Golf IV / Jetta IV :: Overheating - Coolant Spraying Everywhere Causing White Smoke Under The Hood
Apr 28, 2016
I have a 2002 VW MK4 1.8t. It has 172,000 miles on it. Since i bought the car i have had to add coolant from time to time due to leaks from various plastic coolant parts so I replaced the crappy plastic connectors and flanges as they failed but it has never overheated till a couple days ago. It rose up to about 210'F but I didn't let it get to 260'F (aka the red zone).
While the temperature was up, the coolant was spraying everywhere causing white smoke under the hood. I stopped and looked under the hood and came up with the conclusion it was the coolant flange that holds the temp sensor since it was leaking coolant from the flange like a faucet hince the reason it caused it to overheat due to lost of pressure and no coolant in the system. So I replaced the part and gaskets then checked for other obvious leaks.
No leaks are shown nowhere else in the vehicle. So I added coolant to the car and let the cooling system do its magic as i left the heater on high. Let car idle with cap off and heater on for about 45 minutes. No signs of overheating. So I take the car for a spin and that's when the car starts heating up. I look under the hood and feel hoses and notice all are pressurized but top hose that leads to coolant flange is hot and the bottom hose connected to thermostat is cold.
I checked the return hose that leads up to the coolant reservoir to see if it's cycling and it appears it was. At low rpms the return hose had a steady flow and at high rpms it was flowing much rapidly. Which made me think it wasn't the water pump also this car with that many miles wouldn't have lasted with the plastic impellar this long if it wasn't already swapped out by previous owners. My question is what would cause it to still overheat? I forgot to note the fans did not turn on when the temperature was rising unless i turned the a/c on. But i still did a drive test with a/c on and it still overheated. I also did multiple burp cycles. I have invested alot of money in custom work and suck to leave it parked on the drive way.
View 2 Replies
Advertisement
I have a 2007 Honda Odyssey touring model. Recently I had it serviced at the Honda dealership. In addition to my requested front end alignment and oil and filter change, they talked me into a radiator flush, fuel inj. service, air filter replacements and battery service. I drove the car home after wards even filling up with gas before going home. This drive was about 55 miles. I never noticed any problems. The next day, I left for Montghomery AL towing a trailer with a motorcycle trike on it. We stopped for lunch and continued. The car suddenly started making a grinding noise from engine compartment and suddenly white smoke started coming out from the hood. I immediately pulled over and we got out of the car for fear of fire. This was the first time I had any indication of a problem.
After a short time, I opened the hood to see what was wrong and noticed that the radiator cap was sitting upside down next to opening. I had the vehicle towed to Chattanooga where I was told there was serious damage to the engine. I had them repair it (they were an AAA approved towing and repair shop). I also took pictures of the engine compartment. I went back to the dealership and asked to be reembursed for my expenses and the cost of repairs and the owner refused. He said he didn't believe they left the cap off and since he started out in the service department he didn't believe the car could even go that far without overheating. My question is: Is it possible for a 2007 Honda Odyssey to travel approximately 220 miles over two days before overheating and wrecking the engine if the radiator cap was left off and/or if no fluid was even added and the radiator cap was left off?
View 19 Replies
I have a 2006 v6 ford mustang and just developed this problem yesterday.
When I drive the car, the temp guage stay right in the middle, but when I park I get white smoke come from under the hood. I popped the hood and saw coolant leaking from where the top radiator hose meets the engine block. This was producing the smoke. When I checked the hoses, the top hose was hot and hard, the bottom hose was cool and soft.
Extra info:1. I did not touch the radiator to see if there were cool or warm spots2. The overflow bottle looked empty or close to it, but the engine was still hot from driving to work
Thinking this could be one of the following:
1. bad thermostat
2. clogged radiator
3. Air bubble somewhere blocking the coolant flow
View 5 Replies
I have white smoke pouring out of my exhaust in my 2001 Jetta1.8t , it happens at idle and then a lot at acceleration. The smoke is white and everyone and a while it has a hint of blue. I don't know what is wrong but what do yall think could be happeneing?
View 4 Replies
Its a 2001 jetta vr6, 5 speed, electronic seats all leather with wood trim panels, and I am having quite the issue. When you turn on the car it has a rough idle around 600rpm but doesn't die out. it smokes like a banshee, white smoke. if you come back later and start it, no smoke until you give it gas. some times it doesn't smoke at all. misfire cyl 6 and 5, used to have 4 misfires but spark plugs did me justice, maf sensor low voltage output, bank 1 sensor 2 02 something or another, when i first got it, it would just chug and not smoke at all. the better its running, the more smokes it produces it seems. none of my coils have the rubber graumet around them anymore and all seem to be pretty shot regardless. I have no leaks underneath the car, coolant has no oil mixture in it all all, no visible leaks on the headgasket, and most of the time the smoke smells like gas, but its purely white. I am just wondering what could cause it, im trying to feel out more options before getting drunk and doing a headgasket. no oil loss, no coolant loss.
[URL] .....
video of the smoke.
