What happened to my 02 mk4 Jetta after start up and engine failure.
I started the engine, and noticed a high squealing sound just like a loose fan belt, as I backed out my driveway the Battery light came on and engine died, when I tried to re-start the engine it doesn't make any cranking sound just a whirring sound.
Previously, I have had no rough starts or other starting issues, and no issues with my battery, which is 4 years old. I left work and had some errands to run--started my car, drove about 1/2 mile. Started my car again, and drove about 1/4 mile. Started my car again, and drove about 2 miles and stopped at a gas station. Started my car again and drove 2.5 miles.
This time, my car started fine, and I began to take off (moving forward--no car in the space in front of me) and after about 5-10 feet my engine died. I haven't been able to start it since. The starter is turning well, but I don't hear anything firing, and giving it gas as I hold the key over does nothing.
Where should I start? I have a video of trying to start, I may try and upload to Dropbox and post. Car is a 2004 Jetta GLS with 247k, and I currently have no DTCs stored (checked using a generic OBDII scanner, not a Vag).
I have a 2003 Golf VR6. Last weekend the car started sputtering and then died. I haven't been able to get it restarted since. I have already replaced the fuel pump relay and the fuel pump. Since I replaced the fuel pump it will prime when I open the door or when I insert the key. When I go to start it it will only stay running for 5-10 seconds then acts like its running out of fuel and dies. EVERY. SINGLE. TIME.
Its not throwing any codes other than a couple 02 sensor codes telling me its running lean. What to do at this point. I was told that vws have a secondary fuel pump relay under the passenger rear seat that sometimes when it goes bad it will turn on the fuel pump to prime it, but wont kick on when its supposed to stay on. I cant find anything on the interweb about it. The shop I took it to that diagnosed the fuel pump said it wasn't throwing any codes when they scanned it.
Ok so I started car ran for about 15 min at idle but ran rough a few times then died now wont start. O yea I drove it on sunday and the speedometer and odometer stopped working also.
View 2 RepliesI was recently driving home when I made a left hand turn and the car died. I had the timing belt and water pump replaced 1,800 miles ago. It sounds like a timing issue to me. The last time I had timing issue it wouldn't run. This time it runs. Attached is a video of me starting it with the camera looking at the timing belt. The noise I heard made me shut it off. I did not want to cause more damage.
[URL] .....
I have an '02 GTI VR6. It died on me on the freeway after surging then limping to a stop and wouldn't restart. I replaced my fuel pump 5 months ago and now I suspect that it has died again, but I want to be absolutely sure that the pump is the problem before I replace it again.
Last time the car would sometimes hesitate in 1st and 2nd for a couple weeks before the pump actually went bad. This time it seemed fine for 5 months then just went out.
The pump does not prime when I open the door. I checked fuse #28 and it's not blown, but there doesn't seem to be any power to it. I tested the power to the fuel pump connector. When I turn the key on I get ~12v for a split second then nothing. While cranking the engine I get ~9v constantly. I hooked a square 9v battery straight to the two outside connectors on the pump and nothing happened.
Can I be sure that the pump is the only problem? Obviously it's dead, but is there any reason for fuse 28 to not be getting power? And should the connector only be getting power for a split second when the ignition is turned on? I tried a different fuel pump relay with no change.
I have a 02 gti with 1.8t and tiptronic trans. Anyways my gf said she was driving and traction light/battery light came on car started slowing down when she tried to accelerate. Said brakes were stuff to and car shut off..what would cause this. I had a maf code over the weekend i cleared.
View 17 RepliesSo im trying to diagnose my girlfriends issue with her car. When she starts it, the car will make a very loud rattling sound, not really grinding, but like metal on metal contact. Sometimes the sound goes away, but when the car is cold it is a guarantee. The battery light is also on, which was not the case when the rattle first started. I first thought (and hoped) it was perhaps the serpentine belt tensioner as I researched that when it fails it can make a loud rattle sound.
Once replaced, the same issues occurred. So I went ahead and put the old one back on since it was not the issue. Note that the old one and new one both shared the same tension applied to the belt and the pulley was still smooth without issues.
Using a stethoscope to try to determine the location of the rattle a bit more precisely I found the noise to be coming more from the alternator. Weird because I recently replaced it within the last year. I went ahead and removed the tension from the belt and played with the alternator for a bit. The clutch felt good when i used a screw driver to hold the fan and tried to move the pulley. One direction moved with ease while the other direction refused to budge, perfectly normal as I researched. The thing that I noticed that I thought was unusual was the fact that the shaft of the alternator had some play (Video below).
The belt has plenty of tension on it so i do not believe that it is slipping on the alternator. I push the belt with the tensioner engaged and the tensioner does not budge.
I decided to measure the voltage coming off the alternator with the car running and it was at 10.95 which im pretty sure is very low for these cars.
