Golf IV / Jetta IV :: 2005 - Leaking Coolant Flange?
Jun 3, 2014
2005 jetta gli 1.8t automatic ( i know flanges are different from automatic to manuel) just recently found the leaking coolant flange. Can I change the flange without having to drain the coolant out of the system. my coolant is new because i recently had the timing belt/water pump etc done so its new coolant and i do not want to flush the system. also will i have to "bleed" the system if i just pull the flange of and replace it if that is possible.
View 2 Replies
Advertisement
I have a problem with my 2005 gti 1.8t , I had a issue with my cooling flange leaking, I changed it yesterday refiled it with g12 and distilled water took the car for a test drive about 20 min in see the temperature go up, no steam or water leaking any where, turn on the heat notice no hot air from the vents,turn on the ac no cold air, and the fans are not turning on. Everything worked the day before I did the coolant flange, am thinking is this possible because the coolant temperature sensor broke? fans will not turn on at all even if it overheating. If I leave the radiator cap off the coolant is spiting out of the overflow expansion tank don't know where to start looking for some pointers. Would bad thermostat cause the fans not to turn on?I think is impossible that the fans and the thermostat broke at the same time with the fact that everything worked the day before..
View 9 Replies
I have a 99 vw jetta the coolant outlet flange nipple became brittle and broke...its the smaller 1/2 size hose not the two larger ones. Not sure how much coolant actually flows thru there and want to know if i can drive it a couple miles to a shop without it hurting the engine. I believe it's bone dry but don't know and i didnt want to add water since it's 32 degrees COLD. Don't want the water to freeze. The part comes in this weekend ...how far can i drive , with water no coolant....(vw coolant is expensive).
View 2 Replies
Bought a used 2000 Jetta, 2.0L AEG engine by the looks of it, 188k miles. Previous owner told me he did a bit of work on it, and acknowledged the coolant leak - have to fill the overflow ball about once a week. He said he recently replaced the timing belt, water pump, and tensioner pulley. Not sure if that has anything to do with it.
From what I can see it seems to be leaking at the outlet flange (see pics of rust).
Would any of this cause the water in the overflow ball to be rusty yellow (see pics)? Should I just go ahead and replace the ball and then the o-ring at the outlet flange?
I'm new to VWs, but am up for a bit of work to make sure it gets to 200k miles (bought the Bentley manual).
View 19 Replies
I am looking at a 05 GLI 5 speed with 133k miles. I drove it yesterday and it runs fine, but I smelled coolant after I turned it off. I was told by the dealer that the turbo is leaking some, it was spooling while driving and didn't seem to do anything funny. The check engine light came on and said coolant was low when we got back, when I cranked it back up the light was out. Just not sure about it.
View 4 Replies
When my 2000 GTI VR6 sits for a week or two the coolant will run low. There are no leaks that I can find. No coolant in the oil. The crack pipe looks dry. Nothing from the thermostat hosing that I can see. The carpet by the heater core is dry. Nothing that I can see. The thing that is funny is I can drive the car with it 100 degrees outside in Georgia and have no problems with the coolant getting low, or any signs of a leak, smoke or smell. The head gasket and every gasket except the oil cooler and oil stand gasket were replaced about two years ago. The heater core was also replaced at the time. I gave the front pulled loose so I can pressure test the system and look more today.
View 1 Replies
Today I had planned on replacing coil No. 5 to rid myself of the rough idling and drive I've been experiencing the past couple weeks. Car is running smooth now, however, I've noticed again that coolant continues to leak at a fast pace on hot summer days.
I've always had a slight leak, about the size of a hockey puck or so if I let it sit over night. But once temps reach in the mid 80s-90s, like today in PA, the leak gets even worse. Pictured below is the amount of coolant that had dropped in about an hour span. I have attached an image and video of where I can see it dripping from. It looks like it may be a hose, but I can't tell if the coolant is just dripping on there initially from somewhere else, and then onto my driveway. I don't have a jack that I can get it high enough to check.
Car specs:
2003 VW GTI VR6 24V 98,000 miles
View 7 Replies
So over the weekend my 2000 jetta VR6 started leaking coolant and getting way to hot. So i parked it at work and eventually got it towed to a friends shop. I haven't looked at the car since then so bear with me on the descriptions I'm giving as they are just what he told me over the phone. I'm going to try and get to the shop in the morning to check it out some more. He says I have a leak in 2 hoses that look like they are just rotted out.
First hose he says "Comes from the back of the head and is about a half inch wide. it goes into a Y and then the top half goes into a smaller hose." The 2nd hose he says "on the top of the coolant bottle there is a line that goes across the back of the firewall then comes into a rubber hose and from that hose their is a T going into other places."
Obviously that's not a lot to go on. and when I'm looking at replacement hoses at shops online I'm not seeing ones that match these descriptions really. I've been looking for a diagram or some kind of illustration of these hoses so that i can send it to him and he can figure out which ones they are but I have not been able to find one.
