Golf IV R32 :: Groaning When Turning - Power Steering Fluid (Big Leak)
Mar 20, 2014
I was driving home the other day when i heard a groaning when turning. i stopped to check the power steering fluid at O'PepZone and it was really low. i bought some fluid poured it in while the car was running. it foamed a bit from all the air but then the PSF started emptying out of the reservoir underneath the car.
By the time i got home it was groaning and basically empty of PSF again. when i crawled under the car, i saw a lot of fluid on the passenger (right ) side of the car by the subframe and a little bit by the driver (left) side of the car. the leaks seem to be from the ends of the rack and pinion. no detectable leaks by the hose/hard line connections.
Other than the leak(s), the steering has felt very good. no play to speak of and no weird sounds either.
This makes me wonder if i somehow damaged the seals when i installed my PSS9 coilovers....
View 24 Replies
Advertisement
A few days ago my car started making a groaning noise when I turn the steering wheel. Sounds like it's coming from the middle of the car. Makes the noise whether the car is moving or not.
View 12 Replies
A few days ago I had a big PS fluid leak. Turned out the return line had been sliced a bit. I had to drive it for a couple days before I could get around to fixing it. The steering is still stiff and the pump whines. Is this an indicator that I need to replace the pump?
View 4 Replies
Yesterday while cruising around, my right front tire hit a bumpy rock, it was quite a tough hit, but the car kept cruising well. I parked it one minute later and inspected it, nothing seemed wrong. After 2 hours i came back and looked under it. no oil was dripping or anything, still run well for 10 minutes. then, the steering started to ROAR.
Basically, the car was dripping and no power steering oil was left. I didn't do a full inspection yet. I brought the car yesterday on a tow truck and today is Sunday so no mechanics are open in my country.
I took this picture which represents where all the oil is dripping from. also there's a video [URL] .....
I'll be taking the car for inspection tomorrow, but i want to hear from other MK4 owners if they know where the oil might be dripping from. Ican't state if the dripping happened due to hitting the damn rock...do you think it's related?
View 3 Replies
Well my car is crapping out lately,
I put a new steering rack in my mk4 1.8t jetta about a week before I parked it for winter. I went out to the garage yesterday and noticed a pool of PS fluid on the ground, I located one very small leak from the bottom banjo bolt on the rack (needs new crush washers, Was in a rush and didn't have time to pick new ones up :bang head: ).
But the part that confuses me is there is a puddle on/under the passenger side subframe, the rack boot appears to be dry, and I don't believe the new rack is faulty, they are supposed to be all tested and approved before reaching the buyer. and when I turn the car on I can't see a leak anywhere even with the wheel off and a decent view of the rack.
View 7 Replies
I noticed over the last week that there was a pretty loud whine associated with turning the steering wheel. I checked the fluid level and it didn't seem low. I added a touch just to make sure. Took it into the dealership today and they called back and told me there's a bunch of fluid on the bottom splash pan. They haven't said what the culprit is yet. 46k miles on the car.
View 6 Replies
I know I have a leak in my power steering fluid return. I bought the big expensive green jug and top it off when I need to. The past few days, when I start up my car and turn around in the driveway, there's a groan when I turn the wheel in either direction.
View 3 Replies
My Camry 2011 (55k miles) had complaints of power steering fluid leak and needs rack and pinion assembly replacement.
I have powertran warranty only, so this one is not covered and when asked for the dealership for estimate, they said it would cost around 1700$.
Can i get this replacement done at local shop, if so will there be any problem to my powertran warranty ?
View 5 Replies
I have a leak coming from the top of my reservoir from the under the cap for some reason. I bought a new cap and it seem to stop for a day and now it leaking out from under the cap again. What is the reason it would be coming out of there. Am I going to have to replace the reservoir??
View 1 Replies
2004 XG350 with the Sigma engine, 133,xxx miles.
In the picture I attached, the large silver bolt is leaking. Its a slow leak: yesterday morning I wiped it off, and then we I got home from work there was a bead of power steering fluid, but not enough to drip.
What is the best way to fix this? Is it as simple as tightening it?
View 3 Replies
1994 Plymouth Sundance Duster (4 door, automatic transmission) with 97K miles.The power steering fluid leaks every now and then, and sometimes I have to fill it twice in a week. There is some fluid leaked onto the ground.1. What possible causes could these be? (How to diagnose the problems?) and how much might it cost to repair? 2. I need to drive the car ~2,000 miles from Chicago to LA in August. What major checks do I need to do before the roadtrip to ensure a worry-free ride? (I need to fix the A/C for sure). Also, is this car able to haul a U-Haul trailer (5' x 8' in size) with household goods worth a small studio apartment?
View 6 Replies
105K miles, developing a groaning noise when turning steering wheel during low speeds and stopped. Can feel slightly through steering column. No other problems, no clunking or any grinding noises, just "groaning" sound on initial movement. Fluid is full. While searching fix, I found this article on the C70 model, sounds like I might have same thing on my XC90. [URL] ....
