Golf IV / Jetta IV :: Front End Clunk Almost Every Time When Suspension Flexes
Oct 13, 2014
So I've always had a clunk coming from the front end of my car since I bought it last year. It happens almost every time the suspension flexes. I'm pretty sure my steering is okay as I can turn the wheel quickly and/or forcefully back and forth with the car either on or off and there is no noise; the steering feels solid.
Here is the list of things I have done so far:
-Poly sway bar bushings
-Poly end link bushings
-Poly dog bone bushings
-Cup kit (Springs and shocks)Upper strut mounts & bearings
-Ball joints
-Raxles
After a quick look at my Bentley manual, it seems the only things left to do are control arm bushings (most likely in my mind) and sub frame bushings (less likely). Is there anything else I should check for possible causes that I'm missing?
View 2 Replies
Advertisement
I've got a "clunk" in my front passenger side suspension. I'm running stock struts with H&R sport springs that I put in about 10,000-15,000kms ago. The clunk is inconsistent and seems to only happen in the parking lot when I'm backing out of a stall. When I pull forward, I get a couple clunks coming from that side? Could this be tie-rod?
View 17 Replies
I have a 24v gti, but this deals with the front suspension. I replaced my stock suspension with a set of coils and also my drivers side axle with a raxle. Even have new strut mounts, bearings and R32 rear control arm bushings.
When I drive slowly like coming out of the drive way I can hear a continuous clunk happening 1/2 second to 1 sec apart coming from the front suspension, but after I drive a min or 2 it goes away??
View 2 Replies
I was driving my car and forgot to turn esp off, hit boost in 2nd gear and the traction control did it's thing. didn't notice anything while driving so I didn't think anything of it. once I got home to back into my driveway, I noticed that when I turn the wheel sharply (at a standstill or very low speed) there's a clunking coming from what seems like the passenger front. I'm hoping it's not the inner cv. What it could be? I know for a fact it started right after the traction control kicked on so that's what caused it.
View 8 Replies
I am trying to find origin of clunking noise, but it is difficult to do as there is no visual signs and no excessive movements in any components.
Little bit of details and video. Noise occurs when moving rapidly steering wheel on stationary car with running engine. Not noticeable when at speed. Wheel is not vibrating and cv joints not clicking. Very tiny free movement in steering wheel about 1mm, but I am not sure if that is related maybe a completely different issue there. Mot tester make an advisory note that steering system slightly rough, but its not that useful to find an issue.
[URL] ....
View 8 Replies
I have a 2003 Jetta Wagon with 49000 miles on it. I noticed that when turning at slow speeds (like taking turns in a parking lot) I hear a klunk coming from the area of the left front wheel, and I think I feel it through the steering wheel. Yesterday I was going around a hairpin turn at a shopping mall and heard two clunks. Driving straight it doesn't happen.
View 8 Replies
A clunk sound coming from the front end. Drivers side and Passenger side. Not really a metal on metal sound. The problem started after coilover install. The sound occurs while braking and accelerating over bumps. So what I've replaced:
-Strut Mounts and Bearings
-Lower control arm bushings (R32 bushings)
-Drivers Side CV axle
What I've checked:
-Tie rod ends have no play
-Ball joints have no play.
-I have no sway bar, so not the sway bar bushings.
-Its not the axle hitting the frame.
Could possibly be the dog bone mount but when I installed the 1' motor mounts I saw no issue but could possibly be the bushing. feel the clunk in my foot as well.
MK4 2000 Jetta 2.0 5speed With Raceland Ultimo Coilovers (Junk)
View 13 Replies
2004 Jetta 1.8t manual, sport package with about 85,000 miles on it and I've owned it since new.
About a year ago I had a shop replace the strut bearings while it was in for some other things. After I picked it up my alignment was jacked and there was a binding sound coming from the front end. The shop said the sound was just the springs settling in. It did go away after a while. Still don't understand why the alignment was off but I aligned it myself and all was good for a while.
About two weeks ago I myself replaced:
Lower control arms (stock VW) and ball joints (FEQ or Lemforder, not sure which) with R32 rear bushings and poly front (I HATE poly bushings but that's for another time)
Tie rod ends (FEQ)
Front brakes & rotors (stock VW)
I also threw in a oem Audi lower stress brace while I was under there but I don't think that has anything to do with my problem. Then I took it to a shop to have an alignment done on it. Everything is now within spec except that the caster is 6.6 degrees on the left front and 6.2 degrees on the right front. How does this happen?
So now my problem: There is a fairly loud binding sound coming from the front of the car randomly. It sounds like the coil spring is binding but maybe it is something else? it mostly does it when I reverse for a bit and then put it in first and drive forward or forward then reverse so something is shifting front to back. Steering doesn't really seem to have any noticeable effect.
