Golf IV / Jetta IV :: Overheating When Accelerate Hard Or Go Over 50 Mph
Feb 13, 2016
I have a 2.0. Custom gt28 turbo project. Been up and running for awhile now. Took it on a 4 hr trip home and drove it back.
All of a sudden after the holidays it started to overheat and I had no heat. It will not overheat when idling. I replaced the thermostat recently. Lower hose gets warm when it opens. I replaced the green top sensor. I have done a wire tuck etc and I am running a closed coolant system. I believe I have gotten the air out of the system.
It will idle all day at 190. But as soon as I drive and accelerate hard or go over 50 mph it overheats and will not cool off unless I pull over and turn the car off. It will steam as if it's losing coolant somewhere but I think it's at the cap (too much pressure?).
I am thinking water pump but I am not sure. I got the car with 124k miles I'm at 127000. I was told timing was done at 90 could the pump be failing already? Also when it overheats I get a cel for misfire is that normal?
View 4 Replies
Advertisement
My Jetta wagon with 131K on it has a ping when I accelerate hard. I know it's not bad gas, but probably a carbon buildup. I've done a few seafoams that had some effect, but not much. I'm gonna do the water spray/steam next. Which components are prone to carbon buildup in these gassers that would cause ping?
View 4 Replies
I have a 99 Mazda Protege LX. That is only overheating when I accelerate too hard. Like getting on the the highway. I have replaced the radiator and the thermostat and also got the system flushed, but it is still overheating!
View 3 Replies
I have a 2003 vr6 with about 60,000 miles on it and it overheats. I can drive between 35-40 mph and make short trips no problem but when going any faster or accelerate faster than an old lady in a buick, the temp gauge slowly rises(or fast if i accelerate fast.) Until the "stop, check coolant" warning comes on(which i don't let get to that point.) it blows heat all the time, all the hoses get hot, I am no professional by any means but i have dealt with many different overheating issues with other vehicles but I am kind of stumped at what to try first so i don't end up replacing something that doesn't need to be because i do not have the extra $ to do so. The problem started when someone put dirt in my coolant, I flushed out the system twice, the second was just to see if anything else had loosened up that I may have missed the first time..
View 2 Replies
So after owning my R for just over a week I've noticed that when I accelerate hard or let off the throttle the shifter seems to move quite a bit. Is this normal with the stock mounts or is it something I should have looked at? I know the stock mounts are rubber to aid in isolating the vibration of the engine but it seems like the shifter moves a little more than I would expect.
View 1 Replies
2007 Rabbit shakes quite hard when i accelerate mainly on any type of incline and only between 35-60 mph. When i take it to the shop they cant find a problem.
View 3 Replies
Every time i make a turn or accelerate decently hard, i hear a pop, which generally sounds like a tree branch snapping...this isn't a quiet noise either, also i can feel it in the steering wheel sometimes as well.
View 12 Replies
I bought a used 2010 GTI with 37k on it. I am loving the ride, more than I even anticipated. It has the DSG, and I enjoy the multitude of ways I can choose to drive this vehicle.
I do have one issue of concern that I would like some feed back on. Occasionally, when driving hard, the car makes a horrible shudder and doesn't accelerate. It's almost as if the vehicle misses a shift and is governing itself quickly and harshly. I haven't had enough concentration to check RPM's when it does it.
It feels horrible, scares me and makes me wonder what I'm doing, what I need to get checked, or if this is something others have experienced.
Pic for good measure.
View 24 Replies
My 2002 Jetta VR6 is overheating. The car only overheats when the car is not mobile. If I get stuck in straffic or just let it idle it will over heat. What could it be?
View 3 Replies
Ok I have an automatic 02 gti..the other night as I was driving home it started to overheat And fast..I had to stop about four times to get home so it can cool down a bit..the next morning I went to check for leaks but I didn't have any and my coolant level was good..I turned the car on and let it heat up and I noticed the fan didn't kick on..is the fan not turning on a good sign that it is bad? I ordered a timing belt kit from ecs which came with a new water pump and thermostat but I didn't get to switch everything out in time and now im stuck with a overheated engine..the only thing I did change was the coolant temp. Sensor because it was the easiest thing to change.
View 2 Replies
As the title says, car is overheating. Car gets to 190F within a couple miles drive. Temperature fluctuates between 190F and 225F.