View 6 Replies
I had been driving around with gallons of ATF in my trunk for a year until I recently had the power steering pump changed on my 1996 Toyota Camry (which spent many winters sitting outside up in Canada), and now the leak seems worse. I brought it to my mechanic who wants $800 to change a leaky rack & pinion and a hose. But I am but a poor, unfortunate grad student and so I have no more money to put on this old, yet beloved car! So he suggested I put in a combination of ATF and brake fluid, which might slow down the leak. What say you? Will I ruin my newly acquired power steering pump or make matters worse?
View 6 Replies
My '95 Avalon with 120K miles drive & handles like a Lexus. Had the power steering pump replaced 18month ago. Still has a small leak of power steering fluid. Which lines are likely to leak and how much should it cost to correct this in Colorado?
View 1 Replies
My 2010 F-150 Lariat 5.4L 2WD Ext Cab with 76,000 miles is leaking power steering fluid. I traced it down to the cooling coil in between the radiator and the transmission cooler. It does not look easy or cheap to get out of there. Stop leak scares me a bit...
View 14 Replies
I have a 2004 Santa Fe 3.5L with 85K miles. TB, WP and all belts changed at 75K. Have had this whine noise when I turn right, very high pitch noise. On top of this there is now Power Steering fluid leaking from the reservoir and base and brackets are full of fluid... Needless to say I assume it is the reservoir seals giving up but why the noise only when I turn right? No noise when I turn left.
What could it be? Also where can I find parts online that are cheaper than the stealership? I called them and they quoted me $72.00 for this piece of plastic!!
What else should I change? There is also some "oil/fluid" coming down a pressure hose but I believe this is due to the oil dripping from the reservoir...
Any manuals I could use to view this? I bought the Haynes manual and it's worthless!
View 1 Replies
Yesterday the power steering exploded on our 2008 Lexus RX 350 spewing power steering fluid all over the under carriage of the car and the garage floor. Left a trail every where we went. The loss of fluid caused the power steering to quit working. I had no prior signs of any leaks of any kind and no noise or symptoms from the steering prior to this. Had this happened on the highway at speed, I don't know what could have happened.
Loss of steering and the catalytic converters covered in oil could have resulted in a fire and or wreck. I see on line that power steering leaks seem to be a problem with many Lexus models. I have heard that a screen/filter in the power steering solenoid can clog causing the pressure in the system to go sky high blowing the rack seals. Some have said that by cleaning the filter and flushing the system that the problem can be solved without having to replace the rack and pinion.
View 3 Replies
My power steering seems to have sprung a leak. There is quite a bit of fluid below the passenger side of the steering rack. The leak seems to be right below where the power steering hose comes down off the pump, gets secured to the chassis and changes to metal line from rubber. The metal line then goes into an L bend and is routed towards the driver side right where the leak apparently is.
I haven't had a chance to have a good look, as it was 10:30 at night when I parked it and looked (12km of careful city driving since it started to act up)
Is this a high pressure or return line?
The leak seems to be forward of the steering rack, so hopefully I wont have to replace it.
View 8 Replies
Replace the seals in a power steering rack on a Passat? I recently noticed I had a fluid leak after seeing spots on my driveway. After discovering it was power steering fluid when I checked the reservoir, I checked all the lines and found the leak coming from the rack on the drivers side. The boot on the steering rack had come loose and there was fluid leaking from the side of the rack. Is there a fix for this or am I looking at a expensive repair?
View 6 Replies
2005 Santa Fe (88K, 2.7 V6).
For a month or two, after the car got warmed up, I'd hear a whine/hum noise when I slowed to turn or reduced speed. The noise was much more noticeable when the car had been running at least 15-20 minutes, but I did occasionally hear it when the car was somewhat cool still. Never had a problem steering during this time, even with the noise... but I eventually figured out that slowing down and/or turning brought it on. So I took it to a mechanic.
They showed me bubbles coming from the power steering reservoir, and said I needed a new PS pump and pressure hose, along with a flush/new fluid. I paid for all of that.
Next day: The car would become hard to turn when I made a tight turn into a parking spot... again, not a constant thing, but only when turning to park and going slow. The noise APPEARED to be gone, but this new issue worried me so I took it back. They put a different pump on (no charge), thinking the other may have been defective.
Next Day: I hear the whine again on my way home from work. When I get home, I park, leave it running, and pop the hood. There's a fast drip bubbling from beneath the reservoir cap and running down to the pavement. First thing the next morning I return to mechanic. He says the first two pumps were the same brand and both "remanufactured" so he switches to a different brand -- this one brand new, not "remanufactured" -- and installs that one.
A half hour later, I get home. Hearing that same whine/hum, I lift the hood. Fluid is pouring out from beneath the cap in a steady, unbroken stream (not a drip, but a stream). So I took it back to the mechanic (who to his credit, has charged me nothing since the initial new pump installation). What could cause the power steering fluid to gush out from the reservoir cap when the car gets hot? I have a brand new pump and pressure hose. What could cause this condition..
View 12 Replies
I am a new owner of a 2004 F-150 FX4. Bought the truck with a leaking power steering and I have isolated the root cause of the leak. It is coming from the "transfer line" attached to the center of the rack. The top portion has simply rotted through. I have searched the forum and google for about a week and only found one thread where someone actually asked about replacing the hard line on the rack. Unfortunately, no one chimed in with a part source and all my searches only come up with a HP line or Return line....no hard transfer line leading from the rack to the gear box.
View 7 Replies
