Golf IV / Jetta IV :: 2002 1.8t Overheating - Temperature Started To Rise After Driving Like 30 Seconds
Sep 6, 2014
I have a 2002 jetta 1.8t that overheated on me out of no where i have read some post and couldn't really find what i need it never overheated on me before and this was the first time and when ever i open the reservoir where you put in coolant everything spills out its my first time owning a volkswagen, it happens as soon as i start driving like 30 secs and temperature starts to rise.
View 3 Replies
Advertisement
As if puttin on all new 4 tires and having to buy a new wheel because one was cracked didn't cost me enough. Car was idling for a good 30minutes or more (arguing with the gf) and out of no where I noticed the exhaust note change and the temperature rise. I shut if off before it even reached the red mark. Yes I checked the cooling fan and its working when the engine is warmed up. Was it possible some wires may have come loose from hitting a pot hole ( main roads) and it caused it to overheat? Car is running fine and I will get it in the shop next week to have it looked at
Could it have caused any damage to the engine even though I was able to stop it quick and let it cool down?
View 3 Replies
I have a 1998 chevy cavalier, 4 door, 2.2 liter SOHC, which has been running hot for a while now. readings are off the dash guage, here's the scenario. on startup from cold, the temperature begins to rise within 60 seconds, reaching what i consider normal operating temperature within three to five minutes, at approximately the "NO" in " NORMAL" on the gauge.
It reaches what has become it's usual operating temperature, at "RM" within another minute or two. If i am in stop and go traffic, the temperature will rapidly reach the final mark after the "L", but not the red zone. If I get on the highway, the temperature will reduce back to the "RM" position within one to two minutes, three to four minutes in steady traffic at lower speeds, i.e. 35 and all green lights. Thermostat has been replaced, water pump has been replaced, electric cooling fan is running correctly, radiator is free and clear of debris.
When I first got the car back in 2000, it ramped up to heat much more slowly, and hung out at "NO" in all types of traffic. in 2004 i went and picked up my car from my father's place, he had taken it to the local shop and had it given the once over, which is when this problem began showing up, and has gotten progressively worse over the years. I've gotten nowhere with other mechanics, the system is leak free, and the coolant tests good.
View 8 Replies
I have a 04.5 gli 1.8t. When I start the car in the am and give it some gas to go it sputters for a couple seconds and then goes just fine and I have no more issues with it. Where to start looking? No trouble codes thrown either...
View 10 Replies
I have an 04 gti 1.8t and last night it started over heating. I pulled over and checked the coolant and the oil but everything looked good. I let it cool down and drove it home. When I popped the hood there was a little steam coming from the coolant overflow tank but I saw no leaking. I decided to vent the pressure off the system and then I got a little drip on the passenger side close to where the inter cooler is. I can't pinpoint the leak though.
View 4 Replies
So my 2002 Jetta 1.8t is overheating. The water pump was bad. Replaced. The thermostat. Replaced. Radiator. Replaced. Radiator cap. Replaced. We're running out of things to replace! I'm ready to go to a junk yard and get a new block! We've tried about 100 magical "ways to burp it" with no luck. We even tried running it without a thermostat. Without the heater core. EVERYTHING.
The car runs at operating temperature at 4 RPM. But when we take it for a drive, it overheats. There's no heat with the thermostat in unless you rev it at the high RPMs. As for the hoses, top is hot, bottom gets hot. As for the car, it runs beautifully. It gives no codes. No smoke either. Nothing in the oil, nothing in the coolant so I don't think it's the head. It just overheats. This has been FAR too long.