Water pump was replaced ~2 months ago. Was not overheating prior. Temp reached 190F and stayed. Currently has the "black top" coolant temp sensor.
I noticed the coolant fans are not running after I turn the ignition off. This time of year they would usually be running after turning the engine off. If car is overheated and with AC off the fans do not run while engine is running.
I used the guide below to try diagnosing the cause: [URL] ....
Remember both fans should come on in slow speed any time the key is on and the AC is on - if the temperature is above about 32 F (0 C). Both fans run with key on and AC on
S180 (fuse 8, 30 amps, green plastic, above battery) must be good for slow speed operation.
Fuse and holder look good: no melting, no discoloration.
S164 (fuse 3, 40 amps, metal strip, above battery) must be good for fast speed operation.
fuse looks good: unbroken.
To ensure the AC circuits and the Fan Control Module has power check:
Fuse 5 on the cabin fuse panel.
Fuse 16 on the cabin fuse panel. When this fuse is blown the radiator fans will often run unexpectedly.
Fuse 25 on the cabin fuse panel.
All three fuses look good: unbroken
For the first test of the slow speed fans from the radiator thermoswitch have the key off.....Both fans should run in slow speed.
Passed test: both fans run slow
The second test is for the fast speed fans, key on, AC off.... Both fans should run in fast speed.
Passed test: both fans run fast
If the fans run in the tests above, then you should be good to go. No further tests are needed.
If you have been seeing high coolant temperatures and the fans have not been running, then you may need a new thermoswitch.
View 4 Replies
So my 2002 Jetta 1.8t is overheating. The water pump was bad. Replaced. The thermostat. Replaced. Radiator. Replaced. Radiator cap. Replaced. We're running out of things to replace! I'm ready to go to a junk yard and get a new block! We've tried about 100 magical "ways to burp it" with no luck. We even tried running it without a thermostat. Without the heater core. EVERYTHING.
The car runs at operating temperature at 4 RPM. But when we take it for a drive, it overheats. There's no heat with the thermostat in unless you rev it at the high RPMs. As for the hoses, top is hot, bottom gets hot. As for the car, it runs beautifully. It gives no codes. No smoke either. Nothing in the oil, nothing in the coolant so I don't think it's the head. It just overheats. This has been FAR too long.
View 17 Replies
My 2002 VW Jetta GLS 1.8T 5-Speed is over heating
Car is still over heating after replacing the following:
- Head gasket
- Coolant fan module
- Geba Metal Prop Water pump
- Full timing belt kit
- coolant fan switch in Radiator
- Bleed the system of all air blow hot air
So Driving the car around town is ok, doesn't over heat, but as soon as I take it on a highway it over heats. I drove it 50 kms out of the city and it over heated, let it cool down and added water. got it back home. Oil light flashed on as I pulled into driveway, turned it off right away. no external oil leaks. Checked coolant, Oil in coolant. also the coolant was boiling, the level was raising up and lowering. I have been reading the forums for a few hours and the oil in the coolant sounds like the oil cooler gasket. Ok so the fans are running and it still over heats. The old metal propeller water pump was very hard to turn so I replaced it with a Geba Metal water pump. no leaks at water pump. Could it be possible that the Oil cooler was causing air to leak into the cooling system causing the coolant to boil? And then when the oil cooler "o-ring" finally failed it dumped oil into the coolant?
View 5 Replies
1.8 jetta... Seems to do this when at idle only on occasions it goes above 190F. Waterpump was changed about 5k ago so I'm sure its not that. Thermostat still needs to be changed. It seems like if I turn the heat on it stays at 190F.
View 2 Replies
Mk4 Jetta Gli 1.8t , car was over heating only when sitting 5+ minutes at idle, mechanic said the big fan needed replaced so he replaced it. Car still over heated so i replaced the coolant with G13. It hasn't over heated yet but got in the car this morning and the coolant light started flashing and car was telling me to STOP the car. Checked out the coolant and it was on the low side. What it may be? Leak somewhere? Bad thermostat or water pump gone bad? Timing belt and water pump were done when i bought the car when it had less than 50k miles, car now has 99k miles on it.
View 7 Replies
Engine will overheat unless I turn the AC on. The engine fan only operates with the ac on it seems.
Will not overheat unless in traffic for a while.
Would it be radiator thermo switch or the Fan Control Module?
