I was recently driving home when I made a left hand turn and the car died. I had the timing belt and water pump replaced 1,800 miles ago. It sounds like a timing issue to me. The last time I had timing issue it wouldn't run. This time it runs. Attached is a video of me starting it with the camera looking at the timing belt. The noise I heard made me shut it off. I did not want to cause more damage.
[URL] .....
I have an '02 GTI VR6. It died on me on the freeway after surging then limping to a stop and wouldn't restart. I replaced my fuel pump 5 months ago and now I suspect that it has died again, but I want to be absolutely sure that the pump is the problem before I replace it again.
Last time the car would sometimes hesitate in 1st and 2nd for a couple weeks before the pump actually went bad. This time it seemed fine for 5 months then just went out.
The pump does not prime when I open the door. I checked fuse #28 and it's not blown, but there doesn't seem to be any power to it. I tested the power to the fuel pump connector. When I turn the key on I get ~12v for a split second then nothing. While cranking the engine I get ~9v constantly. I hooked a square 9v battery straight to the two outside connectors on the pump and nothing happened.
Can I be sure that the pump is the only problem? Obviously it's dead, but is there any reason for fuse 28 to not be getting power? And should the connector only be getting power for a split second when the ignition is turned on? I tried a different fuel pump relay with no change.
I was driving down the road when my car (02 GTI 12v VR6) suddenly died. I pulled off and tried to restart it. It sounded weird, kind of metallic like maybe the clutch went out. It seemed to be firing, but would not turn over so I stopped trying for fear of damaging something. I thought the timing chain may have come loose, however I didn't hear anything catastrophic like valves breaking so if that's the case then hopefully it only jumped a tooth or two. I scanned it and a bunch of codes came back. I did have the battery out for a while before scanning so I'm not sure if some of the Central Convenience codes are due to that or not.
Here's the full scan:
VAG-COM Version: Release 409.1-S
Chassis Type: 1J - VW G/J/B Mk4
Scan: 01,02,03,08,16,15,17,19,22,35,46,56
[Code] .....
What happened to my 02 mk4 Jetta after start up and engine failure.
I started the engine, and noticed a high squealing sound just like a loose fan belt, as I backed out my driveway the Battery light came on and engine died, when I tried to re-start the engine it doesn't make any cranking sound just a whirring sound.
I drive a 2002 Jetta with a turbo engine. In the past 2 months, my car has 'powered out' or shut down while driving - I can't accelerate, it is hard to steer, doesn't really brake well and although the dashboard lights remain on, my car dies on me. So far, I have been able to restart the car with little problem and she usually starts on the 1st or 2nd try. My dealer/mechanic had the car for a day, test drove it numerous times, checked the computer, battery, connections, etc. and can find no reason for this behavior. The last time this happened, it was raining outside; I don't remember what the weather conditions were the first time this happened. I have kept the car well maintained throughout the years.
View 3 RepliesWhy my 2002 Jetta 1.8t does this?
After I drive for a while I have to [slowly] open the overflow cap and relieve pressure in order to not lose coolant while the car sits. It steams for a bit when I open the cap and then the coolant rises in the reservoir then I close it.
If I don't do this then the car loses coolant but I don't see any leaks visible under the car.
Ok, so I was driving normal highway speeds and all of a sudden, I realize a major drop in power. I pull over and restart it and it changes nothing. Now when I floor it, it takes 20-30 seconds to get to 90K.
I checked the air filter... Nothing. Used a code reader... Nothing. Then I decided to pressure test the cylinders... Nothing, except now the check engine light is on.
The Ol Dub is still drivable, but it is extremely slow and rough at idle. I am thinking it might be a MAF or fuel filter.
I have a 2002 jetta 1.8t that overheated on me out of no where i have read some post and couldn't really find what i need it never overheated on me before and this was the first time and when ever i open the reservoir where you put in coolant everything spills out its my first time owning a volkswagen, it happens as soon as i start driving like 30 secs and temperature starts to rise.
View 3 RepliesSo I'm on my way out of town, when the truck just doesn't feel right. I proceed to make a u turn and pull off the high way. During the course of the u turn the truck shuts off. I pop the hood and notice the oil is everywhere from the fuel bowl back. Oil is also dripping off the passenger frame rail.
There is also a nice size puddle of oil pooled under the truck. I believe that I blew the high pressure oil line that feeds the injectors. I had to get towed back home. If it is the high pressure hose, how much does the stealership normally charge?
