Golf IV / Jetta IV :: 2003 - Replacing Sunroof Drain?
Oct 24, 2014
My 2003 Jetta sunroof drains aren't clogged. Nor are they simply cracked. They don't seem to be connected. I tried snaking them out with trimmer line- the thing took like 15 ft of line without resistance, from either end. I suspect they had a mechanic who tried to use compressed air to blow them out, and may have blow the line off its nipple instead.
So I can't install a new, smaller line inside the old one. There's no way to fish the line from one end to the other.
I'm doing the headliner anyways. I can replace them, but I need to know what type of tubing is actually used. Plus, how that tubing would go down the A-pillars and meet up with the rubber nipple? Can that thing be pulled out from the outside of the door jamb?
View 8 Replies
Advertisement
Fiancee's 04.5 GLI is leaking from the sunroof drain into the front passenger footwell.
The Tubes are clear, but the front passenger drain is leaking from the upper portion of the tube. I pour water down the drain and 90-95% comes out the door nipple. The other 5-10% comes down the Pillar, and then out the bottom of the glove box.
I know its coming out of the top of the drain, not the nipple at the door because I can visually see water drops inside of the pillar.
What if I make a small plug to close off the 1 corner of the drain? I understand the correct solution is to pull the headliner and reconnect it.
BUT with the holidays and chaos of this week, would a temporary solution be to close off the 1 hole? I'd do a small delrin or aluminum plug with an oring on a lathe real quic so its a water proof seal
OR if I plug it, will the water level rise too fast inside the sunroof and pour into the car? I don't know.I think the plug would be a safe solution.....
View 2 Replies
In the past week, my car battery has died twice (Sunday morning after sitting for 45min and Friday night after sitting for all day). The car (2003 Jetta) immediately came back to life once the jumper cables were attached to another car. I've had the battery and alternator checked twice both with good results. I've checked for a drain on the battery while the car is off, and I'm getting 20mA. So everything seems to be fine. Why the battery could have died twice? Is it possible that something is turning on at random and sucking the power out of the battery?
View 1 Replies
There was a really good write up on how to go about replacing the sunroof drain line on the forum, yet I'm having troubles finding it. Been using the search function for the last hour with no luck. Finding the write up I'm referring to? I do remember it has an odd post title.
View 3 Replies
2003 Jetta TDI GLI , fuse number 32 (30 amp fuse) keeps blowing immediately after I replace it. I can't start my car because of it. I do have a shorting head light and the glow plug indicator flashes with the check engine light on. This doesn't happen all the time. When it does happen, sometimes the accelerator will not work and instead of idling at ~900 rpm it idles at ~1100 rpm. I usually just restart my car and then it works again. Not sure how these issues are related but I can't start my car because of this blowing fuse.
View 2 Replies
2004 Jetta 1.8T
Looking for the drain plug and I can't find it for the life of me..
There is a hex bolt on a black plate that is seemingly the lowest part of the whole front-underneath, but this isn't the oil, is it? It does have a washer, that hex bolt.
It's in front of the axle, right?
Which direction does it face?
View 24 Replies
As stated above, where are the rear drains located? Do I have to remove the rear fender?
View 4 Replies
I narrowed my battery drain to the box on top of the battery. When I disconnect all three fuses and the 4th wire from inside the box my draw goes to 0 but when I connect any of those 4 it will go back up. Connecting all of them will not increase the draw any more but it seems all of them are connected in some way?
View 3 Replies
So i noticed i am leaking oil, not much but enought that i will have to top it up before the next oil change. The drip comes from the drain bolt, and drips off the bottom of the oil pan right under it. I have replaced the bolt and it still continues to leak. What could be the cause of this?
View 1 Replies
So I want to remove a sunroof cover from a GTi that's being parted out but the problems are there is no power in the car. I know that you need to be able to tilt the sunroof up in order to remove the cover. So, is there any way to do this without power?
View 6 Replies
2004 GLI ... Venting opens but when I turn the knob to open the sunroof completely, I can hear and see that it wants to open but it stays neutral and wont open up. I attempted the manual crank. Again, I can get it to vent manually, but when I turn the allan key the other way to fully open the roof, it will go as far as moving just below the roof line, but it will not continue to open. I'm concerned if I crank on it too hard, something will break.
