Golf IV R32 :: Fuel Pump Fuse Keeps Blowing
Oct 24, 2014
My R32's Fuel Pump Fuse keeps blowing. This started after driving my car in a bad rainstorm. I think water may have gotten in the door which could be causing the short, but I am not sure. This car has two fuel pumps as it's been modified. I know for a fact the main fuel pump works as it did prime after replacing the fuse (then letting the car sit over night then opening the door). Right after the fuel pump primed though, the fuse blew. I decided to replace the fuse and start the car. The car started and ran for maybe a second or two before the fuse blew. I took a look at this thread in regards to the fuel pump not working as I thought the fuel pump was dead till today. I was wondering what are the possible problems that could be causing the fuse to blow? Could it be the relay? Could it be the switch in the door shorting? Also, where would I find the relay? I know it's under the dash, but is it under the panel on the passenger side or driver side?
View 1 Replies
Advertisement
Ok so I just bought this car, 1993 pontiac grand am se, from a neighbor. When I test drove it, the back seat was all unscrewed so I thought no biggie and it drove really nice for being a 1993. Ended up buying the car. I get the car home, husband puts seats back together and we go to leave for town and the fuel pump fuse blew. Put a new one in, go to start the car, fuse blows again! Tow the car home. Husband checks the wires to make sure there is no faulty wires. Has to reground the ground wire. Car then starts. Go to drive down my driveway and the dang fuse blew again! Mind you there is a new fuel pump in the car so we know this isn't what is wrong with it.
View 4 Replies
When I changed the alternator on my 2000 plymouth neon, I crossed the wires for the plug. Now the fuel pump fuse keeps blowing, when it turns over, which isn't often. I turn the key and nothing happens.
View 2 Replies
I have a 2000 F150 with @175K miles. Replaced the clutch about a year ago, replaced the front calipers a few weeks ago, due to the right front locking up on my way home from work. Since then, when I try to start, it blows the fuel pump fuse. (#10)...
View 2 Replies
I have a 1994 Ford Ranger king cab 4x4 with a three inch lift kit on it . My problem is the fuse is blowing that goes to the fuel pump . It started out blowing the fuse now and then when it was raining . Well I thought it mite be the fuel pump going bad but after I put the new pump in the truck it lasted about a week and started blowing fuses again . I put another fuse in and it go a few days and blow it . Last week on a 100 mile tripe I got almost there and it burned a fuse on the highway . I tried to put another fuse in and it would blow it as soon as I tried to start the truck . Burned five fuses right then . So I had it towed to mothers house and put another fuse in and it cranked up . I looked at the wiring that was not wrapped in that plastic cover stuff and have not found anything yet ...
View 14 Replies
I have a '96 Dodge Stratus that keeps blowing fuse #20, which is for the fuel pump and the ignition. How to isolate the problem? This happens as soon as the key is turned on. The car has 140,000 miles and runs excellent otherwise.
View 3 Replies
My 1996 Ford Ranger's Fuel Pump- Fuse keeps on blowing... (Fuel pump is new)... We need to find where the short is coming from!
View 2 Replies
The fuel pump fuse keeps blowing intermittently. I would assume it's a wire grounding out somewhere but I can't seem to find one yet. I do have a faulty purge solenoid on the canister but I don't think that would cause this. The reset switch doesn't seem to be tripped either.
View 3 Replies
Long story short, my car died on me shortly after pulling out of the driveway a few weeks ago. Initially I thought it was my fuel pump because it wasn't priming when I had the key turned to the "ON" position. Here's what I know for sure:
The fuel pump works. It was tested and is not the issue. The relay is good.
The fuse from number 28 is good. There isn't any power at the fuse. The shop has been tracing wires and looking at diagrams and cannot find any breaks in any wires.
The ECU has been swapped for another one. When I turn the key to the "ON" position, the check engine light and EPC light come on, then turn off after about 3 seconds. They do not stay on.
What else could it be? Car in question is an 01 Jetta 1.8T AWD motor code.
View 9 Replies
my wifes explorer is getting no fuel. (there is a valve I depressed similaR to a tire valve, I pressed it once some fuel dribbled out, and thats it, turned the key several times and not a drop off fuel. I went as far as checking the fuse, the fuse is not blown. what are my next steps of trouble shooting.
View 8 Replies
I have a 2010 V-6 Camry that has been sitting for a couple years, changed the oil (what a system that is !) and was wondering the location of the fuse or the relay for the fuel pump is so I can crank the car over awhile to build up some oil pressure before I start it .
View 4 Replies
Which one is the Fuse for Fuel Pump on a 2014 VW Tiguan?
