Ever since I got my 3" TB installed I've noticed it rattles on the rear beam. I have tried wrapping the beam with exhaust wrap but it lasts for few days. What could I do to fix it?
View 11 RepliesSo I recently lower my car and my 3" exhaust started a constant rattle when I'm in the car. When I get out it stops. Been lowered for a week or so now and today was the first time that happened. I've read up and seen its pretty common when we go lower. Also some ways to possibly fix it.
View 16 RepliesI've noticed that potentially my heat shield or whatever guard that is 1 step toward the front of the car from where the inlet pipe connects to the exhaust system may be the reason for my rattle at 2k and 3k rpms. i think its a heat shield but I am not sure. the thing is it seems properly mounted, nothing is cracked/broken/or loose. But when I do try and wiggle it it does make a slight creaking noise that sounds similar to the rattle I get. So I could foresee this as being my issue.
But, is there anyway to fix this rattle w/out just taking off the part? i figure its there for a reason and it looks like its held on in 2 places. But they're not nuts they almost look like spot welds or something. 1 on each side. What to do?
Something to get you all in here:
Watch this video. I have a rattle/noise coming from the rear right side of my car for almost 2 years now.
The part in the video is the neck of the fuel tank just behind the plastic inner fender.
[URL] ....
Is this normal? i don't know where to search anymore to find where the rattle comes from...
This previous weekend, my buddies and I finally got my FK coilovers installed on my GTI. I have heard that people say there is a little bit of rattling upon them getting properly seated. Well it has been 4 days of driving and now sounds like the rattling has gotten worse! I took it into a local suspension shop and they couldn't put a thumb on it. We in-turn found out that my rear hub bearing was going out and has since been replace. Having issues with coilovers? I have contacted the company that I purchased them through already and am awaiting feedback from them.
Pic of the car in question. (Before coilovers)...
I just got my R last Monday and have noticed a weird rattle coming from the exhaust. It only happens when I am driving. I can rev the engine when parked and the car sounds great. The rattle seems to happen when the car shifts and seems to happen less often if I've been driving for a little while. I did take it to VW they put it on a lift and checked everything underneath. I was told it might just go away but if not to come back and they will further check it out. What it might be?
View 24 RepliesI did some searching and found someone with the same dsg rattle chatter noise I am getting from my R (check link below)
My R has 102,000 miles, runs excellent but the dsg makes a noise mostly when I am in gear stopped with my foot on the brake. While I was under the car checking out the chatter noise I noticed a faint exhaust leak somewhere in the headers near the flex pipe. I want to fix it and I plan to put on a cat back exhaust very soon but I really don't want to spend the money on a set of headers.
OK, my stock exhaust would rattle when I shifted UP with the DSG, seems to be a fairly common thing. I got the EJ exhaust and it STILL does it on occasion, not as bad. Is there a loose heat shield or something? If I rev the car slowly while driving (not standing still) and get it to red line there is no metallic rattle. If I rev it fast and shift, it rattles
View 8 RepliesEverytime I run my revs past 4 and shift, I can hear a steel rattle right at the shift. It's stock exhaust btw, no mods...
View 24 RepliesI have 2000 golf with a gli front end. Recently just did the swap and now I'm having issues with one blinker and one high beam not working. The running lights work on both sides. The headlights work on both sides. I checked the bulbs and they were good. I check for power it was all good. I checked the fuses and they were fine.
View 7 RepliesI installed a headlight kit from VW tuning a while back d2s with 6k bulbs I believe.
The headlights work but my high beam indicator is stuck on. I know this is a common problem but for the life of me I can't figure out how to fix it. If I switch back and forth with the stick on the column it does nothing. Just stays on high beams. I've just kind of dealt with it for a while.
Driving home the other day my right turn signal stopped working. Checked all lights when I got home and the front signal had a constant but low illumination and all the other lights were mostly out as well, very little was working actually.
