Recently purchased a used 02 Golf 2.0 and the engine light has come on with low (around 1/4) fuel, and after i fill up, a day later it turns off by itself.. Next time it happens ill bring it to the dealer just to have the code scanned. I've read the cat's commonly go on these cars, which is a hefty fix.. Its just weird to me it only comes on with low fuel.
View 3 RepliesI recently had my fuel pump replaced in my 2005 GTI ... twice. Both times, the fuel gauge no longer shows a full tank, and doesn't show empty tank correctly. Is there some way to reset the gauge? Is the pump somehow tied to the gauge, or did the mechanics mess the float up when they changed the pump? Sadly I had it repaired somewhere other then the dealer.
View 1 RepliesRecently I bought a aem fuel pump only to find out it was for a vr6... go figure. so i said no big deal took it off and put my old one back on. Everything worked fine before now but now that i have put the old fuel pump back in i am not getting any fuel at all.
View 6 Replies2000 Golf Gl AEG 2.0
My car smells of fuel in the exhaust and when checking the oil it is mixed. I have a cel and it says the o2 sensor is bad, not sure if a bad o2 would be causing all of this or not. The air filter is clean and I have done a few oil changes also. The oil is low also after so many miles but cannot seem to see any leaks.
Car also has over 200,000 miles. Is it necessary to change the gear oil in the vehicle?
After changing a head gasket, I went to fire up and noticed three injectors are leaking where they meet the fuel rail. They weren't leaking before tearing everything apart and nothing was done to the rail other than moving it. From what I've searched, it sounds like O-rings. 2002 2.0 Jetta.
View 3 RepliesI need to replace the fuel line that connects to the fuel rail, it is old and corroding and drips out gas when I dry so I need to replace it. I have the new fuel line for it but how would I go about taking it off and the clamps? Just wanna make sure I am doing it right.
View 1 RepliesSo lately have had few symptoms of fuel pump going out and all that but tonight randomly wouldn't start and I mean no power, no lights, no turn over, no anything like my key fob won't even set my alarm or unlock car is this another symptom.
View 12 Replies2000 1.8t 5 speed Jetta ... The car has run fine up until recently when I started having some starting issues. It was intermittent, and got more frequent and longer. The car will crank but not fire. In the beginning, I could crank it for a few seconds, turn off and turn back on and then it would fire like nothing happen. This continued to happen and progressively get worse until I could not get it started, I could smell fuel which lead me to assume I had to spark.
Today I went out to swap crank sensors but only tried for a little while and cant really get my hand up there. So, I disconnected the battery for a while, went back and connected it, and it started. Up until this point I have had the same 2 codes, over/under boost, but the car has always ran with them present. I scanned today and got a p1545 Throttle position sensor code...But only got that one time. Ive been messing around with disconnecting and reconnecting the battery and among one of these times, the EPC light came on and would not rev passed 1k rpm. turned it off, turned it on, and it was fine after that.
Im sure I have a sensor about to let go Im just not too sure which one it is. I dont have vcds and am not getting a low signal code from the crank sensor with the scanner I have.
I just worked on my car for a week and it was jacked up with the rear end squatted down and now when i corner the fuel gauge goes down.
2004 1.8t jetta ....
Was looking to get some input on possible reasons why I'm getting bad fuel economy. I have a 2003 Jetta TDI with 335 000kms and over the past few months have gone from roughly 1000km/tank (5.3l/100km) to about 700kms per tank (6.7l/100km). The cars timing is spot on. I've changed the air filter. Checked intercooler and maf all of which seem to be fine. I have a VCDS and have gone through many of the values and everything seems to be running fine except for excess pressure.
The map reading is spiking to 2500mbar at about 2800 rpm under full load. Specs on the vagcom say it should be around 2000mbar max. Power is fine and its not smoking other than on start up which on cold morning ( everyone morning here in Canada) seems to stutter quite a bit while idling for the first minute or two. I realize winter gas along with winter tires etc can equate for quite a bit of fuel economy loss but i just cant see losing 300kms / tank.