[IMG] [/IMG]
View 2 Replies
It's a 2007 Nissan Murano with 50k miles and I've had it about 2 years. Occasionally, it won't start and this has happened about 7-10 times in 2 years. It turns over and makes all the normal sounds of starting, but never catches and starts the engine. Normally I wait a few minutes, try it again with some pumping of the gas, and it will start. I take it to Midas for oil changes and told them about it - they said the computer revealed nothing.Yesterday it would not start and I had to have it towed 90 miles home. The tow truck driver said he could not hear the fuel pump "priming" when he turned the key or, he said, it might be a fuse. Two hours later when he delivered it to my home and got off the tow truck, it started.
View 10 Replies
- Fuse Box - Part # 3C7T-14A067-DC Engineering Number on white label.
- Ford Dealer Part # 3C7Z-14A068-DB
I have a 2004 Ford Excursion 6.8L 4x4 that has a bad fuel pump relay. I am looking for a used replacement fuse panel.
Of all these number and letters which of them tells me the real part number? Does the last two letters mean anything "DC" or "DB"?
So I don't get one for a diesel, what is the prefix for the diesel? I am assuming the 3C7T is gas and the year model?
Also, will this fuse panel interchange with a F250/F350 6.8L or do I need to stick with a fuse panel from an Excursion?
View 1 Replies
I have a 92 caprice 5.7. Vehicle had suddenly stopped ... Providing fuel to the tbi. I immediately checked relays etc all were good. Then I figured it had to be the pump because I didn't hear the whirl of the pump with the key forward engine not cranking. I replaced the fuel pump. Still same problem no fuel. I found the 20 amp fuse blown that sits next to the 2 relays. I replace the fuse then the fuel pump got energized as I cranked the engine it almost started but then the fuse blew again. I have a short in the circuit I believe. I don't have a wiring diagram,what else is on the fuel pump circuit so I can have a direction to start in to find a probable bad wire.
View 3 Replies
So the other day my 20amp maxi fuse for my fuel pump decided to blow, put a new one in & everything has been going good since. Is it just a fluke or is this an indication my pump is going out? I inspected wires off the pump & connections for corrosion & that's good, fuel filter is also new about 2 months ago & I always run #1 diesel with a little additive in the winter.
View 1 Replies
I have a 2013 f150 & the fuel pump relay fuse burnt out. I unhooked the battery cable "wasn't thinking" & took the fuse out & replaced it. Now my truck wont get over 3000 rpms & is driving like i got bad fuel or something. & now its throwing codes about my trac & I don't know why. Just from unhooking the battery cable & hooking it back up. What it is??
View 7 Replies
I drove my truck 2 times the day it stopped running. The 3rd time I tried to leave it started moved about 2 ft, spit and sputtered and died. It had blown the fuel pump fuse. I changed it and checked the fuel shut -off in the cab, passenger side. It was not tripped. Tried to start it and as soon as I turned the key it blew the fuse again. I changed the fuse again and this time I changed the fuel relay and the switch in the cab. Turned the key and it blew the fuse right away. Went to AutoZone because they are close to the house described what it was doing to them and they said sounds like a short in the fuel pump.
I purchased a new pump put it in turned key blew the fuse, pump just clicked...I found this site and my son noticed a thread where it said wires under the cab are good for wearing through and grounding out. I looked and it did wear through one wire coating. We taped it up, put extra cover over it and now it does not blow any fuses. Fuel pump still just clicked. Took fuel pump back for an exchange.....same thing. Turns over but fuel pump will not pump fuel. What am I missing?......
View 3 Replies
Having an issue with my car blowing fuel pump fuses every once in a while under heavy to moderate acceleration. Have replaced inline fuel filter and the fuel pump resister(white ceramic part). Runs fine with normal driving, but when I want to get some horses out of it, it will cut out and stall and once i replace blown fuse it will start back up again, and I'm off and running again.
View 2 Replies
FUSE 38 Keeps blowing...it controls the fans and dealer is not sure why. Coolant fan control (FC) control Module.....
View 6 Replies
I have a 2000 V70/XC volvo with 95K miles. I began hearing a strange hollow noise, like a whistle blowing. I took it to the dealership where I bought the car and they said it was the fuel pump. I asked them if it was bad and needed to be replaced and the said they weren't sure about having it replaced right away. They said sometimes it will make that noise and the fuel pump could last for months and sometimes for years. They even suggested to just drive it until it fails then replace it. some say it could never go out. But it bothers me because it is the car that my wife drives daily taking kids around and running errands and so forth. I am always worried that she could get stuck somewhere anytime. So I am not sure what to do.
View 3 Replies
