Golf IV / Jetta IV :: VW 2003 GLX VR6 Stalls While Driving With EPC Light On
Aug 31, 2014
I have a VW 2003 VR6 jetta and lately I need to turn my key 2-3 times to start the car. Then while driving during daytime hours its stalls after 30 - 40mins. With EPC light on. I also have an engine light on.
Code P1151. I noticed a small exhaust noise coming from my middle pipe and my engine is very hot after driving for 30 -45 mins after it stalls. It does start back up after 10 minutes but stalls later.
View 12 Replies
Advertisement
The car starts well every time even though the revs go up then down for just two seconds before stabilizing at normal rev count. Sometimes while driving the car would just stall and loose power even though my foot will still be on the accelerator, if I pump the accelerator it will wake up and move on nicely like nothing ever happened. I've had this problem for the past two months now and it happens atleast 5 - 6 times a week randomly. the problems is beginning to get worse. The car has an automatic transmission. I've changed the fuel filter and air filter only in the last 20000kms. the MAF is ok because when i unplug it the car switches off and won't start again. every time i open the hood and rev the car a bit i can hear what sem to be huge suction of air somewhere next to the throttle body.
2011 Golf mk4, 1.8L...
View 1 Replies
2000 Jetta, 2.0 AEG engine with 220k miles, recently started intermittently stalling (about 15-20 minutes into my trip) while driving mostly on city streets but has also stalled on the freeway at 65mph. Fuel level is always > half full, verified against my tripometer. When it stalls, engine completely cuts off, all dashboard lights are all lit, and no power steering.
I have VCDS but know only enough to be dangerous My mechanic has no answers and I don't want to randomly throw new parts at this the car, hoping to resolve the problem. It's becoming seriously dangerous to drive, knowing it will die at least once on every trip. What's the chance the oxygen sensors need to be replaced ?
Symptoms
(1) Most of the time the engine just turns off, as if I turned off the ignition. Other times, I can catch the engine RPMs drop to ~300 and just hit the gas, which sometimes saves car from stalling.
(2) Immediately after it stalls, there is is rotten egg smell.
(3) Once stalled, the engine won't start back up again for at least 5 minutes. (turns over, but doesn't start)
(4) Confirmed error codes from VDCS: misfires on all cylinders and random
(5) Took it to my mechanic for diagnosis. They were unable to duplicate on a road test. Smoke test showed no vacuum leaks, road test monitoring data did not capture any additional faults, and found no faults running it heat soaked and parked. They captured sensor signal data and found no abnormal patterns. They feel replacing the O2 sensors is an expensive guess.
(6) Replaced the crankshaft position sensor after the car would not start at all, one morning. (discovered that the CPS tested at a faulty ~50k ohms). Bought a new one, installed it and it turned over immediately but the stall issue continues)
Fault Codes
Code:
18057 - Powertrain Data Bus
P1649 - 35-10 - Missing Message from ABS Controller - Intermittent
16684 - Random/Multiple Cylinder Misfire Detected
P0300 - 35-10 - - Intermittent
16685 - Cylinder 1
P0301 - 35-10 - Misfire Detected - Intermittent
16524 - Oxygen (Lambda) Sensor B1 S2
P0140 - 35-10 - No Activity - Intermittent
seen separately
Code:
16517 - Oxygen (Lambda) Sensor B1 S1
P0133 - 35-10 - Response too Slow - Intermittent
Note that I have been ignoring the ABS-related errors for 4+ years. (not a concern or priority). On the short list are ignition coil or crankshaft sensor. Both of which require my mechanic to replace, I think.
View 3 Replies
When you give it a decent amount of acceleration it starts to hesitate and kind of jump, the engine light flashes it kinda sounds like it want to stall. I'm not to good with the turbo motors. The car is a 2000 golf.
View 6 Replies
SO like the title suggests i had my EPC light come on while driving down the interstate. I was on cruise and had been for about an hour. then the motor seemed to stall and then pick up right away but wasnt at full power. i had the gas pedal to the floor and was losing speed. the cruise had come off as soon as the motor faulted. the light stayed on constant and i did not get any other lights or sounds to accompany it.
I pulled off at the next exit and stopped in a parking lot. I turned off the car and then turned the key to see if my check engine light was still operating. it was so i listened to the car as i turned the key on completely. I didn't hear any odd sounds and the EPC light was no longer on. I pressed the gas pedal and the motor responded with full power. Not sure what would cause this 2 occur but I am concerned that it may happen again and i may get stuck somewhere.