View 1 Replies
2003 Jetta TDI 245K miles- owner's records show front bushings were replaced some time ago.
Suddenly started a groaning sound whenever the front driver's side suspension compresses. Started suddenly right after I hit a speed bump but not "hard". I parked and bounced on each corner of the car, no noise on anything but the front driver's side. The suspension's "give" felt similar across all 4x corners.
Of course whenever I'm braking or turning I get that sound. But it's definitely the suspension. And like I say, it's sudden.
I didn't see anything wrong, but the wheel's mostly in the way. The wheel cowling isn't rubbing the wheel. Handling feels fine, still goes straight with the hands off the wheel.
View 1 Replies
Front driver side area making a flat tire noise. Replaced the tires and axle and wheel bearings. Kinda lost on what could btw making the noise. Alignment done 15k miles ago when lowering springs and new shocks were put on.
View 5 Replies
I already changed the two front struts but the clunk its still there when i hit a bump or irregular surface, the dealer told me that I have replace the two front strut mounts too (I have a 2007 Camry SE V6 w 112 miles on it), that can solve my problems?
View 4 Replies
I have a 2002 Nissan Pathfinder 4x4 SE, and I have a strange noise emanating from the front suspension. It's essentially a creaking sound whenever going over speedbumps etc, that lasts only when crossing the bump in question. There is also a distinct ratcheting/popping sound when I more with the wheel at full lock. I've already replaced the front sway bar bushing, recently replaced the struts and springs, lower control arms, and have not noticed any shaking in the tie rods when I try to move them.
View 2 Replies
[URL] ....
Noise is coming from the front suspension. You can hear it at :11 after i come to a stop, then drive over a dip. The dealer has told me it is the front struts. It's the 2nd time I've taken it to the dealership, the first time they could not replicate the noise so i am surprised the technician was able to hear it this time, and I don't want to spend money on strut replacement if it isn't the cause.
View 14 Replies
My wife and I bought a 2014 Elantra with 30,000 miles on it. This is our first Hyundai and the car runs great, but the only issue I have is that whenever I go over a large bump in the road, the front suspension clunks and feels like it's coming apart. Smaller bumps or imperfections in the road are okay and the car runs smoothly over those, but the larger bumps and potholes produce an unreassuring clunk.
We've never owned a Hyundai before and we really like the car, but I was wondering if this is normal for the Elantra and if others experience this. I brought the car to the dealer and they checked everything out. They said all was fine and that it was normal. Is it?
View 4 Replies
I'm getting a clunk sound from my Passat's front left suspension when making turns. I've found info on how to diagnose control arms and I plan to jack the car up tomorrow and check it out. But how would I diagnose a tie rod end problem?
My Passat has 53,000 miles on it.
View 6 Replies
I just had a set of VWR springs installed on my 2011 GTI (35,xxx).
I've noticed a very discernible clunk coming from the driver's side front wheel particularly when traveling over a dip in the road (when the spring and suspension is extending). The sound only comes from the one wheel well - the other three sound fine.
I'm bringing it in for an alignment tomorrow (recommend after the spring install). Sounds almost like a bad bushing?
View 11 Replies
I had my car detailed last Saturday, and now I'm hearing squeaks from around the door seals whenever the car flexes (going over speed bumps, around corners, during rapid acceleration, etc.).
I wonder if they used something to clean the door seals that's causing the squeaks.
View 2 Replies
I have a 2007 Sonata Ltd (63000 miles) and had a clunk in the front suspension. I had the front upper control arms replaced (which were visually badly worn) and that fixed the problem. But now, a several months later another similar clunking noise has developed when I go over those small speed bumps in parking lots.
View 18 Replies
So I'm also noticing my car occasionally makes a huge thud sound from time to time when I put it into two certain gears. From park to reverse it's not loud but there's a little noise, but from any gear into Drive it's sometimes a loud boom and the car shakes. My pops mentioned to me this is dangerous because of how the engine is moving underneath the hood when it happens. I just recently changed the dog bone mount, could it be the others? I'm ware that it's wise to change all 3 if you change one but I was on a budget & it was a lot worse before. Someone mentioned it might be my torque converter but I did some research & the two symptoms don't add up. And I'll add once more that this happens occasionally & not every time I switch to a different gear. What it may be?
View 11 Replies
Alright cliff notes are lowered my 2012 GTI on Eibach Pro Kit springs and Koni Yellows (adjustable) as a DIY driveway job and at first were OK, but 2 weeks later are clunking to the point where it sounds like its going to fall on the ground. Any road imperfection makes it clunk (from the front only).
-Clunks all the time, slow, fast, turns, straight, large or small bumps. Doesn't clunk with dips...
-Gets better when its hot outside (>70 degrees),
View 24 Replies
New to the VW world, just noticed a CLUNK noise in the rear right of my car when i go over bump/potholes.
View 4 Replies
