Golf IV / Jetta IV :: AC Not Working / Low Voltage At Compressor
Sep 19, 2016
I am trying to figure out why my AC is not working. Both fans are coming on and the AC button is light up but it is not blowing cold. The charge was checked and it has a good charge. The compressor appears to not be engaging. I checked for power at the electrical connector for the AC compressor and my voltmeter is showing voltage between 3.1-8.3 volts. It jumps around between that voltage every few seconds. The fuses have all been checked and are in not broken. What else should I be checking?
View 2 Replies
Advertisement
I got a 2003 GTI 1.8t and the AC air is blowing warm. With the car on, AC on and fans full blast both rad fans turn on but compressor clutch does not engage. Took it to a shop and the mechanic said the system was full of refrigerant but that the compressor was not getting the proper signal and there was an electrical problem.
I check the power at the compressor and it is reading about 7 volts, which is low correct? That should be getting 12-13 volts correct? I also check the pressure switch over by the passenger side and it was getting 13v. What to check next to start ruling out causes? Any quick way to determine whether this is electrical or a compressor issue? I am limited in my abilities as far as electrical work goes.
View 2 Replies
Ok My Ac doesn't work on my 05 Jetta 2.0 blows hot air. These are the steps taken so far to no avail
_Function test A/C System_ A/C is not cold_ Recover A/C, System was low
_Pressure test system with nitrogen for leaks_No Leaks Found
_Charge system and add dye
_Test operation
_Found compressor not cutting in_ Inspect for ground at compressor_OK
_Test for power at compressor_NO POWER GETTING TO COMPRESSOR
_Inspect fuses_OK
What's going on with this and what the next steps might be?
View 3 Replies
I have a 2002 Jetta 1.8t and the A/c doesn't work. I took a look and I know that the clutch/compressor does not engage. also, the rad fans do not turn on when I have the AC on in the car. all I get is hot air. I tested the line and there is no freon in them whatsoever. which is why the compressor is off. however, I can't add any freon without it working. I checked the fuses on the side of my dash and on top of the battery as they seem to be ok. Also, I was told that I just need to replace the compressor with a new one and I should be good to go. Is this true? It will be an easy fix if it is.
View 13 Replies
99 Jetta VR6... 190k
So the heat doesn't really work on my car- and its getting cold outside.
I read the DIY on fixing the resistor pack, but there is a lot of hooptiness to my ride, (not sure if that's the issue).
All the fan control speeds work, but the most I ever get is vaguely warm air- it never gets fully hot.
The temperature gauge does not work most of the time- it does occasionally (but randomly) work as expected.
The defrost doesn't work either due to an issue with the AC (it keeps blowing the fuse for the AC compressor- like, right away)
There's a multitude of issues happening here I know, but need to narrow down the suspects for the heat, that would be very useful.
View 2 Replies
Unplugging the Ac compressor, what the voltage reads on the three orange leads that run the compressor (one lead from voltmeter to ground, AC voltage). Test with Ac off then on.
View 2 Replies
AC compressor won't kick on at all. I know the system doesn't have much refrigerant (just replaced the line that runs from the expansion valve to the bottom of the drier, the drier itself, and the condenser)..
Evacuated the entire system with a pump. Tried putting refrigerant in and the pressure on the gauge goes up immediately into the yellow/red...jumped the connector on the high pressure switch and the fans came on, shouldn't the compressor kick on too?
Checked the 14 pin connector on the fcm for 12V...PIN number 8 is barely seeing any power which leads to no power getting to the compressor...
View 11 Replies
The dealer diagnosed my a/c as needing a new compressor and clutch. I had an a/c specialty shop install a remanufactured compressor and clutch. however, they could not get the compressor to kick on. I checked all fuses (all are good).
I checked the compressor continuity (good, 0 ohms). I checked the plug where the compressor clutch plugs in (it reads 12 volts). the funny thing is, it reads 12 volts anytime the engine is running (even if the climatroinc is turned off). I am definitely not an a/c expert and really don't know how this stuff works.
View 7 Replies
In my 2001 2.0, my AC has been blowing hot air for a while now. It was intermittent at first but now is constant.
The compressor runs without going off when the AC is switched on. I can tell because I see the compressor clutch engaged and spinning.
I tested with AC manifold gauges and these are the readings I got.
Engine off : Low is 0, High is 135
Engine on, AC on full blast after running 10 min at 1500 RPM:
Low is 4, High is 135
Looks pretty bad.
View 1 Replies
2000 jetta 2.0
so far i have replaced 2 fans ; thermal switch in radiator ; ran all the tests i can find ; all fuses and relays seem fine ; jumped compressor and it engages .
key on & car NOT running there is no power to the compressor.
I wanted to check the low pressure switch but every test is for a 2 wire set-up.... mine has 3 wires. which wires do i jump?
View 5 Replies
I have a 2004 Jetta wagon 2.0. About 2 years ago my compressor was replaced with a used one and the a/c was working perfectly fine. Last year the air from the a/c began to get warmer until it completely stopped blowing any cold air. A couple of weeks ago we checked the freon lines and they had plenty of pressure in them. We also checked the fuses in the car and on top of the battery along with the fan control module. The compressor spins from the serpentine belt but the clutch does not engage and there is no power in the wires going to the compressor. There is power at the high pressure switch but the condenser fan does not come on unless the switch is jumped. Could the culprit be the ambient temperature sensor?
