Golf IV R32 :: Continuous Clunk From Front Suspension After Coil Install
Jul 20, 2012
I have a 24v gti, but this deals with the front suspension. I replaced my stock suspension with a set of coils and also my drivers side axle with a raxle. Even have new strut mounts, bearings and R32 rear control arm bushings.
When I drive slowly like coming out of the drive way I can hear a continuous clunk happening 1/2 second to 1 sec apart coming from the front suspension, but after I drive a min or 2 it goes away??
View 2 Replies
Advertisement
I just had a set of VWR springs installed on my 2011 GTI (35,xxx).
I've noticed a very discernible clunk coming from the driver's side front wheel particularly when traveling over a dip in the road (when the spring and suspension is extending). The sound only comes from the one wheel well - the other three sound fine.
I'm bringing it in for an alignment tomorrow (recommend after the spring install). Sounds almost like a bad bushing?
View 11 Replies
My R's only got 5,400 miles on it and I just lowered it Saturday on H&R Springs and when I turn my steering wheel like 3/4 either way it makes like a clunk noise at lower speeds only....any other part besides strut top mounts and bearings? It sounds like its coming from the right front.
View 9 Replies
So I've always had a clunk coming from the front end of my car since I bought it last year. It happens almost every time the suspension flexes. I'm pretty sure my steering is okay as I can turn the wheel quickly and/or forcefully back and forth with the car either on or off and there is no noise; the steering feels solid.
Here is the list of things I have done so far:
-Poly sway bar bushings
-Poly end link bushings
-Poly dog bone bushings
-Cup kit (Springs and shocks)Upper strut mounts & bearings
-Ball joints
-Raxles
After a quick look at my Bentley manual, it seems the only things left to do are control arm bushings (most likely in my mind) and sub frame bushings (less likely). Is there anything else I should check for possible causes that I'm missing?
View 2 Replies
I've got a "clunk" in my front passenger side suspension. I'm running stock struts with H&R sport springs that I put in about 10,000-15,000kms ago. The clunk is inconsistent and seems to only happen in the parking lot when I'm backing out of a stall. When I pull forward, I get a couple clunks coming from that side? Could this be tie-rod?
View 17 Replies
So I was searching around online and it seems this thing happens to some ppl after lowering their cars. I'm getting a loud pop/clunk noise from the front left side only. Seems that's the most common place ppl are having this type of issue with. What it could be? My mechanic wont be able to look at it till Friday. So not sure on what to do. The sound only happens when I'm hitting bumps on the road.
View 6 Replies
I recently installed my FK Silverlines and they ride great and look even better. However, they are very clunky. In fact, my whole front end is clunky. Last night I double checked all bolts and retorqued everything with load on the suspension by using a floor jack under the control arm. It sounds like everything is loose and coming apart.
View 24 Replies
I am doing the coilover install this weekend and plan to remove the axles. Is there a way of removing the axles, without buying and using a puller?
View 13 Replies
This previous weekend, my buddies and I finally got my FK coilovers installed on my GTI. I have heard that people say there is a little bit of rattling upon them getting properly seated. Well it has been 4 days of driving and now sounds like the rattling has gotten worse! I took it into a local suspension shop and they couldn't put a thumb on it. We in-turn found out that my rear hub bearing was going out and has since been replace. Having issues with coilovers? I have contacted the company that I purchased them through already and am awaiting feedback from them.
Pic of the car in question. (Before coilovers)...
View 21 Replies
I recently got an MK7, coming from a MK5, and I installed the VWR springs 8 days ago. Since then I've noticed an intermittent clunking sound coming from the rear suspension. I installed springs on my MKV without any issues and again on several other cars, soIi'm familiar with the process. Everything was torqued to spec after the install.
My best description of the sound would be a clunk, not any rattling, clicking, or squealing. The sound is greater in the passenger side rear than the drivers side rear. No issues with anything up front. Sometimes it occurs when I'm turning the steering wheel while backing out of parking spots and driving slowly, other times when I hit bumps in the road, but it is not constant nor does it seem dependent on the size of the bump/pot holes in the road.