So after a long trip from my vacation I ended up running over a dead deer on my 2004 VW Jetta GLI 1.8T AWP. As soon as I hit the car turned off. I was looking around to see what the damage was and everything looked intact but my car still wouldn't turn on. I checked some things and came to the conclusion that there was no fuel running to the engine (whenever the key would be on the "ON" position the fuel pump didn't make the usual "whirring" sound meaning it was on).
So I checked the fuel pump fuse, that was good but when I checked if there was current in the fuse, there wasn't. Then I disconnected the fuel pump to see if there was current going through the connector and there wasn't. This led me to check the fuel pump relay. Relay looked good and when I checked to see if there was current going through to the relay, there wasn't. So my issue is that the car is not turning on because there is no current going through to the fuel pump and no current to the relay and fuse.
Long story short, my car died on me shortly after pulling out of the driveway a few weeks ago. Initially I thought it was my fuel pump because it wasn't priming when I had the key turned to the "ON" position. Here's what I know for sure:
The fuel pump works. It was tested and is not the issue. The relay is good.
The fuse from number 28 is good. There isn't any power at the fuse. The shop has been tracing wires and looking at diagrams and cannot find any breaks in any wires.
The ECU has been swapped for another one. When I turn the key to the "ON" position, the check engine light and EPC light come on, then turn off after about 3 seconds. They do not stay on.
What else could it be? Car in question is an 01 Jetta 1.8T AWD motor code.
Where is the fuel pressure regulator on a 2005 Jetta 2.0 BEV. It's nowhere on the fuel rail.
View 1 Replies1999 Jetta 2.0L manual trans
One day out of the blue the car would not crank or start. Checked and found that fuse #14 was blown and would blow the instant another fuse was inserted. Checked all the typical locations for wiring issues usually associated with the comfort module because it had all the symptoms of a faulty module (the power windows did not work and the fuel pump didn't pressurize the system when the driver door was opened, the alarm didn't set, automatic door locks also inoperable).
I checked the dome light, trunk hinges, rubber boot between doors and body and found nothing. Put a jumper wire into the neutral start relay and was able to crank the car. I then replaced clutch safety switch, neutral start relay and installed new (junkyard) comfort module and the car cranked up, started and everything was working normally again...for about 3 weeks. Then it did the exact same thing again. Fuse #14 was blown again and would blow the new fuse as soon as it touched the terminals in the fuse box.
I reinstalled the jumper wire in the start relay in order to be able to drive the car for the last week, and then last night out of the blue the car would crank, but not start. I turned the engine over several times and could hear the fuel pump pumping and even smell fuel, but no start. 3-5 minutes later after random tries to start, the car stumbles to life as if it wasn't getting fuel, and then drove 10 miles home with no issues. I returned the 'faulty' comfort module Monday and got another one but haven't installed it yet because I fear the same thing happening with this one as the other one.
Last night after I got the car home, I plugged in the comfort module and everything worked like it was supposed to. Can a faulty fuel pump damage the control module? I'm trying to get to the bottom of this and fix the problem and not the symptoms so I'm looking into anything that could potentially cause the problem.
I got a 2002 GTI 1.8t , with about 109,xxx miles. Ran into a few problems, I took the hose off the fuel rail and turnt the key on. & noticed the fuel pressure was noticeable low & another problem i got is the car doesnt start most of the time. it takes about 3 or 4 cranks before it eventually tuns over. sometimes i noticed if i turn the key on and leave it for a minute or so itll start up. finally want to fix this POS. so I decided to run the codes & heres what i got
P0230
Fuel Pump Primary Circuit Malfunction
CONFIRMED
P0341
Camshaft Position Sensor A Circuit Range/Proformance B1
Its a 2005 awp 1.8t gti with 180K stage 2 apr. When i tune the key to the accessories on position I used to hear the fuel pump priming but now I don't and the car wont start.
