Golf IV / Jetta IV :: 2004 GLI Randomly Misfiring After Exiting The Freeway
Sep 2, 2015
2004 gli , 1.8t , 136k , 6 speed
The car started misfiring after exiting the freeway, at the light it felt like it was gonna cut off. The brake pedal is stiff like the car is off. When it's idling is when it's most noticeable. It smoothed out after 2nd gear at like 35mph but still not right. The pedal thing has never happened before but I knew the sputtering was the coils, so I had it scanned and sure enough. 5 codes.random misfire.. random misfire all four cylinders.. so I bought 4 and replaced the old ones.. Changed the Sparks as well. No change.. The cel came back on..still idling rough.. What it could be.
View 5 Replies
Advertisement
So I have a 2004 jetta GLI (1.8T) with forge splitter valve and short ram intake. I went and got my codes pulled and all 4 cylinders misfiring and random misfires. I replaced both coil packs and spark plugs. check engine light popped up again after about 20 miles and same thing. I just bought the car so I'm not sure how long it has been running with these misfires. I just got the timing belt replaced. I know it could be off a tooth. (Wouldn't a code pop up though for it?) How could I check that. And I also took my MAF sensor off as well and no change. Heard it could be clogged cat, any way to check? I've also cleaned the throttle body. It runs fine when I'm driving, just a rough idle.
View 15 Replies
Every once in awhile when I'm on the freeway, the hazard lights will flash and the doors will lock and unlock for about 3 seconds then stop.
The car is running normally other than this, except that the doors have stopped locking with the fob or the key itself. It is a 2001 2.0L L4 SOHC 8V.
View 1 Replies
I finally drove the Celica for the first time to work after rebuilding the front end. As I was exiting off the freeway the car suddenly stalled. I coasted into the lot and tried to restart. The car struggled to restart and when it finally restarted it ran extremely rough with a lot of metal on metal clatter. I tried to drive it to the other end of the parking lot and the clatter got worse and worse. Sounds like the contents of a tool box in a paint shaker.
It's always run great prior to this. The only thing that seems to have changed is the work I did to the front end and the replacement of some seals on the timing chain cover. The car still has oil but I can see oil splatter on the bottom of the distrubutor. I'm going to have it towed home in the morning.
View 2 Replies
CEL came on and the report says #2 cylinder misfiring. Changed plugs, wires and coil. Last step was to change the #2 fuel injector. I changed the 2nd injector from the left but I'm still getting the same message. I was wondering if maybe they aren't numbered that way. It's a 2004 Jetta with Car engine: 2.0L L4 SOHC 8V. Did I change the wrong injector?
View 1 Replies
For some stupid reason, my truck decided to lose power today when exiting the freeway. D/s egt gauge verified it with no increase in temp when stepping on go pedal. After about a minute, I could feel it gain power. So, rolled into fuel station, and topped off tank. While filling, I popped the hood and started messing with the uvch and looking around. It was then I noticed that darn hose riding on top of a ton of wires. Pulled said hose up and sure enough, a wire is shafed clean off of insulation. Anyway, something to check while looking around under there....
View 4 Replies
I'm getting used to just expecting a problem with this car every 3 months or so. Anyway, I have a 2004 1.8T GLI which lately has been idling and then stutters and dies. The first time it happened it turned right back over and started driving. So I drove it home and cleaned up the battery terminals and it didn't seem to have a problem since. Now about a month later I was just parked and turned it over.
It was on for about 1 second and then it stuttered and died. I can hear the starter engaging and turning the engine, but it won't turn over. I also checked the battery levels and its showing 12v so I don't think it's electrical? From scanning forums here it seems like the two prime suspects are spark plugs or the fuel pump?
Also checked the fuses and none are burnt. I could see it being the fuel pump because that would explain it randomly stuttering and dying. Also the car is at 149k miles and that is the original pump. Wondering if maybe it being at 1/4 tank isn't working either? Going out to buy a vagcom and see what codes it throws!