View 1 Replies
I was driving my 2004 Jetta Tdi manual the other day and everything was fine. I stopped at a stop sign and began to go when suddenly i lost power like I was out of fuel only that was not the case. I looked behind me and saw lots of white smoke puffing behind me. I pulled over immediately and checked the oil (a little low), air filter (still pretty and white), coolant (clean and clear). I added a little oil and drove home very slowly and kept the RPMs as low as possible. There was no engine noise that I could tell.
View 4 Replies
I have an 02 jetta 1.8t just recently put oil in it and it's now pouring white smoke at idle and right around when I'm in 3rd. When parked and running it's puking oil and I have oil sprayed all in the engine bay. I have it sitting now and there's still a drip.
View 2 Replies
Having issue with a 2003 jetta 1.8t. I bought it used and it seemed to run great. Sometimes going up hills i get white smoke for like a minute (probably in too low of a gear when it happened).
Happens on the highway sometimes too if i punch it to pass somebody (like already going 60, punch it to 80). I've read other posts here to get some ideas (turbo going bad, etc.) It seems to coincide with a lack of power or stumbling in the gear I'm in...
View 1 Replies
i was a few mins early for work so I was just sitting in my car with the engine off...out of nowhere I heard a noise from under the hood...it sounded like a loud spraying noise with a lot of pressure. I opened the hood and finally found the problem. A hose popped off and yellow fluid was spraying out along with a lot of air. I clamped the hose back on to where it belongs and it was secured right away. There is, however a crack in the hose.
I know it's not coolant because the coolant is pink. I saw a thread that suggests it could be power steering fluid, but I haven't noticed any problems with my steering. I also saw a threat that suggests an AC leak.... What this is?
View 6 Replies
Last weekend, I was riding my Golf 2.0L when it started losing power, then a thick blueish white smoke started coming out from the engine all the way through the exhaust. Stopped the car on the side of the road and had it towed back home. I've looked for loss of any oil or coolant but the levels are ok. No mixed fluids from sight. I've had a check engine light for oxygen sensor for a year or so, but I've been told that would not be the problem. I started the car a few hours after it was towed home, it was now cool so the smoke wasn't as thick. The smoke doesn't smell like coolant fluid. I took out a spark plug and there was a bit of oil onto it too. My engine runs normally. People have been telling me to look for head gasket, valve cover gasket, engine head, etc. A week later, I still can't find what it could be.
View 1 Replies
When flooring with 1st or 2nd gear engine suddenly lose power, smoke like hell (white smoke) and engine start to shake badly? It disappears after few minutes when engine turned off. When cold it will go in "that" stage almost on every flooring. When warm it possible will start to shake a little and disappear after a minute without turning off engine.
After CCV breather valve(was broken) , turbo and nozzle replacement this problem still exist.
What could cause that problem?
*Golf mk4 AHF 81kw with new turbo, new bigger nozzles and chip.
View 9 Replies
Let's start from the beginning. 3 months ago, I replaced my oil pan, and since then I've noticed that white smoke would randomly blow out of my exhaust- A couple times when I really got on her, and a few times when sitting idling for 10-15 minutes.
Two days ago, I was driving and about to hop on the highway to make my 40 minute commute home, realized that my temp had gone up about an eighth over 190 (usually stone cold centered)... Watched it for another 2 minutes and the temp was 3/4 of the way to the red, so I pulled over and popped the hood.
The coolant reservoir was COMPLETELY empty, which didn't really make any sense- I had been running my AC all day because it was hot out, but I don't think I was idling with the AC on for too long.
I let her cool off, had a friend bring me some coolant (not much at all) and a TON of water. Filled her up and went home; temp was trying to climb but I wouldn't accelerate too much so she wouldn't go much higher than that eighth over the 190 mark.
Next morning, dropped her off at a mechanic's before work, asked for an oil change, inspection, and to check out this temp issue. These guys told me that they ran a compression test and everything was okay, no leaks or cracks in any hoses so it is a faulty turbo. They also stated that in idle, there seems to be intermittent white smoke out of the exhaust- coolant burning, obviously).
Drove it from them to a spot nearby to let her cool off because I wanted to see if there was more white smoke.. Driving TO the location, I blew A LOT of white smoke on acceleration, I had the heat blasting the entire time so the temp didn't really rise too much.
I'm hoping it's not the turbo, reading up on these issues in here it could be a number of things, but the ONLY reason why I don't want to spend a fortune on replacing the turbo right now is because one or two mechanics i spoke to today said it's not the turbo, but 3 others said it was...
I have no loss of power, no hesitation, and no abnormal sounds from the turbo. Actually, she sounds amazing. I don't however thing it's a head gasket because the dipstick and oil cap aren't milky.
View 24 Replies
Mk4 Jetta Gli 1.8t , car was over heating only when sitting 5+ minutes at idle, mechanic said the big fan needed replaced so he replaced it. Car still over heated so i replaced the coolant with G13. It hasn't over heated yet but got in the car this morning and the coolant light started flashing and car was telling me to STOP the car. Checked out the coolant and it was on the low side. What it may be? Leak somewhere? Bad thermostat or water pump gone bad? Timing belt and water pump were done when i bought the car when it had less than 50k miles, car now has 99k miles on it.