What may be causing this? My plan was to give it a week for everything to settle before I tore everything apart to look for any culprit.
View 1 Replies
I already changed the two front struts but the clunk its still there when i hit a bump or irregular surface, the dealer told me that I have replace the two front strut mounts too (I have a 2007 Camry SE V6 w 112 miles on it), that can solve my problems?
View 4 Replies
I have a 2002 Nissan Pathfinder 4x4 SE, and I have a strange noise emanating from the front suspension. It's essentially a creaking sound whenever going over speedbumps etc, that lasts only when crossing the bump in question. There is also a distinct ratcheting/popping sound when I more with the wheel at full lock. I've already replaced the front sway bar bushing, recently replaced the struts and springs, lower control arms, and have not noticed any shaking in the tie rods when I try to move them.
View 2 Replies
[URL] ....
Noise is coming from the front suspension. You can hear it at :11 after i come to a stop, then drive over a dip. The dealer has told me it is the front struts. It's the 2nd time I've taken it to the dealership, the first time they could not replicate the noise so i am surprised the technician was able to hear it this time, and I don't want to spend money on strut replacement if it isn't the cause.
View 14 Replies
My wife and I bought a 2014 Elantra with 30,000 miles on it. This is our first Hyundai and the car runs great, but the only issue I have is that whenever I go over a large bump in the road, the front suspension clunks and feels like it's coming apart. Smaller bumps or imperfections in the road are okay and the car runs smoothly over those, but the larger bumps and potholes produce an unreassuring clunk.
We've never owned a Hyundai before and we really like the car, but I was wondering if this is normal for the Elantra and if others experience this. I brought the car to the dealer and they checked everything out. They said all was fine and that it was normal. Is it?
View 4 Replies
I'm getting a clunk sound from my Passat's front left suspension when making turns. I've found info on how to diagnose control arms and I plan to jack the car up tomorrow and check it out. But how would I diagnose a tie rod end problem?
My Passat has 53,000 miles on it.
View 6 Replies
I have a 2007 Sonata Ltd (63000 miles) and had a clunk in the front suspension. I had the front upper control arms replaced (which were visually badly worn) and that fixed the problem. But now, a several months later another similar clunking noise has developed when I go over those small speed bumps in parking lots.
View 18 Replies
Alright cliff notes are lowered my 2012 GTI on Eibach Pro Kit springs and Koni Yellows (adjustable) as a DIY driveway job and at first were OK, but 2 weeks later are clunking to the point where it sounds like its going to fall on the ground. Any road imperfection makes it clunk (from the front only).
-Clunks all the time, slow, fast, turns, straight, large or small bumps. Doesn't clunk with dips...
-Gets better when its hot outside (>70 degrees),
View 24 Replies
I just installed Neuspeed Springs and my car is taking a "clunk" in the front spring, I went back and I replaced the strut bearing mount and the noise still continues.
View 8 Replies
I just finished my suspension refresh and I notice a noise coming from the front end. I really think that my end-links are the source of the noise. When I push the car up and down from the center, no noise. When I shake the car from right to left, I can ear a clunk coming from my end-links.
View 1 Replies
I have been hearing/feeling an occasional noise from my front end. Not a low-freq "thud" more like something sticky. Usually at very slow speeds, when turning the wheel, going over uneven pavement, or pulling away from stop. It sounds and feels to me like a steering rack issue, but maybe CV joints? 40k miles, 6-spd manual no mods.
View 3 Replies
Just installed a 4" lift sunday, with a BDS drop pitman arm and then i retorqued it to 185 ft/lb. I now have this extremely low speed (<2mph) or stopped clunking whenever i turn the wheel. I just replaced the upper and lower tie rod that goes from the pitman arm, and its still doing the same thing. Steering box is shot?
Clunk after lift install - YouTube .....
View 5 Replies