View 5 RepliesI am having an issue with my speedo and the fuel gauge on my 2002.5 24v vr6. First it started with a speedo that would bounce and dance around. it went away then came back and so on for awhile. Then i notice the fuel gauge would go up or down and would flash that i need to fill as I would go around turns. Also the odometer doesnt work either. I know that the vss could be the cause.
View 1 RepliesI have a 2005 Volkswagen GTI with 80k miles. Just yesterday I went to school and the car drove fine. But when I came back and tried to start my car, it stalled out after a few seconds. Now I thought this was a bad fuel pump until I checked it and found that the fuel pump wasn't receiving any power. I checked the fuse and it was intact. So then I went to check the relay and found that if I unplug the relay and plug it back in, the fuel pump momentarily receives power for about 2 seconds then nothing. Any clue what the interference could be?
View 1 RepliesThe Symptoms: Car decided not to turn over for my son one morning, when I came home I tried with my key and the engine did turn over but immediately died.
Turned on key to power and watched for lights like the immobilizer/key but that came on and went off no problems there, did the same with both keys and the immobilizer/security key light went off fine.
Read for codes and there was a P0320 which pointed to Crankshaft Position Sensor. Order the part from good old Rock Auto and 2 days later it came, installed, cleared out the code, tried to start, did not start.
Decided to spray some starter fluid into the throttle body to get it to turn over in hopes a new code would come out.
It did fire up for a few seconds and did throw another code, this time P0321. That code points to the same sensor I just replaced.
Figured I would check to ensure the fuel pump and relay were working so I wired from positive and negative battery terminal to the outer plug clips at the fuel pump and I heard and felt it click. Not sure if it should prime and make more than just a click.
In my other cars you can clealy hear it prime for more than a second so not sure if the fuel pump is really the culprit here.
The car has 125K and the pump is original I can see.
I did check the relay fuse under the drivers side dash and I can feel/hear it click when I turn the ignition on.
I also did check all of the various fuses in the side compartment that have to do with the engine, they all look good and tested with multimeter as well.
So now I did order a new fuel pump, what else to try out? I did change the fuel filter at 100K so do not believe that is causing the issue. Not sure if the fuel regulator by the rail could be an issue.
It seems like all of a sudden fuel is not being delivered and with faulty injectors or plugs, they throw a code for misfire etc. Also starter seems to be fine, no griinding/smoke etc but was thinking about taking it out and over to Advance to have them check as well.
Ok so I disconnected the fuel line and the fuel pumps when I turn the key to on and when I crank it it's not pumping gas ..
Changed the relay
Changed the crank pos sensor
I'm at a loss what would cause the fuel pump not pump when cranking?
04 jetta 1.8t
apr tune 1.6v
neuspeed 4bar fuel pressure regulator
3" turbo back
APR TIP
This is the second time this happened to me. First time was about two weeks ago where i was just driving and the car stalled. Tried to start but it sounded like it just wasn't getting fuel. Brand new battery, terminals are clean) Got it started and it was revving high like a cold start, normal but why after driving for 30 mins? EPC light came on also which was strange along with the CEL, a buddy checked the code and it was for the secondary air injection pump. (I have not had that go off in a while. Code po4011 secondary air injection. Had this issue a while ago with that code when i did a short ram intake. Tuner cleared it so i can pass emissions. ) Now today it died about 2 miles from my house. Same thing but no CEL. EPC light came on and car was revving high, luckily 3 cars behind my buddy was there and he give me a push into the gas station. Once again it wanted to start but i felt like no fuel. waited a few minutes and it started right up again until it almost died in my drive way. Cluster comes on when it dies. ignition is good.
My big question is the stalling part and the EPC light coming on, then the car revving like it is a cold start but not stopping? and i need this car to be working.