View 2 Replies
Trouble shooting my sunroof. When I first go the car the sunroof would open but not close, even when I pushed in the button to reset.
I have replace/ and calibrated replace the switch now I get the fallowing.
When I put it to open all the way, it goes in to vent mode ( the back opens up), ( when i put it close it closes fine).
When i put in vent the sunroof slide back 1/4 of the way. when I try to close it closes and opens back to 1/4 open. I have to close it and press the button in to close it.
View 2 Replies
Is the sunroof drain supposed to drain into the trunk? Check out this pic:
Is the Tube supposed to be going where that plug is? If so, is there a specific Toyota plug part number I should use?
View 8 Replies
On my 1.8t jetta she is leaking coolant slowly. Just started when it got cold out. It is dripping down the oil pan right down the center. It is falling off the oil drain plug. Was reading that it could be the water pump leaking but then it wouldn't be in the center of the pan. Got it jacked up now so here are some pics.
View 6 Replies
So I bought my 03 golf 2.slow about 10 years ago used and it came with a moonroof... not a sunroof. I never really thought about it and just assumed it was a option from the factory but the seals have been leaking lately and I was looking for a replacement seal and could not find anything only sunroof parts. Is this an aftermarket moonroof where they cut a hole in the roof and added this?..I really hope not. Or did someone take the sunroof assembly out and put this in its place.
View 3 Replies
Have a sunroof that rattles when closed while going over bumps? I use my fingers to lift up on it and its barely budging, also floors are soaked....
View 3 Replies
last weekend I was closing my sunroof and it went all the way shut, then started going back, just like your garage door does if you leave some stuff blocking the door. I stuck my hand in there and whisked around to see if there was anything blocking it but found nothing just dust. I didn't look closer because I was going down the highway 75mph at the time. Them the issue went away by itself and I left it shut.
View 6 Replies
The sunroof drain clogged on my '02 Passat and caused major damage to my electrical system. Its at the dealership being repaired and insurance does not want to pay to have carpet replaced. They will pay for the padding but not the carpet, the problem is they say the carpet and padding are one piece and both would have to be replaced. I am worried that if all it is not replaced I will have a stinky moldy smell in the middle of summer.
View 9 Replies
I own a 2002 GTI and my sunroof was damaged beyond repair.
A local headliner shop had a used 2004 Jetta sunroof which he sold to me. The shop owner said everything was in working order with the sunroof except the wire harness that runs to the sunroof was missing the plug since it was cut. He recommended just taking the plug from my GTI sunroof motor and soldering it onto the Jetta motor since it may throw off the "timing" of the sunroof motor and would need to be recalibrated if removed. Keep in mind he is an authorized Webasco dealer so I took him at his word.
I cut my plug off of my GTI sunroof motor harness and began to solder it onto the Jetta sunroof.
I quickly noticed the Jetta sunroof motor had one extra wire (Brown). I didn't think it would be a big deal since my GTI doesn't have 6 wires and only requires 5 so I mounted the new sunroof with the Jetta motor onto the car.
The sunroof retracted back into the "fully open" position and would close but would not go into the "vent" position. Each time I would turn the dial to the "vent" position, the sunroof would slide back into the "fully open" position.
I thought this was a bit strange and now I am beginning to wonder if I need to swap the GTI sunroof motor on my car due to it not have the extra wire or is the Jetta sunroof motor going to work fine but another issue is causing this to happen?
Below are the differences in the two sunroof motors. Both are Bosch products.
Jetta Sunroof Motor - Part Number : GDO 849 696 564
This part has 6 wires that connect to it.
White, Green, Gray, Blue, Purple, and Brown
Where as the GTI has only 5 wires on it.
GTI Sunroof Motor - Part Number : GDO 849 696 566
White, Green, Gray, Blue, and Purple
The difference between the two is the additional BROWN found in the Jetta sunroof motor.
View 4 Replies
Are the bolt and nut holding the strut to the wheel bearing housing the only things that need to be replaced when removing the strut? Anything else I should change while I'm in there? So far I'm just doing 034 strut mounts and bearings.
View 3 Replies
My sunroof opens and closes correctly. but when in the closed position it will be sunken into the cabin of the car a few MM not sealing to the body of the car tightly. how do I fine tune the sunroof to sit flush with the body when closed? some kind of adjustment screws?
View 4 Replies
