week of driving with the light on we brought the car to the dealer to have it checked. The dealer diagosed a faulty catalytic converter given a P0402 diagnostic code and didn't think the P1078 code for the intake manifold a problem. The dealer also stated that the oxygen sensors were fine. We declined the dealers offer to replace the catalytic converter for $2,170 and the check engine light was reset. After two weeks of daily drifting and 1000 plus miles the engine light is still off. Did we actually have a problem? Why hasn't the light come on again?
View 8 Replies
My wife drives a 2005 Honda accord and the catalytic converter heat shield recently fell off. I am wondering if it is safe to continue driving the car without the heat shield? I have read that the main function of the heat shield is to prevent fires when parking in long grass. Does it also protect the bottom of the car from starting on fire?
View 1 Replies
The Honda dealership read the check engine light code on my Honda 2002 Accord, that said the catalytic convertor is not operating within the efficiency range(plus the converter has a rattle in it...it is not the heat shield as it was taken off years ago). They said it was too expensive to have fixed at the dealership and to find an independent repair shop to replace the converter.
They warned me to not get the cheap universal converter as the check engine light for the converter would come back on and stay on. They said get a more expensive one but would not give any specific brand or price range and said it SHOULD keep the check engine light from coming about the converter.
I have an independent shop and they agreed about never using an universal converter. However when I press them about the $270 converter they would put on would keep the check engine light for the converter from coming on, they hesitated in assuring me it would not come on.
Honda Accord converter can be replaced with an after market converter, what did it cost, and did it keep the check engine light for the converter from coming on?
View 2 Replies
The heat shield on the catalytic converter of my 2005 Honda Civic rusted and was hanging on by one nut, so I decided to rip the bottom part off. Is it necessary to get a replacement or can i go without it?
View 5 Replies
We have a 2006 impreza, that we've been told the Catalytic converter is going out. We cannot seem to determine if there are one or two converters on this car, and want to know if this is something that we could do ourselves once we find out where everything is at?
View 18 Replies
I have noticed lately, when the car is hot, while pulling into my quiet garage, and even when the car is in park, engine running --- hearing some clicking / ticking coming from, or near the Catalytic Converter.... It sounds as if a small piece of metal is rattling inside with the flow of air... It stops clicking once the engine is turned off.
View 5 Replies
I wanted to get some input about lowering my 2010 Corolla LE. I wanted to go about 3 inches, but have been told i will need to replace some extra parts. Not sure where to begin, but i'm not afraid to ask questions or get dirty. I hear a lot of different things and i'm on over load with info.
View 7 Replies
I have a 2006 Jeep Liberty with 135,000 miles. My check engine light is mostly on. Sometimes it is off. One mechanic tested the car and said the catalytic converter is bad. Another mechanic said that test can often be false positive and it might only be the O2 sensor. The difference between the two is about $1,000. Which mechanic is correct? My car is registered in a state that doesn't do car inspections.
View 19 Replies
06 Camry SE I4
I had to replace my catalytic converter because of the code I was getting. It wasn't difficult to do, but took me a while because I had to transfer the thread rods to the new CAT. Once the new CAT was installed, I went to test her out, but noticed that the car all of a sudden, has no electrical power. Nothing at all. I checked all fuses and nothing is blown. The only electrical I messed with on the car was the O2 sensor.
Car has a brand new battery from yesterday. The only thing I didn't do is install a support bracket on one side, because it was missing a bolt and one thread rod was stuck in the old CAT, i couldn't remove it.
A friend suggested that the missing bracket may be causing a ground issue. Is this true?
View 7 Replies
I recently purchased a used 2006 Honda Pilot. I now notice a mildew/musty smell that appears to come from the ac vents. I only notice it when driving with the windows down, right after I turn the AC off, and sometimes when I first get into the car. I do NOT notice it when the AC is running or when the fan is blowing. I have had the car detailed twice (thinking the odor was coming from the upholstery) and have hired someone to spray an odor eliminator spray into the vents and air intake. I have also changed out the cabin air filter. None of these actions have worked and the smell remains. I love the car but this odor is really annoying me.
View 2 Replies
At 120K mi, had ALL the service work done. Changing the trans fluid as well as the 4WD differential was due. A noise in the rear diff began. So the mech said a Honda bulletin stated that this happens sometimes when changing the fluid. Ok. Changed it again. ANYWAY, the noise is still slightly there when going from a stopped position .... steering wheel all the way to one side or the other ... and giving the gas. IS THE REAR DIFF BEING DAMAGED?
View 2 Replies
While driving 1 of 3 issues occur... radio will click off for 2 seconds, entire dash turns off for 2 seconds (car continues to run), or all electric clicks off and car shuts off. If left to sit for a few minutes car will restart. Will occur a bunch of times in one trip and then not for a week. Does not seem to depend on type of driving or weather conditions. Honda cant seem to figure out and until the yesterday they blew me off. Yesterday, the anti-theft actually locked out the radio, so at least they could see "something" occurred.
View 5 Replies
My son-in-law has a 2006 Honda Accord with over 160,000 miles on it. About 8 months ago, the check engine light came on. The code said the down stream oxygen sensor was bad. He took it to a Honda dealer and they replaced the sensor and now the check engine light is back on with the same code. Can the catalytic converter have gone bad and can it have made the oxygen sensor go bad too?
View 5 Replies
I recently had my catalytic converter replaced with a non-OEM cat. The check engine light came on and a different shop (different from the shop that replaced the cat) said that it will keep coming on because I had the cat replaced with a non-OEM cat.
View 3 Replies
I have a 2001 VT GTI with 155K miles on it. It is in very good condition. I have loved the car except for the high maintenance costs that typically seem to be associated with VWs.
I found out this week after my check engine light came on that the car needs a new catalytic converter and a new new secondary air pump.
Let's assume that this diagnosis is correct and the repair is accurate for the sake of this posting (and I have no doubt it is). In other words, I don't want to get my question derailed on that issue.
The car has new Michelin tires on it and runs well. The problem is that it will fail the state emissions test I am required to take next December, and I will either be forced to have the car repaired or will not be able to get updated license tabs (isn't that sweet?!).
It seems that I have a few options:
1. Get the repair done (ouch) and keep driving the car for a few more years. Repair cost is about what the market value of the car is (from what I have seen).
2. Sell the car "as-is" between now and December and see what cash I can get out of it. Any buyer will discount the value of the vehicle based on the repairs needed. Of course, then I'll need a replacement vehicle of some sort.
View 16 Replies
See related guides and technical advice from our community experts:
How to Replace a Catalytic Converter
Step by step instructions for do-it-yourself repairs
Browse all: Air Intake and Exhaust Guides
View 9 Replies
I have a 2000 Lincoln Town Car with a single exhaust system, part of/attached to the frontal area of the exhaust "Y" pipe are two lumps with heat shields, the muffler is obvious in the mid-section of the car, but are those "lumps" the catalytic converters, and if so, why two when the older cars had only one?
View 2 Replies
Someone put sugar in my gas tank so I had it worked on at the Dodge place they replaced my fuel pump..fuel filter cleaned the tank..flushed the lines cleaned my injectors and replaced the plugs..I went to pick it up I barely made it a mile down the road I had no power and a lady flagged me down to tell me to pull over because I had sparks coming from the bottom of my van I looked under the van and the catalytic converter was red like hit coals the Dodge place is telling me its my flex plate? I think they are misdiagnosing the issue because before the sugar issue I had no problems with my van?
View 14 Replies