View 2 Replies
04 jetta 1.8t
apr tune 1.6v
neuspeed 4bar fuel pressure regulator
3" turbo back
APR TIP
This is the second time this happened to me. First time was about two weeks ago where i was just driving and the car stalled. Tried to start but it sounded like it just wasn't getting fuel. Brand new battery, terminals are clean) Got it started and it was revving high like a cold start, normal but why after driving for 30 mins? EPC light came on also which was strange along with the CEL, a buddy checked the code and it was for the secondary air injection pump. (I have not had that go off in a while. Code po4011 secondary air injection. Had this issue a while ago with that code when i did a short ram intake. Tuner cleared it so i can pass emissions. ) Now today it died about 2 miles from my house. Same thing but no CEL. EPC light came on and car was revving high, luckily 3 cars behind my buddy was there and he give me a push into the gas station. Once again it wanted to start but i felt like no fuel. waited a few minutes and it started right up again until it almost died in my drive way. Cluster comes on when it dies. ignition is good.
My big question is the stalling part and the EPC light coming on, then the car revving like it is a cold start but not stopping? and i need this car to be working.
View 11 Replies
I have a 2004 Jetta 1.8t. 160k miles. Bought it recently. It's been overheating on me. Mainly on the freeway while having the RPMs higher than the small streets. I don't see any leaks. I'm not losing any coolant. But I do smell burning coolant. I don't see anything smoking though. I changed out the coolant temp sensor. I have a thermostat but haven't gotten to it yet. Just wanted other opinions before moving on. There is some sort of little motor on the radiator with some coolant hose connected to it. When turning off the car, it stays on and buzzes for a good 10-15 minutes before stopping. I'm not sure if that has anything to do with it. I don't even know what that thing is or called.
View 14 Replies
I got an 03 vw gti. I was driving to work and car just shut off and hasn't start ever since. Check my fuses and relays there all good. I thought it would be my fuel pump so took the old one back to auto parts and got a new one. That didn't work. I also just replace my crank sensor cause my car won't crank at all, but it back fires after the first attempt to start it and i did some research and ppl had that same problem and said it was the crank sensor but that didn't work either.
View 6 Replies
I am having a recurring problem, My engine keeps misfiring. I have replaced the spark plugs, ignition coils and pcv valve with all new parts and and fixed it for a little bit but now my car is misfiring again, and Im hoping its not the head so need to narrow down what the problem is...
View 1 Replies
So leading up to today ive had some bucking under load which felt like misfiring to me. I borrowed my friends VCDS cable, checked MAF, checked o2 sensors, checked cat. They are all good. This problem is constant but i did get a misfire code once (random, cyl 1, 2, and 3). I cleared the code and they never came back.
Today as im driving home from work, the bucking problem was much worse. Then the CEL came on. I just checked the code, and it was system too lean. I cleared the code and now the car will not start. It cranks, shows rpm on VCDS and sputters but doesnt even come close to starting.
View 10 Replies
1995.5 Jetta VR6
Misfire cylinder 1 and random misfiring
P300 P301 Vagged it and can't figure it out
Changed the plugs, wires, and coil pack Used and old timing light and getting spark in all wires so can't be the coil pack
Fuel injector, O2 sensor, any other things?
View 4 Replies
Why my 2004 Jetta 1.8T Stalls out while Driving? It usually happens while on the Freeway, 60-70 Mph, I Coast to the Shoulder then it starts back up again...
View 3 Replies
I have a 2001 golf with a 2.0 AVH engine. I recently replaced the coil-pack and was very pleased that the engine was running better, the only problem was the mpg was still kinda low in the 24-5 range when it used to be 29.
I tried to do a compression test but I didn't prepare properly, I thought you left the coil pack plugged in and the fuel fuse. Now I have a CEL that *was* flashing saying cylinder one is misfiring though it has stopped flashing. I drove it 13 miles home and it did improve but its still running rough. Very reminiscent of when my bad coil pack was still in there, a real lack of power.
So I have to ask, what can I do from here? Have I damaged my coil pack or cylinders? Will this likely go away on its own? Is there anything I should do?
View 4 Replies
Is it possible that disconnecting battery causes a misaligned throttle body, which in turn causes the EPC light to come on? And does a misaligned throttle body also cause misfiring cylinders (1 & 2 in this case)?
View 3 Replies
I recently bought a 2000 jetta vr6 MK4 and since i have had it its had a misfire problem. So its saying that its misfiring in "cylinder 1" and sometimes when I clear the code it will stay off for the whole day. I did everything I could think of. I replaced all the spark plugs. I replaces the plug wires. Then i bought I new coilpack. and its still misfiring.