View 24 Replies
Why my 2004 Jetta 1.8T Stalls out while Driving? It usually happens while on the Freeway, 60-70 Mph, I Coast to the Shoulder then it starts back up again...
View 3 Replies
I'm really bad with cars but I'll try to be as specific as possible.
Car: 2002 VW Jetta
Basically the car will just stall out of nowhere while driving (not stopped at a light), I would say usually about 10-20 minutes after I started driving. After this, when I try to start it, it makes that noise like it is trying to start but the actual ignition doesn't happen. it usually takes me about 15 minutes to start it up again.
In addition to this, when driving, the RPM seems to randomly drop off often, and the car also jerks frequently, especially when I press on the pedal quickly.
View 5 Replies
Just as I was talking up my 03 jetta with 250,000 miles to a buddy, it developed a problem. It started to take a while to start, and wouldn't rev over 3000 while driving. (like all the other posts, would just die at 3k). So, I installed new Crank and Cam position sensors. Started up...a little stumble...running. Take it for a drive and able to rev over 3k rpm. Now it just spits, sputters, dies, stumbles.....push in clutch, engine dies....???? I know i will have to probably take it to VW for them to check it out....
View 6 Replies
I have a 2001 Golf 1.8T and while driving the oil pressure light turns on and the meter goes beyond the midpoint. I brought it in to a shop and they told me I need to change the oil pump and will cost $900. They told me it's because I don't frequently change oil and once the new oil is in, it caused the problem and only way to drive the car again is to replace the oil pump.
View 19 Replies
I was doing about 65 going up a 7% incline and all of a sudden no power from motor shifted down and kept trying tell 2nd gear and power hit and started accelerating again I know I have a p0420 has kicked on and off with the cluster but could that make this happen?! If not what can make my engine or other parts do this... 2.0 2003 Jetta....
View 4 Replies
I have a mk4 Jetta 1.8t. Problem started last night. After I drive for about 15-20 minutes the oil pressure warning light comes on. It doesn't feel any different and my oil is full. Could my pump be going bad? I hear a slight tick near the bottom of the engine on the passenger side. But the car idles fine and drives fine too.
View 17 Replies
I recently got a 2001 Mk4 GTI from carter Volkswagen in Seattle with 113k on it last friday (it did come with the car fax). I drove it back home to Wenatchee and it ran fine and is still running fine... I think. Today as i was coming home from school the check engine light came on when i was in 3rd gear and the car just wasn't driving as smooth as it was the first day (it felt as if i was driving over really really small bumps or like something was loose and was moving around a lot).
When I would get to a red light and be in first gear the light went off but it came back on as i would shift into 3rd and stayed on when i got into 5th. It recently had its oil changed at 112,000 miles. Also when the car is just idling the tachometer is going up and down a little bit, it is idling at about 600-700 rpms. I got this car because i didn't want to have a car with problems any more (I had an 88 Isuzu Trooper before).
View 14 Replies
I have an issue that I have yet to figure out. While the car is in motion there is a rumble from what sounds like the front driver side. I've replaced the wheel bearing and CV axle already. The noise seems to have gotten better but its still there. The noise will worsen when turning left and pretty much disappear when turning right.
View 2 Replies
Here is my new to me 03 Jetta 1.8T Wagon. This all started yesterday driving down the highway at about 65, I drove over a bump and there was what felt like a jerk. I lost the radio right away and when stepping on the accelerator it didn't seem to go over 3500rpm. I got a few miles into town taking it easy and it died as I pulled up to a stop sign. I was able to get a jump and get it running again.
This was the first jump of the day...When we popped the hood to jump it I noticed that the red wire coming off the positive battery terminal to the power block was frayed and corroded, so I cut the bad end off and stripped the wire to get a good connection. Left the car on a battery tender just to make sure the battery was charged and came back after a few hours and it started right up. Problem solved right?! Wrong...
Probably 10 miles down the road the same thing happens, a jerk or clunk sound, lost power and the call stalled out. Called family that was close by and tried to jump it again 'cause that worked the first time... Got a few miles down the road and it happened again!
Here's a picture of the gauge cluster and all the lights that lit up.
Long story short the car had basically no lights, power, for the windows/radio/turn signals/headlights etc... but was putting along at about 5 mph. I was out in the country and about 5 miles from home so I was just focused on getting it in my garage. It died again and a jump wouldn't even get it going the next time. I did some reading on my phone and it seems like the power block can be problematic, I took a picture of that because there is some obvious melted plastic on the large black wire.
