So I was late getting ready to go somewhere and knew that my coolant was low and asked my dad to fill it up for me and he accidentally put the coolant in my power steering pump. I don't think it will really effect it.
View 9 RepliesI've lost all power steering about a week ago. I checked all the lines the return is bring fluid up from the pump and the res is flowing into the pump.
A) should I replace pump?
B) look into other things that could be causing the issue?
A few days ago I had a big PS fluid leak. Turned out the return line had been sliced a bit. I had to drive it for a couple days before I could get around to fixing it. The steering is still stiff and the pump whines. Is this an indicator that I need to replace the pump?
View 4 RepliesI am having a heck of a time finding this coolant leak. It drips off the power steering pump. I replaced the upper radiator hose and the heater "y" hose that goes to the bottom of the Degas bottle. I recently replaced the lower radiator hose as well. So the truck runs normal. When the system is under pressure I do not see any leaks. But after the engine is completely cold it starts leaking a small puddle of coolant. Its appears to be coming from the power steering pump. But I am sure its something above or near it. This is on my 2005 Excursion with a 6.0. Can the water pump be going bad and leaking this direction. I would expect a water pump to leak straight down the middle of the engine. What to look for? The thermostat seal stays dry. but it has to be in that area. What is really messing with me is. When it is hot and pressured up It does not seem to leak. Only after it has been sitting for hours and cools off..........What the heck!
View 14 Replies6L Turbo Diesel .... I still have this returning oil drop on the oil pressure regulator. That fluid does seem to be oil.
Now I found what appears to be coolant dripping off the power steering pump. I have had to add a small amount of coolant every week...not much but definitely noticeable.
I have a new OPR which I will replace. These pics are from looking up at the mail pulley and to the left (power steering)..
So my coolant system woes have continued! I recently replaced my thermostat ,thermostat housing, thermostat cover and all of the rings and gaskets. I finally stopped the leak on the driver side which seem to be the thermostat now about seven days later I am experiencing leaking on the passenger side. I walked out from work today and noticed I pool of coolant under the car. I can't tell exactly where it's coming from but it's coming from one of the components that runs off of the large belt. I snapped a few pics from the bottom of the car I don't think this is the actual component that's leaking. I think the leak is just falling off of it . I was wondering where the water pump is located.
View 5 RepliesSo after a long trip from my vacation I ended up running over a dead deer on my 2004 VW Jetta GLI 1.8T AWP. As soon as I hit the car turned off. I was looking around to see what the damage was and everything looked intact but my car still wouldn't turn on. I checked some things and came to the conclusion that there was no fuel running to the engine (whenever the key would be on the "ON" position the fuel pump didn't make the usual "whirring" sound meaning it was on).
So I checked the fuel pump fuse, that was good but when I checked if there was current in the fuse, there wasn't. Then I disconnected the fuel pump to see if there was current going through the connector and there wasn't. This led me to check the fuel pump relay. Relay looked good and when I checked to see if there was current going through to the relay, there wasn't. So my issue is that the car is not turning on because there is no current going through to the fuel pump and no current to the relay and fuse.
Over the past week its been pretty cold here in IL (hovering around 30 degrees). Car makes a binding noise when its cold, but only when its cold. Noise is VERY similar to this:
Is this my PS pump going out, the rack itself, or something suspension related? Fluid level is up to the Max and there are no leaks....
Long story short, my car died on me shortly after pulling out of the driveway a few weeks ago. Initially I thought it was my fuel pump because it wasn't priming when I had the key turned to the "ON" position. Here's what I know for sure:
The fuel pump works. It was tested and is not the issue. The relay is good.
The fuse from number 28 is good. There isn't any power at the fuse. The shop has been tracing wires and looking at diagrams and cannot find any breaks in any wires.
The ECU has been swapped for another one. When I turn the key to the "ON" position, the check engine light and EPC light come on, then turn off after about 3 seconds. They do not stay on.
What else could it be? Car in question is an 01 Jetta 1.8T AWD motor code.
I have a 2005 Volkswagen GTI with 80k miles. Just yesterday I went to school and the car drove fine. But when I came back and tried to start my car, it stalled out after a few seconds. Now I thought this was a bad fuel pump until I checked it and found that the fuel pump wasn't receiving any power. I checked the fuse and it was intact. So then I went to check the relay and found that if I unplug the relay and plug it back in, the fuel pump momentarily receives power for about 2 seconds then nothing. Any clue what the interference could be?
View 1 RepliesI think I blew a power steering hose. I lost all my fluid and lost power steering. I'm at work. Is it safe to drive 3 miles home with no fluid?
