Golf IV / Jetta IV :: Rattling When Going Slow With Load On The Gear
May 22, 2014
Ok so lately I noticed a horrific rattling coming from the rear of my car. It happens mostly when I'm in a high gear going slow with a load on the gear. It's sort of like the rattle that comes from the exhaust with the same gear load but it's much looser and rattley sounding, and it doesn't always do it. It almost sounds like a piece of sheet metal in my spare tire well rattling when there's a gear load and the exhaust rattles. But I checked in there and it seems tight.
View 5 Replies
Advertisement
I've recently been having a metallic creaking/rattle go on when idle or moving at slow speeds. I took it in during my 20k service and they said there was something with a cable and the heat shield... the service manager had also said something about the catlytic converter - but when I re-checked the service slip - nothing. This was originally in March.
The noise came back again recently so I had a different dealer check it out when I finally had the fuel tank recall done. They confirmed the noise and checked the heat shield (I had told them about the original complaint), but said there wasn't much that can be done - they made sure all the bolts were tight, but the noise was coming from the heat shield "flexing."
Most of the time it's fine and the noise went away for several months. It's subtle again, but if it becomes constant - it seems like I have a valid argument to have the heat shield replaced - seems defective.
View 3 Replies
So, in the last month or so I have been having trouble getting the car to go into second gear when mashing the go pedal. I have to try several times and seems to be that the car has to unload and then it will shift.
I am using the DG shifter and have been for 30k+ miles and I have the red HPA dogbone insert. The shift has not been a problem up until the last month or two.
Is it time for motor mounts?
View 8 Replies
2003 Jetta 1.8T (Manual Transmission)
It does this while driving. Seems like when the car is under load or lots of gas driving there is no sound, but when less gas pedal like coasting it makes this sound.
Car has leaking turbo seal. And bad catalytic converter.
View 2 Replies
Installed the wastegate actuator rod rattle clip on their R? I've been getting a buzzing sound under light load in first gear- very audible when it echos off a wall, etc.
[URL] ....
View 15 Replies
Under load, the car shimmies back and forth. Left to right. But only under load. It will even do it in 5th gear at 1500 rpm. The problem goes away when foot off the gas, or in neutral.
Already did a drivers side axle, passenger side axle, and dog bone mount.
I removed the intake to inspect the transmission mount and this is what I found below. Should it be able to wiggle this much? I imagine the mount is original to the car. Which has 156,000 on it currently.
View 6 Replies
I'm getting misfiring after the engine is hot, but it only shows up under certain load. For example, if I'm in 3rd gear at about 2500 rpm and I give it some amount of throttle, it wont misfire at all but if I give it just a hair more (maybe past 50% or so), it will start misfiring badly and the blinking CEL comes on. The codes it's triggering are misfire on cyl 1 and multiple misfire.
I replaced the coilpack about 6 months ago, that's why I'm hoping for some feedback before I drop a few hundred dollars on another one. I had the plugs out very recently and they look fine. The shape of the wires are difficult to get multimeter probes on so I haven't checked them.
View 16 Replies
I bought a cheap golf in february. It's an akl engine (1.6sr). Everything was fine on the way home. The car then wasn't used for like a month or two, and was stored outside. When we started using the car it gradually got more and more stuttering. At first it was just a slight stutter when accelerating, but now it's horrible. It will stutter and hesitate like crazy when accelerating or under load, but will cruise just fine at normal rpms. So far I have changed the air filter, fuel filter, spark plugs and a bad spark plug wire, but nothing has worked. I bought a vag scanner but couldn't find any codes. The idle isn't too bad but not perfect. What the problem can be?
View 10 Replies
Alright I drive a 05 1.8t with 68k original miles.. nder a full load my car bogs and hesitates. also my turbo will stop spooling and my boost gauge will go from 10 pounds to about 4 and i will have to let go of the gas and push down again for my turbo to spool.. What this could be I can't figure it out..
Here is my car.....
View 5 Replies
I bought a 03 GTI 1.8T. It was hit in the front so it needs a new bumper. The intercooler is smashed to bits. The car will start and idle but as soon as you go to drive into the shop it wants to stall and die out. Will not drive at all. Would the smashed intercooler cause this? No check engine light at all. Car is a 5 speed. All wheels turn free so nothing is keeping it from not rolling.