I have a 2002 f350 dually with a 7.3 and 197k. At 186k it died while driving and I had it towed home. As soon as the tow truck dropped it the truck fired right up like nothing was wrong. Then it died again 2 days later. I replaced the cps, but the fix was replacing the icp and pigtail. Now it is doing the same thing again. It died on my wife while driving yesterday, i had it towed to the dealership I work at and it started and ran for about 2 hours with no issues. I hooked up the factory IDS and had a diesel tech look at it with me. The oil pressure, injector circuit and injectors, and IPR all look good. The batteries were a little weak so i replaced both of them. I drove it home yesterday, about 10 miles, and drove it around town today. Then i tried to jump start my 96 bronco and after about 10 minutes of running it sort of hick uped then 5 minutes later it died and would not start. I let it set for 30 minutes and it started and died after about a minute.
View 2 RepliesI have a 2002 f350 dually with a 7.3 and 197k. At 186k it died while driving and I had it towed home. As soon as the tow truck dropped it the truck fired right up like nothing was wrong. Then it died again 2 days later. I replaced the cps, but the fix was replacing the icp and pigtail. Now it is doing the same thing again. It died on my wife while driving yesterday, i had it towed to the dealership I work at and it started and ran for about 2 hours with no issues.
I hooked up the factory IDS and had a diesel tech look at it with me. The oil pressure, injector circuit and injectors, and IPR all look good. The batteries were a little weak so i replaced both of them. I drove it home yesterday, about 10 miles, and drove it around town today. Then i tried to jump start my 96 bronco and after about 10 minutes of running it sort of hick uped then 5 minutes later it died and would not start. I let it set for 30 minutes and it started and died after about a minute.
I have a 2002 f350 dually with a 7.3 and 197k. At 186k it died while driving and I had it towed home. As soon as the tow truck dropped it the truck fired right up like nothing was wrong. Then it died again 2 days later. I replaced the cps, but the fix was replacing the icp and pigtail. Now it is doing the same thing again. It died on my wife while driving yesterday, i had it towed to the dealership I work at and it started and ran for about 2 hours with no issues.
I hooked up the factory IDS and had a diesel tech look at it with me. The oil pressure, injector circuit and injectors, and IPR all look good. The batteries were a little weak so i replaced both of them. I drove it home yesterday, about 10 miles, and drove it around town today. Then i tried to jump start my 96 bronco and after about 10 minutes of running it sort of hick uped then 5 minutes later it died and would not start. I let it set for 30 minutes and it started and died after about a minute.
Driving home on the highway today, not boosting, just regular driving. Car was acting fine, then just shut off. Tried starting, and it would crank, but not actually start.
Got it towed home. Scanned. Two codes: 01314, Engine Control Module. And again, 01314, Engine Control Module. Tried clearing codes, and it says "comm. error". Im using the VAG Check scanner from ECStuning, has always worked fine.
Thought it could be fuel pump, but the fuel pump primes when I open the door. I did notice that the throttle body refuses to align when I put the key in the second position, when it always has before. Radio works, all presets work. Unplugged the battery for a half hour, replugged, nothing. I'm leaving it unplugged overnight to see if that does anything.
Previously, I have had no rough starts or other starting issues, and no issues with my battery, which is 4 years old. I left work and had some errands to run--started my car, drove about 1/2 mile. Started my car again, and drove about 1/4 mile. Started my car again, and drove about 2 miles and stopped at a gas station. Started my car again and drove 2.5 miles.
This time, my car started fine, and I began to take off (moving forward--no car in the space in front of me) and after about 5-10 feet my engine died. I haven't been able to start it since. The starter is turning well, but I don't hear anything firing, and giving it gas as I hold the key over does nothing.
Where should I start? I have a video of trying to start, I may try and upload to Dropbox and post. Car is a 2004 Jetta GLS with 247k, and I currently have no DTCs stored (checked using a generic OBDII scanner, not a Vag).
I have a 2003 Golf VR6. Last weekend the car started sputtering and then died. I haven't been able to get it restarted since. I have already replaced the fuel pump relay and the fuel pump. Since I replaced the fuel pump it will prime when I open the door or when I insert the key. When I go to start it it will only stay running for 5-10 seconds then acts like its running out of fuel and dies. EVERY. SINGLE. TIME.
Its not throwing any codes other than a couple 02 sensor codes telling me its running lean. What to do at this point. I was told that vws have a secondary fuel pump relay under the passenger rear seat that sometimes when it goes bad it will turn on the fuel pump to prime it, but wont kick on when its supposed to stay on. I cant find anything on the interweb about it. The shop I took it to that diagnosed the fuel pump said it wasn't throwing any codes when they scanned it.
