I need a way to make my both fans be on constant during track days, I know induction makes a fan kit for the mk4 r32 which works great but the controller in the MK5 is different and the kit don't fit.
View 8 RepliesI have a 2001 jetta 1.8 turbo. when I turn the car off the cooling fans stay on and kill my battery. Ive been told it could either be a relay or temp sending unit but i dont know what one to tackle first, also my coolent temp stays way low almost as if the thermostat is stuck open.
View 2 RepliesI can usually find what Im looking for with a quick search but I have had no luck with this issue.
View 19 RepliesMy 2003 camry LE 4 cyl cooling/radiator fans stay on all the time. As soon as I turn the ignition key both radiator fan start to spin even though the car is cold and not on. I checked all the relays and fuses. Checked the voltage on the coolant sensor harness with ignition switch on, there is no 5v or the green pin is not grounded. I am clueless where to go next.
View 14 RepliesSo I replaced my big fan today. Everyone knows that the factory fans are notorious for going out. After replacing the fan, I turn the car on and noticed that both fans were on... and never turned off. So I turned the car off, and turned the car over again. and they still were constantly running. I messed with the climatronic controls and when I have the settings on auto the fans are constantly running, when I have it on econ, they don't run. And when its on neither, the fans are constantly on unless I turn it off. Before replacing the fan, I replaced both the FCM, CTS, and the fan switch. Its becoming pretty frustrating. I supposed it could act as my own switch for the fans, hahaha. I've searched and havent found anything like this. Hopefully its something small
View 2 RepliesThe last few times I drove my car, I noticed the A/C didn't feel very cold. I checked today, and noticed that neither cooling fan comes on with the A/C on. My understanding is that both fans should be in LOW mode with the A/C on. Also, after idling for a while and even after doing some spirited driving and pulling over, the fans never turned on.
From what I'm reading, this sounds like it probably is either the fan control module or the fans themselves failed. Is the fact that both fans don't work in either high or low speed point to this being more likely to be a fan control module? Would this show up as a fault code on a VAG-Com scan?
After about 3 weeks, I finally get my 04 .:R32 back from the shop after getting a new fuel pump (long story there) and the mechanic mentioned the fans began to run and stay running when the key is turned to the on position and then turned off, key removed etc. I picked the car up tonight and repeated his claim turning the key to the on position and the fans kicked on and stayed on until the battery was disconnected. I am hoping there is an easy fix. What this could be? FCM maybe?
View 20 RepliesI have a quick question, I got a 2005 mk4 gli, and when the cooling fans go on, only one works, the other one does not, I checked the fuse and its fine.
View 13 RepliesWhy recently the fan comes on when I start the car, then a few seconds later it turns off, then a few seconds later it's on regardless of outside temp or engine temp? Is this simply caused by a malfunctioning green coolant temp sensor? What type of electrical Gremlin causes our cooling fans to cycle "on" and then "off" every three seconds?!
View 1 RepliesMy 03 Golf ac is not working and i am looking for a wiring diagram/ troubleshooting chart. the cooling fans turn on low and I hear the engine surging like the compressor is trying to cycle but it is not.. When I jump the low pressure switch the fans go to high and no power to the compressor. I get a flash of power to the compressor but just a blip every ten seconds. I am trying to check continuity of the ac clutch but having a difficult time getting in there hot. I just bought the car and fixed light body damage on the right front but it was not even bad enough to hurt the washer bottle. Hard to believe the hit caused damage to the ac? AC seems to be charged with about 100 psi static pressure. Why are diagrams so hard to find?
View 2 RepliesI have a problem I can't seem to figure out. My car has a misfire at idle. It has stumbled every once in a while at idle before while at Red lights. Now it does it all the time. Check engine light is on and I got 5 codes. P0300, p0301, p0302, p0303, p0340, and p0012. The last two are for cam position sensor. I took it outo and looked at it. Looks fine. I reinstalled it and hand cranked the motor with a meter hooked up and I am reading about 10 volts when it senses the metal ring going around. So I think that is good. I sprayed brake cleaner on all the hoses to see if the motor reved to hopefully find a vacuum leak. Nothing. I also noticed today that my cooling fans or my ac don't work. Now I have another issue to deal with. I checked all my plugs and wiring and coils also.