View 17 Replies
My 2002 VW Jetta GLS 1.8T 5-Speed is over heating
Car is still over heating after replacing the following:
- Head gasket
- Coolant fan module
- Geba Metal Prop Water pump
- Full timing belt kit
- coolant fan switch in Radiator
- Bleed the system of all air blow hot air
So Driving the car around town is ok, doesn't over heat, but as soon as I take it on a highway it over heats. I drove it 50 kms out of the city and it over heated, let it cool down and added water. got it back home. Oil light flashed on as I pulled into driveway, turned it off right away. no external oil leaks. Checked coolant, Oil in coolant. also the coolant was boiling, the level was raising up and lowering. I have been reading the forums for a few hours and the oil in the coolant sounds like the oil cooler gasket. Ok so the fans are running and it still over heats. The old metal propeller water pump was very hard to turn so I replaced it with a Geba Metal water pump. no leaks at water pump. Could it be possible that the Oil cooler was causing air to leak into the cooling system causing the coolant to boil? And then when the oil cooler "o-ring" finally failed it dumped oil into the coolant?
View 5 Replies
So i have a 2002 1.8t that i got in december. Everything has been great so far untill the other day the car overheated on me in traffic. It was a bit warm out maybe 75-80 degrees. I saw the needle start to climb and then the light went on so i through the heat on full blast and it dropped the needle a bit and turned the light off long enough to pull off the highway. I let it cool down and checked things out. I am not low on fluid, an the fluid was changed within the last year with the vw recommended stuff. The radiator hoses are pressurized so i believe that the pump and thermostat are working. I am thinking it could have something to do with my fans. I tested them in my driveway by supplying them with 12v and the spun perfectly. It only happens when the car is standing still for a period of time. Driving at any speed is fine. Is there some sort of switch that tells the fans to turn on?
View 2 Replies
I have a 2002 1.8T tiptronic with around 150k Kms. Recently, the transmission has started slipping, more so when at running temperature than when cold. It feels like when a certain amount of gas is applied is when it starts slipping. It can slip immediately after 3-4 and 4-5 with continued acceleration, or will constantly slip while in 5th if trying to drive at speeds greater than 90 km/h (with very gradual acceleration to that point).
Does this sound like a clutch wear issue requiring a new transmission, or more like a valve body issue?
View 1 Replies
Last night while i was driving my car began to overheat. I could smell coolant burning. I pulled over and opened my hood. The coolant inside the coolant pod was boiling. Some coolant lines were steaming as well. I could also hear a gurgly like noise coming the engine. This is a 1.8t gti
View 3 Replies
I have a question about my Golf MK4 1998 - 1.6
I was out driving to work today, and when i cam to a roundabout, the engine stopped. The battery light was lighting as if the ignition only was on, and the steering wheel was extremely hard to use. The gal pedal didn't even work either. After a few(2-3-4) seconds, the car automatic started again, and i could gas and steer normally.
What could this be due to? I know i have some problems with the starter on the car(when i start it sometimes it gives me this loud elephant noise), but it should not have anything to do with it..
View 13 Replies
My son has a 2002 Jetta, we just changed the water pump and the thermostat. The car will sit at idle and the temperature will stay around 190. When you drive down the road the temerature will rise and when you let off teh gas the temperature goes back down. What this could be, I have tried everything I can think of to fix this car.
View 13 Replies
I have a 2002 Volkswagen Golf 2.0, I was driving and the temperature gauge starting raising pretty quickly. I stopped, checked the coolant and oil, both were at normal levels. The car cooled down pretty quickly, and I drove a little and it raised again. The heat is coming out cold despite the hot temperature. Overheating, normal coolant levels, no heat.
View 8 Replies
My vr6 some times loses its power but it's weird because the check engine light does not appear. It does for like 30 seconds then it goes back to driving normally.
View 1 Replies
I have had my 1998 Honda Civic for about 5 years now... I bought it used. Occasionally I have noticed my oil levels have been low every 2 months or so. Oil is not being burned and doesn't leak. It hasn't affected performance from what I can tell. I have basically monitored the levels and everything has been fine. There was also an electrical issue since I have had it.