View 9 Replies
Recently I started leaking coolant on the driver side area to the right of the engine:
I am assuming I need to replace some part/tubing that has a leak in it, but I am not sure what any of these things are called. How to identify what leaking part here is?
View 1 Replies
My MK4 Jetta started leaking coolant recently and I'm not sure where it would be coming from. I already checked the reservoir to see if it was leaking out of there but I could not find any leakage. I've found some coolant on the right side driveshaft near the differential, there is also some on the diff. I'm wondering if this could of happened because it has been sitting on a jack stand not being driven for about 2 months. Is it possible that within that time 1 or more of the coolant hoses could have cracked or anything. And while I'm on the subject of why it's on a jack stand, it also has gone through wheel bearings twice within the last 6 months to a year. Is this normal?
View 8 Replies
Yesterday i was cleaning my car and when I took it out from the garage i noticed a spot on the garage floor. Put my finger on it and thought it was oil but when i looked under the car it was red. It was a few drips on the oil pan and a few on the splash shield. I'm sure its coolant because i was missing some too. This morning on my way to school by serpentine belt started the squeal every time I let go of the clutch. Where this leak is from? My guess is that its leaking onto the belt making it squeal and slip. Its a 03 vr6 24v ...
View 1 Replies
when I bought my 2003 gti 1.8t it had a small exhaust leak, I decided to investigate today and found that the downpipe flange and turbo flange was rattling around, there's almost 1/16" of play and it's making a rattling noise. I can't tighten the nuts on the studs any more but that might just be from them being seized in place. I'm getting a new gasket and studs and nuts and hopefully that will fix it?
View 3 Replies
I've got 149,xxx miles on my Golf TDI. Took it by a local shop for a routine oil change and since then, it's just been puking oil from the oil cooler. I took it back to the shop and the mechanic even pointed that out. Some red flags here; Timing is too shady. This happened literally the day after the oil change. He also told me that he won't use customer-supplied parts for liability reasons. Seems believable enough, but why would this part just choose to go wrong now?
This is my first time at this shop too and I've never really dealt with "bad mechanics" before but something about this isn't sitting right with me, and I'm not sure how to handle my next step properly. So what would cause an engine oil cooler to leak profusely just after an oil change?
View 1 Replies
its cracked and its leaking i was tld its 210 dollars to replace it... what is the part number for this??? or is this not that bad of a deal?
View 2 Replies
I think its a flange that connects to hoses, they want to charge me 140 to repair. would this be something i can do myself?
View 5 Replies
The TigWig runs great, tonight on my way home from work the MFD tells me to stop and check the coolant level. I stop and check the level and it is below minimum but still some in the expansion tank. On the trans side of the engine there is coolant on top of the transmission. I return to work to top off the coolant, everything is back to normal. The temp gauge never exceeded normal operating temperature. Half way home low coolant warning is displayed again. Temperature still never above normal. I top off the coolant again. It seems the Tiguan is burping coolant out of a flange or sensor port. It burps and then reseals. Mileage on the TigWig just hit 148k.
View 6 Replies
My wifes car started leaking gear lube in the driveway. I traced the leak to the passenger side output flange seal. At first I thought the cause was a bad CV joint but when I tried to shake the axle, I noticed the whole flange moving...How can this be repaired? Does the whole tranny need to be removed or just the output pod?
View 4 Replies
The dipstick tube flange is now leaking ....
View 3 Replies
Our 05 Elantra (170k miles) is leaking coolant externally from the head gasket. At first I thought it was coming from the freeze plugs, but it's actually leaking from above. I'm mechanically inclined but have no experience with head gaskets. I have access to Alldata but no service manual. Will it tell me everything I need to know? The farthest I've gone inside an engine is removing valve covers car runs great and we like it enough to want to keep it for a while ... I'll also mention I will be replacing the timing belt as well.
View 7 Replies
Okay so recently I was driving my 2000 Jetta and the coolant temp light came flashing on, when I went to check the coolant I was surprised to discover that it was like a mud brown color, almost looks like peanut butter. From everything I have read this can be from a few things, either rust build up that is gunking everything up and oil getting into the coolant somehow. I'm pretty sure its rust build up but I was wondering what everyone thinks about this, I was also not using G12 coolant which I'm told now is the premier brand for VW's.
View 3 Replies
Ok, I own a 1990 Volkswagen Jetta GLI that I bought from my neighbor about 4 months ago, and recently, it started having problems. It's idling very high, around 1,500-2,000 rpms, it's leaking coolant, not from the bottom of the reservoir but from the top, and it's slightly overheating. Oh yeah, the speedometer stopped working. I've recently taken it to the shop twice, the first time to get the reservoir replaced, and the second time to get radiator replaced.
I have had problems with it stalling in the middle of the highway during traffic because it over heated. I commute daily to and from college and I want to make this car last as long as possible as I do not have the means to buy a new car. I have noticed that there seems to be a build up of air in the reservoir. I witnessed it leak, and there was a hissing sound coming from it. Also with the speedometer, the light doesnt turn on for it and that there is a clicking noise coming from it. Any tips?
View 5 Replies