View 11 Replies
Having clutch issues? I have just put 10k miles on my JSW and the clutch feels like it slipping in 1st gear when heavier load(uphill ETC) is present its even worse. We have never drove it hard pretty much cream puff.
View 9 Replies
I recently purchased a 2003 jetta 1.8t 5 speed manual and it wasn't making this noise when I first bought it.. It's almost like a growling/grinding noise. It's sounds like it's coming from my middle console but it could be coming from the engine bay hard to tell, but the only time this noise happens is at 1900 rpms when the car is under load like if I'm going a hill it's pretty loud when I'm going slow, the previous owner had the water pump, timing belt, and clutch done 10k miles ago. I have a feeling it's from the clutch/transmission or maybe from the timing belt?
View 2 Replies
Info: O2J 1.8t, Peloquin LSD, clutchnet 6 puck, VF mounts
Getting a vibration on driver's side during either accel or load up a hill after driving for 20 miles. It's related to distance driven versus engine warm or cold. I can feel it in the pedals, definitely driver's side.
Things checked:
-axles, replaced driver's side, no change
-transmission is full of fluid, looks good
-motor mount bolts tight
-called Peloquins, they said the diff would cause issues while turning and would occur anytime under load, not just when cold
Wheel bearings have about 15k on them and were INA's, and those shouldn't vibrate only on accel or load. I thought about the dogbone, the poly bushings in it are about 35k miles, but makes no sense why it would appear after driving 20 miles.
View 6 Replies
I can't figure if it's a TB issue as I've just had it replaced or a mount problem. I only get the knock on biting point idle and pull away under load. This noise is driving me insane.
View 2 Replies
I have a 03 golf 2.0 with 82k on it. I am having a really weird issue with car pulling left under load and then going back to the right when letting off the gas. It's more noticeable at higher speeds....over 40mph or so. I did a quick check under the car at ball joints, cv joints and can't really see anything that would make this issue. Would a trans mount or motor mount cause this? Is there something I am missing?
View 2 Replies
So I am getting a crinkle/pop noise going slow in 1st gear. I don't know if its the clutch or the gear itself. drives fine but the noise is pissing me off. its like a mixture of crinkles and pops .
View 11 Replies
Ever since day 1, I noticed my wife's 2011 TDI/DSG make clattering/rattling noise during low gear changes (1st to 2nd and 2nd to 3rd gear), it sounded like a diesel engine's clattering/clicking but a little louder at gear changes. I mentioned it to the dealer at 3month/3k checkup and they test drove and say it's normal. Is it really normal?
View 6 Replies
I own a MK4 Golf GTI which has recently started making a rattling noise when I first start the car (Perhaps cold weather?). It will continue for roughly a minute despite load (A/C, acceleration) before It stops and It won't happen again until the car has cooled down hours later. It's quite an unsettling noise and I would like to be set in the right direction.
After a couple hours online I'm leaning towards perhaps the belt tensioner being to blame? I haven't delved too deep into the noise but do believe it is from the left side of the motor. Can likely clarify on the weekend.
Is there anything to worry about? If so, where do I start? I myself was trying to fiddle around and see if the noise would happen at higher revs, which it seems to. [URL] .....
View 19 Replies
Just today i was driving along in my 2.0L golf when I started hearing a rattling coming from under the front end, its a hollow sound that only really is loud when i step off the gas after accelerating, and a faint little rattle when I am idled. I wasn't too bad at first but now its to the pint where i get no exhaust sound coming out of my muffler, currently I have a 2.25" Magnaflow cat-back exhaust system, so I am pretty certain it has to do with probably the resonator or the catalytic converter. Where I can start?
View 2 Replies
I would really want to know what is causing this sound as it has become louder.
The noise can be heard in this short video: [URL] .....
The noise is coming from the area of the pulleys, and can be perfectly heard behind the passenger side front wheel.
The car is an AWD 1.8T Golf 2002 model.
View 4 Replies
First, when I downshift to 2nd gear for instance, I don't feel like the car slows down any and I'm still needing to hit the brakes to slow down. In previous cars, going to 2nd would seem to make revs go up and slow the car down. Wondering if this is common on the Golf R to almost feel nothing when downshifting?
Second, my gauge cluster lights up when I'm driving outside w/o the lights on. When I go into a parking deck the gauge cluster starts out lit and then goes completely black except for the blue needles. Wondering if this is normal or if I have a cluster issue?
Car has 17,000 miles on it and completely stock minus the soundaktor removed.
View 5 Replies