View 1 RepliesI've decided the first issue w/ my new-to-me jetta I want to focus on is the cooling fan constantly running. I suspect this is potentially related to the temp gauge not reading anything, which I suspect might be because of the coolant temp sensor.
So basically, when I turn the key to on (I'm pretty sure it's on, not start), one of the cooling can comes on. It's the fan on the right side as if you are sitting in the driver seat. I've been looking at the wiring diagram for this issue as well, and the only other thing I can think of that isn't a computer involving issue would be the thermo switch. But it seems like both fans should be coming on in that case, and it's definitely only the one fan that is coming on.
The heater fan quits working on colder days. It is not the fan motor, as twice after it has quit, several days later the fan began working again. As controls are switched, the indicators light and mode shifting sounds can be heard. It seems to be that the fan quits on the colder days (<38 deg) the will resume working again when the outside temperature exceeds 50 degrees.
View 7 Replies2002 F250,heavy duty. Problem, AC cools while driving at night or even on a cloudy day but on a hot sunny day you have to run on max and even then will not cool cab. I had gas checked they said it was good to go. I bought this truck new and the ac has always been weak in my opinion. I took it to dealer the first summer I owned it everything checked out ok. What the problem might be?
View 11 RepliesI have issues that are drivin me crazy. Cooling fans not coming on. I was driving and smelled antifreeze, I immediately looked at gauge was at 210. So I stopped to check, right side of radiator was split. Put new radiator in waterpump and thermostat. As the car was running during the flush process it started spewing so shut it down gauge was 210. Plugged in Modus ran codes were none for overheat. The cooling fans are not coming on while car is running, but I can turn them on with the with the modus so fuses and relays are all good. The one thing that puzzles me why it works with modus but not by itself. If that's not enough started a couple weeks ago sometimes when hitting bumps loose power to windows, radio, convertible top, and then hit a bump and it starts working again. I have been all under the dash and hood checking connections and grounds to no end.
View 2 RepliesOne of my cooling fans will not shut off, I think it is the aux fan. Anyway it will fun till batt is dead either hot or cold .
View 2 RepliesMy 97 lesabre cooling fans won't come on. the car gets pretty hot when driving around town. I saw on another form that they should come on when the Air Conditioning is on but mine does not. I got the fan to come on when connecting it directly to the battery so i know the fan is good. I replaced the high speed relay with the horn relay and still nothing.
Im not opposed to putting a switch in the cabin but im not sure the best way to go about doing that.
I own a 2004 V6 Touareg as I have been going to the dealership for the last three months now and they cant solve the problem.
Once I start my car in the morning, immediately both cooling fans start running and they wont stop until I shut down the car, it takes them about 10 min to shut down.
In the process of resurrecting my 93 SSEI after running at idle for awhile the engine was pretty hot. I noticed the fans never came on. I unplugged the temp sensor and both came on. So would the problem be the temp sensor, thermostat, or relay. I am not sure what the actual engine temp was because my Cluster only works when it wants to, usually when its warmed up and going down the highway or when I mat the throttle.
View 10 RepliesI have 05 prius and the cooling fans wont kick on as well as the ac wont work. I have had the cooling fan motors checked they are good. I have changed the 2 cooling fans relays and the cooling fans still wont kick on.
When I bought the car the check engine light was on so I had it scanned and it threw the code P1121 coolant valve control. so I went and bought this part since I heard it was a common problem but haven't got it put on yet. Could this cause the cooling fans to not kick on and ac not to work or is it something else?
I have an 06 Passat 2.0T, and last night whenever I shut off the car, the cooling fan is constantly running. I had to unplug the battery so it wouldn't drain it, and about 5 hours later, I hooked it up and it stays off. I also noticed when turning on the air conditioning, the smaller fan doesnt kick on. I'm lost and don't know where to start. Could it be a thermal switch or the whole fan assembly
View 19 Replies