View 10 Replies
I'm getting misfiring after the engine is hot, but it only shows up under certain load. For example, if I'm in 3rd gear at about 2500 rpm and I give it some amount of throttle, it wont misfire at all but if I give it just a hair more (maybe past 50% or so), it will start misfiring badly and the blinking CEL comes on. The codes it's triggering are misfire on cyl 1 and multiple misfire.
I replaced the coilpack about 6 months ago, that's why I'm hoping for some feedback before I drop a few hundred dollars on another one. I had the plugs out very recently and they look fine. The shape of the wires are difficult to get multimeter probes on so I haven't checked them.
View 16 Replies
OK so here's the deal. Driving around town @ lower speeds I've yet to have this problem. When driving at freeway speeds seems like between 1/4 tank & reserve all of a sudden the power just drops off . I mean like the ignition has been turned off. No throttle response .. nothing..... just begins coasting & dropping speed. When throttle is depressed... totally dead. This lasts for about 5-10 seconds then after coasting & looking where to pull off the highway all of a sudden the engine kicks back in like nothing ever happened. Where to look for Jetta MK 4 18T Fuel supply problem??
View 4 Replies
2002 Jetta 1.8t, auto tranny, 90K miles. Recently took it in and had all coilpacks replaced under VW's recall.
Sometimes when it's been sitting out in cool air for a long time (in Texas summers, this is nights-only), about 3 miles in it suddenly starts misfiring- BAD. Check Engine light comes on. Lasts about 30 sec, then goes away and doesn't come back for the rest of the drive. WTF?? I can't make it happen on queue.
I heard about the all-too-common grounding problem on the engine harness. I did find a significant resistance between the ring terminal on the head and the battery (-). I tied the 3 ground posts under the battery together with 12ga wire and crimped terminals, and ran another 12 ga wire up to the engine block ground right under the ring terminal that grounds the coils, which should have shorted past any weak spot on the harness. PROBLEM STILL OCCURS!
Scans showed:
17766 Cylinder 2 Ignition Circuit: Open Circuit
16682 Cylinder 2 Misfire Detected
16684 Random/Multiple Cylinder Misfire Detected
17658 Low Fuel light (only ~3 miles after lighting the Low Fuel warning, I don't think the fuel pump's running dry just yet here)
Seems to focus on Coil 2. But last time I did this I got these errors for Coil 3 and swapped it for a new replacement I had in the trunk in case one went out unexpected. Well now it just says Cylinder 2. Just did it again tonight after clearing codes and got these same Cylinder 2 errors again.
Actually I started to wonder... I've been running the tank close to the "low fuel" light to check my actual mpg usage (no display for it in my MK IV), but fill back up a few miles after it lights. I can think of a couple of spots on the late-night drive back that I see this, one's after a hill which might cause a fuel pump to run dry temporarily, but another's a light downhill then up a light offramp. I don't think the tank's been low every time this happened but I'm not sure. Well, a couple of times it's been mostly level in the parking lot anyhow and misfired a bit right off the bat when starting, so probably not.
Wouldn't there be some sort of "low fuel pressure" code if fuel starvation was actually the issue going on? Hmm, I went looking and I'm not sure there is one for a MkIV, there's errors for fuel trim but I don't think you get those in short-term. This is kinda scary how it just goes out while driving, and I can't do much to reproduce it or test out fixes.
So looking further, other people report what may be intermittent fuel pump issues when the tank goes low. But could that result in "Cylinder 2 Ignition Circuit: Open Circuit"? I mean the coils will still electrically read as firing. Of course if the system gets all glitch-y, the software may be making a mistake somewhere and report this wrongly.
View 4 Replies
I'm having a misfire issue on my 1.8t. When I go into high boost I'm getting bogged down and misfiring.
I plugged in my obd2 adapter and it gave me a misfire on cylinder 3. I since cleared the code to try and see if it was a coil pack by switching it to another cylinder, but now the cel won't come back on although the problem persists.
I have recently changed the plugs and the car was fine. I then added a fuel injector treatment and the misfire started shortly afterwards. (coincidence perhaps). It's frustrating as I can't rule out coil packs as my cel won't come back on and my code reader is not displaying any faults.
I did previously have a cel with something about fuel trim bank 3? I am also sure I have a boost leak as the car whistles pretty loud under boost.
Also worth mentioning I have a bit of white smoke sometimes but I'm not using oil or coolant and they are not mixing either. I'm at the end of my tether with this car and just want to try get it back to normal.
View 24 Replies
