Golf V R32 :: Rattle Coming From Underneath The Car - Catalytic Converter?
Jun 24, 2016
I have this rattle coming from underneath the car that's been going on for a while.
The car has 110k miles and the rattle is most prominent when I start the car or accelerate hard or just cruising downhill without gas.
I went to one of the well known shops in the area and they said it's coming from the cat and it needs to be replace and quoted me like $1300 for parts and labor which seemed quite steep to me.
They said it's coming from the inside the cat so it needs to be replaced.
Is this a common issue with our cars? I though maybe something is loose and can be just welded together or something.
View 1 Replies
Advertisement
The catalytic converter shield is tack welded on the front end but free on the rear end. There was originally some braided wire packing at the rear to keep the shield from rattling against the pipes. Mine was deteriorated and had been damaged, I think, when I sustained some oil pan damage last summer -- big jolt to the system when running over a muffler on the highway.
The fix is simple. Bought a foot of 3/16" braided stainless steel cable. I used about 8 inches and layed in the lower bead line on the catalytic converter shield (see picture below). You can see a bit of the cable thru the gap in the upper/lower shield on the left side. (1/4" cable would be a better fit, but this will work for a long time.) Cost: $1.84
The local VW parts man dug out an exploded drawing of the system but it showed NO parts or packing for this problem.
View 24 Replies
Heard a funny intermittent rattle and my mechanic told me that my check engine light should be going on any time now as my cat converter is bad. The part is about a thousand bucks! Looked on line and see some aftermarket ones from walker and some other retailers. My car has 103K miles on it,.
View 17 Replies
Took my car to a shop today after I'd been experiencing a "tinny clunking" sounding rattle. I was worried it might be my catalytic converter and after couple of bumps on the exhaust system while on the lift, the tech thought this was indeed the case. Replacing the catalytic converter could be a $1500+ job from what I hear if replaced by toyota.
View 17 Replies
My wife's car is a 2002 Prius, 149 k miles. Lately the check engine light has been coming on. I took it to the dealership, and their assessment is that the catalytic converter needs to be replaced. They are recommending about $2,000 + of repairs. While I am contemplating the practicality of investing that much in keeping this car going I'm wondering if it harmful or dangerous to continue operating this vehicle.
View 12 Replies
I have a 2001 VT GTI with 155K miles on it. It is in very good condition. I have loved the car except for the high maintenance costs that typically seem to be associated with VWs.
I found out this week after my check engine light came on that the car needs a new catalytic converter and a new new secondary air pump.
Let's assume that this diagnosis is correct and the repair is accurate for the sake of this posting (and I have no doubt it is). In other words, I don't want to get my question derailed on that issue.
The car has new Michelin tires on it and runs well. The problem is that it will fail the state emissions test I am required to take next December, and I will either be forced to have the car repaired or will not be able to get updated license tabs (isn't that sweet?!).
It seems that I have a few options:
1. Get the repair done (ouch) and keep driving the car for a few more years. Repair cost is about what the market value of the car is (from what I have seen).
2. Sell the car "as-is" between now and December and see what cash I can get out of it. Any buyer will discount the value of the vehicle based on the repairs needed. Of course, then I'll need a replacement vehicle of some sort.
View 16 Replies
After hearing some loud noise coming from my exhaust system, it was determined that there is a hole (from rust) in part of the cat. assembly. Three shops advised for replacement, there are no aftermarket products for this unit. I have NOT gotten any error codes, the only problem is the noise. What to do? The car is 10 years old with 86000 miles. I have been reading about some of you getting just the one piece and having it welded on, but I do not believe any of the shops here will do that, and indicated that it would be a very temporary fix.
View 17 Replies
Took my car in for emissions and says catalytic converter is not ready.
What can I do to make this go to "ready"?
I've recently got my computer flashed with new programming.
Since it's been flashed, I've driven the car over 400 miles.
All of the cars self checks should be complete, I can't figure out why the catalytic converter won't go to ready!
Any thoughts or tricks to make it work?
View 6 Replies
My check engine light has been coming on and off and it seems to show P0420 for catalytic converter. The light stays off for about a week and it'll come on for a day or two and off again.