View 4 RepliesI have a 2001 Jetta 2.0 5 speed. Some months ago I was driving in a little snow and turned my wheel at just about full lock, in reverse. All of a sudden I hear a gushing sound coming from around the steering wheel/floorboard. Power steering officially ceased to work. Ive drove with it like that for a while now. To the point where the rubber around my steering wheel is all falling off. But it's getting old.
I've replaced the pump four separate times. Nothing. Can't hear the pump try to work. Fluid comes in to the drivers floorboard. My whole carpet is soaked with it. Also, I refill the reservoir to keep the pump lubed and everything, but for some reason if I turn my AC on it makes the pump instantly burn out. Complete with smoke and the pulley snapping off. Ive looked for leaks, loose hoses etc.
So I'm not sure if this thread goes here or not, but I thought I'd throw this out there to see if I could get a definitive answer: I started to hear some whining from the steering when I turn, checked the PS reservoir, and it was a bit low, so I added some fluid (the correct type, too). The whining hasn't stopped, but I'm not getting any leaking anywhere. I've done some searching on Vortex and other sites but can't come up with any useful information regarding the use of Lucas Power Steering additive (or any other additive) with VW steering systems.
View 2 RepliesI have an 06 Jetta VR6 and it's making a lot of power steering noise (humming and howling). Is steering pump failure common in these cars?
View 4 RepliesI want to clean up my bay a little bit. How and where can I relocate the power steering reservoir?
View 15 RepliesOkay so recently I was driving my 2000 Jetta and the coolant temp light came flashing on, when I went to check the coolant I was surprised to discover that it was like a mud brown color, almost looks like peanut butter. From everything I have read this can be from a few things, either rust build up that is gunking everything up and oil getting into the coolant somehow. I'm pretty sure its rust build up but I was wondering what everyone thinks about this, I was also not using G12 coolant which I'm told now is the premier brand for VW's.
View 3 RepliesI need to replace the power steering rack on my car. Mech wants 300+parts. I supply the parts. Is there a different rack for the vr6 VS the I4 jetta?
View 1 RepliesRecently bought a MK4 for 1500, I already knew the car would have problems at some point. To make a long story short. I was driving yesterday, I was in 5th gear, going around 55 mph. Out of no where my battery light comes on and next thing I know the power steering goes. The car completely shut off out of no where, there was no noise or anything that would warn me except the battery light. So I automatically thought the alternator must have went. I checked the alternator and battery. The battery was from September of 2011 so.I bought a new one and thought that maybe that was the problem. The car didn't do anything, it didn't even crank it would do absolutely nothing. The funny part is, which has me puzzled is that the lights, radio and other electronics work fine. I don't know if it's either the alternator, ignition coil, the starter, or the wire harness. What this could be?
View 8 RepliesThis is the second time the car has died mid-drive. was getting off an exit on the interstate, popped it into neutral from 5th. suddenly had no power steering/brakes. engine just shut off. pulled over to start it, and engine just turned over. no starting-just the cheerful noise of a cranking engine. nice motorist pulled over and gave me a jump, which worked. The first time was the same story. going into neutral to coast down a hill, and it died. was about to get a jump and it started after sitting for about 10 mins. What is going on here?! fuel filter? pump? I'm at a loss.
View 12 RepliesYesterday while cruising around, my right front tire hit a bumpy rock, it was quite a tough hit, but the car kept cruising well. I parked it one minute later and inspected it, nothing seemed wrong. After 2 hours i came back and looked under it. no oil was dripping or anything, still run well for 10 minutes. then, the steering started to ROAR.
Basically, the car was dripping and no power steering oil was left. I didn't do a full inspection yet. I brought the car yesterday on a tow truck and today is Sunday so no mechanics are open in my country.
I took this picture which represents where all the oil is dripping from. also there's a video [URL] .....
I'll be taking the car for inspection tomorrow, but i want to hear from other MK4 owners if they know where the oil might be dripping from. Ican't state if the dripping happened due to hitting the damn rock...do you think it's related?
Well my car is crapping out lately,
I put a new steering rack in my mk4 1.8t jetta about a week before I parked it for winter. I went out to the garage yesterday and noticed a pool of PS fluid on the ground, I located one very small leak from the bottom banjo bolt on the rack (needs new crush washers, Was in a rush and didn't have time to pick new ones up :bang head: ).
But the part that confuses me is there is a puddle on/under the passenger side subframe, the rack boot appears to be dry, and I don't believe the new rack is faulty, they are supposed to be all tested and approved before reaching the buyer. and when I turn the car on I can't see a leak anywhere even with the wheel off and a decent view of the rack.