I have a problem with my A/C Compressor. The other day while going down the freeway my belt started squealing for a few seconds then stopped. Yesterday when my wife was driving it did it again, and then another time while at idle and the engine struggled and almost died.
I went to look at it last night thinking maybe the belt was loose, but what i found was when the A/C Tried to engage, you here the click, and you see the compressor clutch jolt but not spin. It tries to engage 3-4 times before the system stops and the ac light blinks. Also found some burnt belt on the clutch pully. To me it sounds like the Compressor is locked up or frozen somehow inside.
My first instinct is to get a new compressor. Ive done a bit of mechanic work but not much on A/C. If i replace the compressor, do i just have a shop vac it out, replace, and recharge? car has 150,000 miles, do i need to replace any other components? 2002 V6 Camry....
I have a 2002 jetta 1.8t that overheated on me out of no where i have read some post and couldn't really find what i need it never overheated on me before and this was the first time and when ever i open the reservoir where you put in coolant everything spills out its my first time owning a volkswagen, it happens as soon as i start driving like 30 secs and temperature starts to rise.
View 3 RepliesI was sitting in a drive through line, and my 2002 Ford F-150 started spitting, sputtering and then died. I restarted it several times, not getting anything but the spitting and sputtering again and then nothing else. I was told by a friend it HAD to be the fuel pump, now I am being told it HAS to be the ignition coil. My friend is a shade-tree mechanic and now I am not certain I trust his judgement.
View 13 RepliesHaving an issue with my 2002 GP GT. I started it, but then it died after a couple of seconds while the "Security" light was flashing.
I actually had both original keys with and tried each to no avail (same thing: starts, but engine kills after a few seconds). I checked the PassKey III fuse and even replaced it - still no luck.
Called two different dealer service departments and they suggested turning the key to the "ON" position and leaving it for 15 minutes. I tried this 3 times and still the same issue.
I understand this can be a VERY expensive repair as I've read it requires replacing the ignition module and perhaps the Theft Deterrent Module. How to at least temporarily by-pass or reset the system so I don't have to get it towed (of course it's no where near my place).
2009 Subraru Impreza Outback Sport (60K miles).. I'm trying to figure out what's wrong with my clutch. When I start my car I hear a squealing noise from the engine that sticks around until my car is warmed up. If I depress the clutch while it's warming up (and squealing), it goes away. Bearing?
View 5 Replies2000 VW GOLF 2.0L, manual, ~190k miles
Driving down the highway my CEL started flashing and the engine power dropped at the same time. I drove two miles to my destination and the idle was very rough and the power was still very low. The codes were P0300, 0301 and 0304.
The coil was replaced about 2 years ago. The plugs have never been replaced. About 2 weeks ago I had a solid CEL with the codes P1255 and P0422... I purchased a new ECT Sensor but did not yet make time to install it.
Could everything be related to the ECT? Or do you think there are multiple issues?
I have a 04.5 gli 1.8t. When I start the car in the am and give it some gas to go it sputters for a couple seconds and then goes just fine and I have no more issues with it. Where to start looking? No trouble codes thrown either...
View 10 RepliesI am having an issue with my 2002 GTI 1.8T. I have tried searching for an answer to this, and found a couple things saying maybe it could be the secondary air pump but wanted to get more opinions before I go shell out money to chase this problem.
When I start up the car in the morning after having it sit overnight, the car does the normal thing where it increases rpm's to about 1100 to warm it up. During this a loud "whistling" noise can be heard. Once the car is warmed up a little bit, the rpm's decline to about 900, and the whistling sound goes away. When this happens though it almost sounds as if a valve or something is closing causing the noise to go away.
Also, I am unsure if this is related to this, sometimes when I am driving, I will be accelerating and the car seems to stop accelerating as strong as it was, boost goes down from around 8 or 9 psi to about 4 and I seem to lose power as if I had let off the gas some. When I put my foot further down the car accelerates harder again and boost goes back up.
I have already changed spark plugs, cleaned MAF sensor, and run the 3m 3 part engine cleaning kit through it.
Yesterday, i bumped into the curb as I got home, and today when I went to work the car is pulling very hard to the right, and makes a squeeling sound when I get up to speed. The ball joint looks bad, but can that cause this problem?
View 4 RepliesI purchased a 2001 Jetta and it ran alright for a few days then all these problems started arising. The engine would not idle correctly and then a week later my EPC light started coming on. After all of that I have replaced the Throttle body ( Bosch) the MAF ( after market) and gas pedal ( after market). It ran fine for a day and then same issues. I had a mechanic relearn the throttle which had the Engine light go away for about a day. Now all the issues have came back. Here are the main problems.
1. Randomly lose throttle ( up hill, down hill, highway does not matter)
2. I randomly get stuck in park and cannot shift at all.
This is extremely troublesome since every time I lose throttle i have to put the car in park, shut her off and turn her back on to be able to drive. I keep getting the Throttle and MAF codes. I also checked on the recalled parts and they have already been replaced. I have read many reasons as to what would cause this but even the mechanic doesn't even know and I cant pay for him to check the electric. Also when driving if it is raining my car will not start or when it does it chugs. I was running through a puddle and after the water splashed the car basically would no longer run.