Wouldn't a failed converter stay failed? Can P0420 be triggered by loose/bad gas caps?
View 3 Replies
Does this mean the DPF is shot? I believe its integral with the cat. whats worth checking first?
View 2 Replies
105,000 miles on my R32, starting to get check engine light for catalytic converter. Any cheaper options to VW originals that won't harm performance?
View 1 Replies
My exhaust on my 01 was rattling. It was coming from the catalytic converter, I assumed it was the heat shield. Put it up on the lift and lo and behold it was something in the cat that was rattling. I was popping a code for the cat anyways so figured I'd just swap it out. Fast forward to tonight. I get the car back up on the lift and I wiggle the cat but no rattling? I go farther back to the first muffler/resonator now it's rattling. It's not a hanger or a heat shield or metal to metal on the outside, there is obviously something of substantial mass inside of it I can almost feel where it is by wiggling around. I chose to wait and cut the exhaust up a different night because I plan on taking that section out as well now, hoping to get out whatever is rattling. If not I'll just have some spare pipe on hand to replace it.
View 6 Replies
Car is a 2001 MK4 Jetta with 2.0 Auto Tranny and 120k miles, stock exhaust
A little over a year ago I was getting a cel and the code that was being thrown was a DTC 16804. I changed the cat and both o2 sensors and the light went away for almost a year. The other day I was driving and the light came on again. Scanned the car and its the same 16804 code. I replaced the front o2 sensor thinking it was bank 1 but it didn't solve the problem. I clear the code and it comes back the next day. I'm finding it hard to believe that the cat is bad after only a year. I checked for vacuum leaks, faulty MAF and nothing under the hood looks out of whack. My mission is up next month and the car won't pass with this code.
View 5 Replies
Title says it. Cat is done. Threw code p0420 and am experiencing hesitation at WOT. Already replaced my front o2 (cbfa) and now I'm debating whether or not to get a new downpipe. I daily the car and am wondering if keeping the car as is for a while will damage anything. Cts turbo has a sale for a catless downpipe.
View 5 Replies
I have a 2002 Santa Fe that has started to have a very loud rattle. It sounds like it is coming from underneath the vehicle toward the rear, possibly the passenger-side wheel-well, but that specific location just may be an auditory illusion.
[URL] ....
View 4 Replies
06' F150 4x4 XLT SCrew 29K-mi
I have a rattle of some sort I can hear coming from underneath towards the rear while under acceleration. Usually hear mostly at certain RPM and not through entire accel to hwy speed. Do not hear it while in Park and reving engine, but on the road I hear it. Mostly I think after it gets hot or something.
No driveability issue only rattle? While I was reving in Park I could hear a bubbling after I let off the pedal. Is that normal. I don't think it is the same noise/rattle.
View 14 Replies
The clamp connecting the resonator and the catalytic converter is leaking around the edges. I changed the bolts and tightened the clamp but still leaking.
View 24 Replies
I recently had my catalytic converter replaced with a non-OEM cat. The check engine light came on and a different shop (different from the shop that replaced the cat) said that it will keep coming on because I had the cat replaced with a non-OEM cat.
View 3 Replies
See related guides and technical advice from our community experts:
How to Replace a Catalytic Converter
Step by step instructions for do-it-yourself repairs
Browse all: Air Intake and Exhaust Guides
View 9 Replies
I have a 2000 Lincoln Town Car with a single exhaust system, part of/attached to the frontal area of the exhaust "Y" pipe are two lumps with heat shields, the muffler is obvious in the mid-section of the car, but are those "lumps" the catalytic converters, and if so, why two when the older cars had only one?
View 2 Replies
Someone put sugar in my gas tank so I had it worked on at the Dodge place they replaced my fuel pump..fuel filter cleaned the tank..flushed the lines cleaned my injectors and replaced the plugs..I went to pick it up I barely made it a mile down the road I had no power and a lady flagged me down to tell me to pull over because I had sparks coming from the bottom of my van I looked under the van and the catalytic converter was red like hit coals the Dodge place is telling me its my flex plate? I think they are misdiagnosing the issue because before the sugar issue I had no problems with my van?
View 14 Replies