Pulled the bumper and head lamp tonight. The plastic connector on the low beam was melted and the wires were burnt. The problem was the two brown wires that are sort of routed together. Third wire (grey or another shade of brown depending on headlight manufacturer) was OK.
Headlights are aftermarket, Volx Tuning, < 1 yr old. The rest of the harness inside the assembly looks good- certainly don't see any opportunities for a short.
I replaced the connector and bad section of wire and plugged it back in for a test. All lights were then 100% operational. I removed the assembly to find that the same lamp was smoking again. (I sort of expected this, but had to try.)
Clearly I've got a short somewhere but where do I start? The part of the vehicle's wiring harness that is visible behind the assembly is in good condition. The lamp itself (H7 I believe?) appears OK as well, I don't guess I get so so lucky as to hear those can develop an internal short in the base or something?
I have a 2003 Jetta Gli , 24v vr6 with a 6 speed transmission.
Well this all started last night, started to drive, when accelerating , around 3k RPM I start to hear a rattle or grind. This only happens around 3k while accelerating. Once letting off the gas or pushing the clutch in, it goes away. Sometimes after 3k it'll go away.
I've got an awd 1.8t and ever since I did my 3" downpipe and cat delete I've had an oil smell both inside my car and from my exhaust. I thought at first maybe it was the valve cover gasket which I did last summer, but it looks to be fine. Also it does smoke out of my exhaust sometimes, but a buddy told me if it was my turbo seals my oil level would reflect the seals being gone, which the oil level hasn't moved. What else could it be? Do I just need to put a cat backin?
View 5 RepliesI have a 2001 Jetta 2.0L standard transmission I believe my exhaust manifold is cracked looking for a replacement. There is a local guy selling one off a 2001 golf wondering if that would work on my car..
View 1 RepliesSo I acquired a 2003 1.8t GTi a little bit ago and i'm loving it, but I want it to be louder and more aggressive. With that being said I've already searched the forums but could not find anything for my specific case. I bought the car with a 3 inch downpipe and Borla muffler installed so I would like to know what way I can modify the exhaust to be louder while keeping these components in tact!
View 8 RepliesPutting a straight pipe from the cat back on 1.8T mk4? I was thinking going 2.5 inches from the cat back with a tip. But I wanna know how loud it is.
View 6 RepliesSo I recently swapped my 2.8l 12v vr6 for the same engine because mine blew up, everything went good and the car runs great but there is a faint kind of rattling sound coming from the top of my motor, when its idling it will be a constant faint rattle. It gets worse as i accelerate between 3 to 4.5 rpms but then stops making the noise when i really start cooking so Idk if I just can't hear it or what. I've tried looking it up but i can't seem to find a video that has the same problems as my car. My father told me it could be my rockers or valves and others have told me it could be my timing chain or guides. I would love to just take it to vw to get it diagnosed but I don't have the money. I will try and upload a video of the sound ....
View 7 RepliesHave a sunroof that rattles when closed while going over bumps? I use my fingers to lift up on it and its barely budging, also floors are soaked....
View 3 RepliesThe rattle, 1.8t GLI
-2500-3000 RPM
-Car can be in gear or out of gear, rev rattle is the same.
-Sometimes, I can hear the rattle when the car is off and I slam the door slightly harder than usual.
-My hood release cable may have been the culprit, but I could only zip-tie part of it and the rattle hasn't changed.
One really important clue is that when I have reached around the area between my engine and airbox, the rattle has gone away. So I had a bad coolant flange, so when reaching my phone down there to take pictures, I must have bumped or pressed something because the noise was gone for about a mile.
I recently had my airbox out and a visual inspection didn't show any promise and tapping on random parts didn't recreate the sound.
There is am RPM rattle near my airbox....
I am leaking coolant at a slow drip but over a couple days my coolant light will come on due to low levels. I climbed under the car and I'm leaking right where the o2 sensors are on the exhaust. The coolant is dripping down from the exhaust shield which was just hanging there when I got under the car.
View 3 Replies