The car is a 2002 VW Jetta, automatic 1.8t GLS. 146k miles on it. Has an external amp/sub wired up by my brother who is an MECP certified tech and has been doing car audio and overall Audi/VW for years.
I was driving, nothing out of the usual, this car is my daily. Stopped because of traffic and my car died in the middle of traffic, the gauges (tach, speedo, gas, etc) spiked immediately, which I assumed meant loss of electricity, but my radio, headlights and everything else stayed on. The oil and Battery lights came on as well. Tried to start it, it was trying to start, and was cranking quickly, but wouldn't turn over. I got it out of traffic. I pulled my amp power and the car turned over and started driving like normal, so i figured there had been a short in the wire and that was what caused my issue. Drove about a half mile down the road, car shut off again, car said it needed oil this time. checked the oil, there was plenty, but i put more in to be safe, and it turned right over and i managed to drive it about 30 minutes and got it back to my house.
So, my brother and i look the car over, couldn't find anything really wrong with it, so we took it out for a drive, no problem at all for the first few minutes of driving. Car shuts off again, doing the same thing, but just the battery light came on. My brother jumped my car, it turned over, but as i started to drive it, it was a lot more rough with shifting (possibly tied to electrical problems because i know there is a solenoid cluster for automatic transmissions), i mean you could actually hear the gears shifting and the car was kicking through each gear, as well as my driver side headlight not turning on (just installed brand new xantec 6k 55w HIDs, but i dont think those are the problem because the problem started before i installed the HIDs) and died 3 more times before i got it home, having to jump the car every single time with symptoms the same as the first time it died without the oil light. Another thing i noticed is that the car seemed to only die when i hit the brakes and the car went to low RPMs, which lead me to believe a major vacuum leak. At idle the car also seemed like it was misfiring even though the CEL was not flashing, it just had the jerking feeling and sound of misfiring.
My brother and i take a better look into the bay area, and noticed that the top of my engine was covered in oil, from the intake manifold back. I know my car has been leaking oil, but not spraying it. We pulled everything apart, totally cleaned the engine bay area out including MAF, spark plugs, coil packs etc. The engine bay area looked practically brand new. Now i do know that my car has had a vacuum leak (no boost gauge to tell how bad, but the brakes were a little bit less responsive and the car was acting as though it was misfiring despite the fact that the coil packs and spark plugs are brand new) and we couldn't find where it was, and we thought that maybe that was the problem. A lot of the vacuum line was dry rotted and falling apart and some parts weren't even connected anymore from that, which we replaced all of the line we could find to eliminate the idea of a vacuum leak causing the car to die when i hit the brakes. We also tested the battery with a multi-meter which read variably between 13.8-14 V, which if i understand correctly is within normal range, but oddly enough we put the battery through a stress test including turning on defrosted, turning sound system back on, headlights on etc, and the voltage didn't read much different, still bouncing between 13.8-14.
When tearing things apart, we also found that the starter solenoid was unbelievably loose due to a bad transmission mount, and one bolt was missing, so we were thinking that could be arcing causing the problems, but when the solenoid was tightened down, the problems still persisted.
Started the car, let it warm up, and it seemed perfectly fine. I drove it into town without problems, but forgot my wallet at home, so i had to turn around and go back. Almost made it home, the car died while stopping at a stop sign. Tried turning it back over, nothing the first 3 times, let it sit for about 5 minutes and the car turned right over as if nothing was wrong. Died again when i made it into my driveway about 0.5 miles away and the symptoms repeated until the car finally just turns on like normal now, but the idle is at 1100 RPMS (not sure if related or not) even though the car is at the optimal temperature. I tried driving it again after the car starts normally like it does now, but it just repeats the symptoms that it has been, cutting off but leaving the stereo, headlights etc on. I managed to get it back in my driveway.
My R has 56k on it. it sat for just over a year and a half and i just got it back on the road a week ago. Two days ago i started it to pull it on my rack and change the oil and it was making a rattling/chattering noise. The noise was going away when i pushed the clutch in but not anymore and the noise goes away in the higher rpm's. on the way home it threw a code and the check engine light came on and with throttle it started making an awful squealing noise. I am kinda scared to drive it.... I guess ill start pulling the motor, transmission or both tomorrow...
View 2 RepliesOn my way to work this morning check engine light came on, diagnosis came up with 2 codes p2181 cooling system and p1516 intake changeover. went to leave work car started then died after about 5 seconds then wouldn't start. as of right now I am thinking that it might be the coolant temp sensor? That's not letting it start? the past week it has been getting bad gas mileage and a low idle.
Mods done giac chip now set at stock setting
APR exhaust and intake
107,xxx miles