About 8 or 9 months ago, I noticed the temperature gauge was basically in the red while driving. I pulled over and noticed the oil was reading empty. I put oil in it and took it to the shop the next day. They told me the head gasket was bad and that the oil and coolant were mixing and recommended I replace the engine. I asked them how long I could manage before the car quit entirely and he said maybe a month, two if I kept doing oil changes.
I put the heat on while driving it, and the temp was normal. I took it to another shop the same week. They couldn't get it to overheat for a couple hours. The guy told me it was probably the fan but wouldn't know unless he could see it overheat. He said the fan would cause it to overheat at stoplights when there wasn't air on the engine. When the car gets hot, it doesn't get worse at stoplights and is only after I've been driving like 20 minutes that it heats up. I asked that he call me as soon as he knew what it was and I would decide whether I wanted it fixed that day or not. Then I didn't get a call for awhile, and when I called them, they said the guy was out getting the part. I felt like they were rushing so I would replace the fan. I asked if it was the head gasket because I didn't want to fix a fan if the engine needed to be replaced. They said it was not. I didn't replace the fan. They also told my husband that we could save wear and tear on the engine by putting the air conditioning on instead of the heater. When we do this, it overheats. Its only when the heater is on that the temp stays normal.
I have been driving the car for 8 or 9 months now with the heater on with no performance issues. It doesn't overheat and even when I forget to put the heat on it goes up to the red, but doesn't "overheat" with the steam and whatnot. It doesn't seem to do anything to affect the performance of the car. We have replaced the radiator cap, which had pieces falling off, and it didn't work. The check engine light came on yesterday and the code indicated something to do with the transmission.
We took it to a third mechanic today and he said I needed a new thermostat... I do not see any sort of film in the oil. We just flushed the coolant today and there was no sign of oil. I'm totally lost on what to do. I feel like the mechanics have lied to me about what was going on. They contradict each other and the little things they told me don't seem to be the case or don't work.
View 8 Replies
I have a 02 gti with 1.8t and tiptronic trans. Anyways my gf said she was driving and traction light/battery light came on car started slowing down when she tried to accelerate. Said brakes were stuff to and car shut off..what would cause this. I had a maf code over the weekend i cleared.
View 17 Replies
What happened to my 02 mk4 Jetta after start up and engine failure.
I started the engine, and noticed a high squealing sound just like a loose fan belt, as I backed out my driveway the Battery light came on and engine died, when I tried to re-start the engine it doesn't make any cranking sound just a whirring sound.
View 9 Replies
Resurrecting my 940 TD after it's been sitting for a year and the temperature needle now doesn't rise as the engine warms up. Is there any trouble with sensors on these or should i be concerned about something else? It was working when I stopped using the car.
View 3 Replies
I have a 98 cavelier 2.4L..When engine is cold and the colder the outside temp is, the engine runs great with lots of power. but as temperatures rise, there is a huge loss in power. It feels like the computer is retarding the timing. Is there an outside air temp sensor to close to the rad??
View 2 Replies
I was recently driving home when I made a left hand turn and the car died. I had the timing belt and water pump replaced 1,800 miles ago. It sounds like a timing issue to me. The last time I had timing issue it wouldn't run. This time it runs. Attached is a video of me starting it with the camera looking at the timing belt. The noise I heard made me shut it off. I did not want to cause more damage.
[URL] .....
View 3 Replies
I drive a 2002 Jetta with a turbo engine. In the past 2 months, my car has 'powered out' or shut down while driving - I can't accelerate, it is hard to steer, doesn't really brake well and although the dashboard lights remain on, my car dies on me. So far, I have been able to restart the car with little problem and she usually starts on the 1st or 2nd try. My dealer/mechanic had the car for a day, test drove it numerous times, checked the computer, battery, connections, etc. and can find no reason for this behavior. The last time this happened, it was raining outside; I don't remember what the weather conditions were the first time this happened. I have kept the car well maintained throughout the years.
View 3 Replies