View 7 Replies
My 04' GTI, 24v VR6, all stock, @ 107,000. I had a coolant leak from the t-stat housing. I installed all new housing, seals, and C-Pipe from GruvenParts. Already had a green CT sensor installed and the kit I got didn't come with one, so I didn't change it. Found out the leak was from the t-stat housing o-ring didn't fit the old housing. The new one fits perfect. I put coolant on the seals and burped it. Doesn't leak a drop. But still overheating, all the hoses have pressure and are hot, so no blockage....I noticed the fans were not coming on at all. The fans used to engage every other minute and run for 15 secs on high ONLY. Longer times, if not constantly w/ A/C on. I was wondering how to test the fans, sender, and/or fan control module to see which one of them isn't working. And which pinouts are what?
View 2 Replies
I've got this weird problem , it started a month ago. Sometimes I would drive for half a hour, park the car, stop then engine and some white smoke comes out of the hood after a few seconds. But sometimes I can drive the same amount of time, park, stop the engine but no white smoke.
The only time I did notice it happening is when my temperature gauge isn't working properly , sometimes it will give the right reading (which is right on the middle) and while driving it will drop to 0. Also sometimes there is a smell of rubber burning I think (Doing my best here). But I've checked Google for people with my problem but all I read is either people with tail pipes issues or smoke directly in the drivers cabin. My white smoke is only when I kill the engine. There is no smoke coming out of the tail pipe nor in my cabin. Only a rubber burn kind of smell.
View 4 Replies
My wife just sent me a text saying she noticed her car (2005 Elantra GT, auto, 140k) making a chugging sound and then saw white smoke coming from under the hood on her way to class.
I'm at work, so I'm trying to pinpoint the problem from my office, but I'm guessing the white smoke is the result of a coolant leak? Bad seal somewhere? What would cause the chugging that's related to a coolant leak? Or maybe it's not coolant-related at all.
View 11 Replies
Yesterday I made a 3 hour round trip with my car, and on the last leg coming back into town, I noticed my check engine light came on, and I saw white smoke coming from underneath the hood of my car, along with a burning smell. Luckily I was able to make it home just fine. I've googled this issue, some people have suggested coolant leak.
Also, I checked the oil levels today and they appeared to be slightly below the lowest level tick, which could be why it was having issues yesterday. Last time I got an oil change was November of 2015. I'm surprised it's this low considering I normally don't commute farther than a couple miles each day.
View 4 Replies
Last night while i was driving my car began to overheat. I could smell coolant burning. I pulled over and opened my hood. The coolant inside the coolant pod was boiling. Some coolant lines were steaming as well. I could also hear a gurgly like noise coming the engine. This is a 1.8t gti
View 3 Replies
After finally getting some issues sorted this weekend (needed a transmission flush) I was driving around a bit to make sure everything was good. On the way back to my house, the car started overheating. I replaced the thermostat this winter (~4-5 months ago) because it was stuck open making things run a little cool.
I was thinking the water pump is probably shot but not 100% sure. the radiator fans both work and when I turn on the heater, it blows hot. Any good way to check if the water pump is dead? I have a little point and shoot infrared thermometer and one side of the coolant line was way hot and the other was fine (cold ~90 deg F).
View 11 Replies
I am having a overheating issue with my 1.8t AWP gti, it goes as fallows, start the car, engine warms up go for a drive (short 5-8 mi), park the car and temp gauge starts to rise, (turns off car)... I began to check some things with the system, I checked both rad hoses bottom is hot top is a bit hotter and fans work when ac is on; here is where it gets interesting i took off the coolant return hose on the reservoir (cold start) and nothing was flowing ...water pump?... So i turned the heat on and air full blast and all of a sudden coolant starts to flow.
It also seems like air is being spat out as well. Soon after the flow beginning my coolant in the reservoir starts to fluctuate (rising and dropping) with air bubbles and beginnings to over flow so i shut the car off. Now I know what the possible issues are its either the water pump, air in the system or bad autozone thermostat. Here is some history of the car TB was replaced at 70,000 by Previous owner, i bought the car had the belt inspected and was told it was good, about 2 months ago i had a coolant leak and had it misdiagnosed as a thermostat housing leak; it turns out it was a coolant bypass hose that was leaking so i ended up fixing it. I lost a lot of coolant but topped it off with g12+. My mechanic doesn't think its the water pump and recommended changing the thermostat for an VW one another mechanic recommended to bleed air of the system.
View 7 Replies
I drive a 2004 Hyundai sonata. Last time i had an oil change they told me there is a small oil leak. I have yet to fix the leak due to lack of funds. I drove to work today and a co worker noticed after i got out of the vehicle that there was white smoke coming from the hood. I have checked my oil and my coolant and both seem to be fine. I have not checked the resivour yet( should i? ) My question is do you think the oil leak is what is causing the white smoke along with a slight burning smell? Or possibly another issue? I am having it check this weekend however until then i wondered what i could do to avoid overheating if you think that may be the cause of the smoke as well?
View 3 Replies