View 9 Replies
I have an 02' 2.0 Jetta Wagon, and the A/C is having some issues. Since I know close to nothing about A/C systems, I took it in to a few places to have it looked at. I've had the whole system Evac'd and recharged, and have had the low pressure fitting replaced (apparently there was a slight leak there), and the system is still not working.
The A/C worked fine when I first purchased the car a few months ago. Shortly after my 800 mile trek from Oregon, back to home, the A/C started to only work intermittently. The compressor would engage, then disengage, repeat...It seemed like a bad idea to keep trying to use it in its sad state so I stopped using it altogether. As I said, I had the system emptied and recharged, but it still only works intermittently. It sort of follows a pattern where upon start up it works longer, and switches on and off at shorter intervals, until it doesn't engage at all.
There are no strange noises from the compressor, and when it was hooked up to the machine, it proved to be performing its function well.
View 5 Replies
Compressor does not engage, and my fans do not come on when I turn on the A/C. They do come on low speed when I jumper pins 1 and 2 on the temp switch plug, but they do not come on high speed when I jumper pins 2 and 3.
I have replaced the FCM with a new one, as well as a guaranteed working used one; neither one changed anything. I assumed right away that it was the fcm because my original one has a hole eaten through it from battery acid.
Compressor clutch ohms out within spec, and it will engage if jumpered.
View 3 Replies
I have a 2003 2.8 GLI and my compressor clutch will not engaged i provided the clutch with a direct power and ground from the battery and it engaged. i also went to the junk yard and got a couple of Fan Control Module ($4 each) and it still does not engaged.
View 3 Replies
Golf 2.0 ... Finding the location of the AC Clutch/Compressor relay location. On the TDI its behind the the dash and I looked on mine and it doesn't seem to be the same. I've seen a thread where some said it was under the battery? Where it is and what number will be stamped on it. Another thread said it should be behind the dash and number 385 or 358, I looked and I don't have those numbers back there.
View 2 Replies
2002.5 VW Jetta GLI VR6 24V 6-Speed. Barely accepts a small can of Freon from full empty, and pressure goes to over 100 psi in the red, compressor does not kick in, idle fluctuates with A/C button on, small fan kicks on fine, some air pump turns on and off with the erratic idle and sounds like shot of compressed air. When I turn the A/C button off, idle comes back to normal and that psss sound is gone. I already changed compressors and that made no difference. Video below.....
View 5 Replies
Clutch for the AC Compressor will not disengage even with the AC off. The only way I can daily the car is if I disconnect the power from the AC Compressor at the compressor itself. Seems the AC compressor has a constant draw if it is plugged in.
Plugged = dead battery...
Unplugged = good battery...
I'm getting ready to rip the damn thing off the engine and calling it a day, but that would defeat the purpose of me buying a new compressor.
View 4 Replies
I have an issue with my 2003 golf 2.0 ac I've done everything that I cloud thing of to check but I still have this issue so here it is. The air coming out of the vents is warm, compressor Clush turn on but doesn't kick off. I hook up ac gauges and it reads 70 on low side and 155 on high side with an ambient temperature of 80. The system has freon, I check fans and they are on when compressor kicks in all relays and fuses are fine.
View 8 Replies
Weird A/C issue that started yesterday. Had ac on all morning, start my car after lunch, a/c runs for a few seconds, hear a squeak (like a belt sticking) no more a/c. Moving the temp knob makes no change just all hot air. Both fans engage, compressor and what I believe is the clutch engage, hoses get cold, and no CEL's. Really stumped here.
View 3 Replies
03 Jetta 1.8T AC is giving me fits. When the compressor comes on the AC is nice and cold. Problem is that it isn't on very much. Today was a good example. No AC for about the first 30 min drive to get an oil change (local driving). Next 40 min highway drive, AC only got cold for the last 20 minutes and then started to warm up before I got to work. Drove to auto parts place at lunch, AC cold from start to finish. No AC all the way back to work.
So, this evening I started the car with the hood up and watched. Compressor wouldn't engage. Pushed the AC button a couple of times and clutch engages. Compressor stayed on for 7 minutes and ice cold air. Clutch then disengaged and immediately both fans went to high speed for about 5 minutes with warm air out the vents.
Fans cycled back to low speed and compressor clutch engaged again for about 2 minutes this time. Fans to high speed again for 3 minutes, then compressor engaged for only a minute. Each time the compressor shut down, both fans would go to high revs. The minute they would go to low speed, the compressor clutch would engage and I'd get nice cold air..
Just had the expansion valve replaced and r134a charged by and AC shop last week. I have had the on/off AC problem for months and then could not get the compressor to engage at all for about one month. Of course, just as I was getting to the shop, it started blowing cold air.
Not sure whether I'm looking at an electrical problem or what. Just seems odd that both fans suddenly speed up and slow down and the compressor engages only on low speed.
The only other odd thing I've noticed is that cold or hot, as soon as I turn the ignition on (engine off), one fan continually starts cycling on and off. It does that continuously. I've checked the fuses on top of the battery and they all look fine. No appreciable drop in RPMs when the compressor engages. Fan control module?
View 7 Replies
99 Jetta, installed a new AC compressor a month ago, has been working great, not clutch will engage for a few moments, then turn off for a minute, then engage again. Seems, like there is Freon in there by the gauge on the low side.
View 4 Replies