View 1 Replies
I have a 04 jetta 1.8t that just randomly started having some overheating issues. I just got the car two days ago, and the first day I had it I replaces the coolant temp sensor due to a check engine light. Drove 50 miles and the light shut off. Just yesterday I was sitting in traffic and noticed the temp going above 190 (which it hadn't done in the 200 miles id driven it so far). I brought it home and once I was out of traffic and moving along the temp went right back down to 190. The only time it tries to overheat is when its sitting still or at idle (after reaching operating temp). which is weird.
I was parked in my driveway and let it sit at idle for a few minutes until the temp started significantly rising. i revved it to 2000 rpm (thinking it would rise even more), but to my surprise it instantly went down to 190 again. my big fan isnt running either, but my friend said he doesn't run fans in his and that it shouldn't overheat because of the fan. also, my top hose is warm to the touch, but the bottom isn't. I know your thinking thermostat, but if that was the problem it would :
1: always overheat, or
2: never overheat.
The temp wouldn't fluctuate the way it is.
View 5 Replies
I have been having an overheating issue with my 2001 1.8 turbo Golf GTI MK4. What I have replaced and checked:
-Supposed new water pump (dealer said they changed it when they did timing belt) (to be even more clear i pulled the top line off the coolant reservoir and there was a constant flow of coolant from the line meaning the pump is indeed working.)
-Thermostat (I personally changed it, 190* thermostat, aftermarket brand)
-Green top coolant temperature sensor (I personally changed it, its the one on the flange at the head, from the dealer)
-Cooling fan Thermo switch (I personally changed it, its the one located on the driver side on the radiator itself from the dealer)
-Checked fan motor speeds and operation. (I tested the cooling fan thermo switch and both fans came on at low speed, as well as both fans came on at high speed, which according to this test states the thermo switch is bad, but i already replaced it.)
I used the operation : [URL] .....
What my car does:
-Car starts to warm up and reaches 190* and fans start to cycle
-Both top and lower radiator fans become hot
-Car starts to get hot (indicator starts to go to the first line after the 190 line)
-Fans stop coming on
At this point i do one of two things to resolve the issue:
-start to drive (thus getting air through the radiator, and it cools the coolant and the engine.)
-turn off the car
What the problem is:
The fans wont turn on, on their own past a certain temperature, but sometimes when i turn the car off the fans will then kick on. (At idle, with the car on, they wont turn on again past, what seems, a certain temperature.)
View 14 Replies
So my friend, ignoring my advice that this generation seems to be riddled with electrical problems, decided to purchase a seemingly nice 99 Jetta, with a junkyard AEG swapped in(AEG is written on the intake and block like a JY would do). Sun roof doesn't slide back, gets jammed, evidence shows water has built up previously and run down the A-Pillar to the fuse box.
I just got the fans unplugged and verified that the fans with power applied, both have their low/high speeds. The fuses on top of the battery are in-tact, no visible melting, looks like the thing is in ok shape(haven't taken them off to inspect the contacts yet).
View 9 Replies
I have a 2004 Jetta 1.8t. 160k miles. Bought it recently. It's been overheating on me. Mainly on the freeway while having the RPMs higher than the small streets. I don't see any leaks. I'm not losing any coolant. But I do smell burning coolant. I don't see anything smoking though. I changed out the coolant temp sensor. I have a thermostat but haven't gotten to it yet. Just wanted other opinions before moving on. There is some sort of little motor on the radiator with some coolant hose connected to it. When turning off the car, it stays on and buzzes for a good 10-15 minutes before stopping. I'm not sure if that has anything to do with it. I don't even know what that thing is or called.
View 14 Replies
I recently bought a 2003 VW jetta 1.8T with 150,000 miles on it. After the purchase I got about 20 miles down the road and it overheated. I noticed there was oil in the expansion tank. I replaced the head and head gasket on the vehicle. As i was taking everything off I noticed that there was green coolant in the car. WhenI took the head off the pistons were glazed over and a lot of things were charred.
So I cleaned everything and put the new head and gasket on. After everything i cleaned the expansion tank of the oil and put new coolant in. After I drove it around for a little bit and everything seemed fine and there was no oil mixing with coolant. So I left got another 20 miles down the road and it started steaming and the overheated light came on. I checked the engine and there was no oil in the expansion take but the coolant was just pulsing it wasn't a constant flow.
View 4 Replies