Been the proud owner of a '04 Golf for a few years but it hasn't been without its share of hiccups. I recently had my battery die on me. Got the car looked at and apparently the alternator was the culprit, ie, it wasn't functioning and re-charging the battery. Swapped out the OEM for a rebuilt Bosch 120A (my car is a 2.0GL, so it's supposed to be 90a default, but I looked online and saw that I could use the 120). Even put in a new battery as the old one was past its prime. Now the new alternator (which was not fun to install) isn't working either. I had a different mechanic look at it and they said that while the auto shop gave me the right part number, that apparently VWs are hinky with aftermarket parts and I'd have to take it to a VW dealer for a diagnostic? Makes no sense as I've seen tons of people online who've used aftermarket alternators with no problem.
So now the car essentially is dead in the water. Battery light comes on when the car is started and I'm not tempted to not drive the car anywhere out of fear that the new battery will die in mid-traffic. I've checked the grounds, pulley, etc, everything looks fine and connected proper. What could be going on?
I'm running into a brick wall trying to get my GTI to start. This post is my last-ditch effort before just towing it to a shop.
A little over a week ago, the car just died while idling outside a buddy's house. Prior to dying, it had been having some sputtering starts and had been dying while driving as well (engine cut outs) for about a month, but it had always started right back up strong after cutting out.
First I tried replacing the crank position/engine speed sensor. No dice, still not starting. I had new spark plugs in the toolbox so I popped them in, still nothing. Then I realized that my spark plugs were totally dry when I changed them. I pulled the hose off the fuel rail, tried to start the car, no fuel. I had a more mechanically inclined friend come out with a multimeter and he checked my fuel pump and relay. He tells me the relay is good, but the pump must be fried because it's getting power but not pumping (I'm not certain of this as I didn't physically lay eyes on the multimeter when he told me this). The next day, I replaced the fuel pump and the fuel pump relay just to be safe. The car started! I thought I had it all figured out. I drove the car for two days and then, last night, it refused to start again. This morning, pissed off, I went back and was ready to tow it but it started right back up again on the first try. I drove it home, but then later when I went out to go grab a burrito it wouldn't start again. It cranks and cranks but just won't catch.
Pertinent information:
- I do have a CEL. Don't remember the exact code it's throwing but it's something like "Engine distributor circuit, no signal." The code cleared after installing a new fuel pump, but the CEL is back now. Could be a new code, though as I don't have a scanner.
- No other nasty dash indicators are on.
- With the new fuel pump, even when it was working normally, I never heard the usual "priming noise" you get when opening the driver's door. This is strange to me as I used to hear it all the time.
- The car cranks normally but I think it just isn't getting fuel, even with a brand new pump, plugs and relay.
- About a year and a half ago, the coil pack was replaced under the recall campaign.
After all these new parts, I'm thinking electrical. A ground short or something. But I've seen that for some people it was the ignition switch, or the IMMO, or the fuel injectors, etc....
My k03 blew up after 100k miles in a cloud of smoke and oil... Where is a good place to buy a k03 turbo for less than $900 or so?
View 2 RepliesOk so I started car ran for about 15 min at idle but ran rough a few times then died now wont start. O yea I drove it on sunday and the speedometer and odometer stopped working also.
View 2 RepliesI recently purchased a 01 1.8t GTi with a blown timing belt. I got the car rebuilt, did all maintenance work like brakes , hub/bearings, bushings, oil and all the good stuff that goes into getting the car back up and running. I've finally started driving it and I'm having a weird issue.
Yesterday , I stopped at a red light and the car randomly died on me. Pushed it off the road and checked things out but I couldn't see if there was anything wrong but about 10 minutes later , I was able to restart the car and drive home. Now today , on my way home from work the car starts back firing and I lost all power and rolled to the side of the road where he car would just continue to crank. I was able to get it restarted but it cut out again a couple seconds after. I don't have my code scanner but I know I do have one lean code for something. Maybe cause I have a leak between turbo and dp. I don't have access to vagcom unfortunately..
The other night I was coming home from work in my 1999.5 MKIV 2.0 Golf (Only about a 2 mile drive), once I got to a stop light my car just turned off. No loud bang, no sputter then die, just off (Like I turned the key). After trying to start the car with just a click, pushed it into a nearby parking lot with a friend steering. Once in the park lot we tried bump starting the car (it's a manual) with nothing the car sounding like it wanted to go but never did. The next night I pushed it back to my house, pulled the starter and the battery, and had both of them tested. The starter extended and spun up fine and the battery was in excellent shape.
View 2 Replies