I have a friend with a vag com, and he was able to come out and read the faults and then clear them and the car started right up just fine off a jump pack. We did get it home, but today I'm getting the same issues. I am trying to trace that black wire to its origin to see if there is corrosion or a loose connection there but I have no clue where else to start....
I start a new job on the 21st of July and this was meant to be my commuter as my truck gets terrible mileage...
View 2 Replies
My 04 GTI 1.8T got the infamous codes P0300, P0303 and P0301 yesterday morning. The check-engine light flash when I drive it. It is a little rough when the check-engine light flashes, but it is drivable and nothing major. When the car idle or when it come to a complete stop for 15 seconds or so, the check-engine light goes away and it comes back after 15 seconds or so after took off from stop.
I cleaned the MAF last night, but the check-engine light still acts the same way as yesterday on the way work this morning. The codes refer to miss-fire. This is my first VW.
Since I can easily get sparkplug from Checkers, I'll try it first. Checkers carries Autolite, ACDelco, NGK and Champions. Which brand do you prefer for VW engine? I hope that it is not the coil pack. It is expensive for $30 each at ECS Tuning.
View 9 Replies
So my alternator went bad last week so I replaced it. Tested it yesterday and it was charging fine and drove it to work. I got the esp light on after driving 10 miles everytime I start it. So I go start it and it turns over slow but starts. Before I got to a friends house I was getting on it from a stop pretty hard and noticed the ac stopped blowing cold air. I go to leave a few hours later and it barely turns over and died shortly after moving. Took a while to jump it and the battery light blinked the whole way home. THEN, I go inside and hear something about 5 minutes later and my stereo is on! Also ABS light is on. Could a dead battery do all this?
View 1 Replies
While driving on the highway I lowered my seat. Once it got to the lowest setting, I heard something sort of like a snap, and it threw an airbag light, so I raised the seat back up. I'm new to VW, but I know there's lots of possibilities for the light.
2000 Jetta GLS
View 2 Replies
I have a 99.5 vr6 Jetta that I just got running, I just put a new motor in it and got all cels to go out except one because a vac hose came off and I put it back but I haven't had time to reset it. Now that I have put in ~160 miles on the new motor I felt like doing some harder pulls and racing the lights and whatnot.
Well when the car is revved up really high, like when doing a flat out start, it stalls around ~5000 rpm. It'll drive all day and pull even when I don't rev it up that high but it stalls on the way down from 5000. It stalls in neutral and while driving. It does it hot and cold.
I have put a new MAF, new crank position sensor, new output shaft, new cam position sensor. Has a new stock air filter. And an oil pump and good bearings. Has good timing too and all new timing tensioners.
View 1 Replies
So up until a couple months ago my car was running fine. We drove to Vegas and everything was good, then on the way home from the car show, I put some cr@ppy 87 in and about an hour out of town I was going 80 on cruise and it bogged all the way out and came back when I hit like 60. Put some 91 in when I got to the next town and car stopped bogging out after every 5-10 miles.
I got home and read my codes. I've got a secondary air injection issue which has been going on for awhile. Also had a cam position sensor which I fixed.
Now I was driving my car the other day, I drove it til it was all the way warm and then when the clutch gets pushed in and around 1k rpms it stalls. I started it back up with my foot on the floor to get it back going. Right down the street I stop at a stop light and it stalls again and won't start. Had to push it to a gas station and leave it for a couple of hours to wait for it to cool way down to start back up. Was running like cr@p at first, but I made it home.
I had initially thought I needed a new fuel filter as well as a new fuel pump. Heard that it could also be a crank position sensor?
View 6 Replies
This has been happening for awhile now, but whenever the gas gets to 1/4 tank and below (about 2 ticks from the red tick on the gauge) the car will stall for about 3 seconds then come back to life. If it happens while I'm stopped it will completely die and I'll have to restart it.
View 5 Replies
I had just picked my car up from the shop after getting a new 3" downpipe installed (welded to stock cat) and attached to stock catback exhaust. I mention this because I never had this problem before and have already had installed a TIP, boost hose kit, DV, larger intercooler, and breather hose kit, all for a Unitronic Stage 2 tune.
So I go to turn on the A/C and the idle drops to about 400 rpm, almost stalls, interior shudders, vacuum jumps from about 20 to 10 as the engine revs itself a bit, and then it settles back out and the car runs fine (awesome with the new tune) and A/c works great. I have used the A/C a bit since getting all other upgrades done and never had a problem, or I didn't notice, but I'm wondering why a new downpipe would make a difference. I tried turning it on and off a few more times and the same things happened at idle, but after that initial dip and near-stall the engine was just fine around town and on the highway.
View 6 Replies
