Golf IV / Jetta IV :: 2001 - Weird Turbo Spooling Sound By Passenger Side?
Apr 29, 2015
I just got a 2001 Jetta 1.8t 100k miles, and had some repairs done - timing belt - K03S Turbo - Forge Tip - 2.5 Turboback Exhaust. I bought the car without a working turbo, yesterday I got the car back from the shop and it was a night and day difference..... but to my point, today I had some CEL's pop - Charge Pressure control positive deviation, Pressure drop between turbo and throttle valve, and secondary Air injection system incorrect flow detected. Now I have never owned a turbocharged car before, but when my windows are rolled up and im accelerating, I can hear what I am guessing is the turbo starting to spin over by my passenger side(2k ish rpms+) except it doesn't have clean spin sounds, kinda sounds like bearings are goofed or something. This noise only happens when I am accelerating or cruising? I also have felt really no change is boost or power!!
View 2 Replies
Advertisement
I have a 2012 R with 85,000 miles, APR chip running 93 octane with a HPFP and VWR cold air intake. I was driving my car today (slow driving on highest) and all of a sudden I felt no turbo boost, and heard a weird sound whenever I hit the gas. Car moved but would not get above 3500 rpms and couldn't really get past 60 mph. Again, absolutely no boost (I have a boost gauge as well to verify).
About to drop off the car at a shop but had a couple questions:
1. If the turbo is blown, can I still drive the car to the shop (not too far) without damaging the engine itself?
2. if the turbos needs to be replaced, what are my options besides getting the stock turbo replaced, without getting some crazy setup? This is my daily driver and I don't want to spend money beyond what I need to get it fixed, but it there is a stronger more reliable turbo for about the same as a OEM, I would want to consider... Also price for OEM replacement??
3. Without the mechanic looking at it, I'm just assuming it's the turbo but what else could be the issue? All the lines looks intact and intake is fitted correctly. I did have issues with my cam follower getting damaged at 45,000 miles (there was a hole in it) and I have been replacing it every 20,000 miles since. Didn't have any issues for 40,000 additional miles, but could damage to that cause turbo failure?
View 24 Replies
I've got a 99 1.8t, and every once in awhile when the turbo starts spooling I hear a fluttering, not sure how to describe it. sort of like when your valves run low on oil and you can hear em tick? Like something is fluttering in the turbo when its spooling, instead of just a steady sucking of air.
View 2 Replies
I got a b5 passat and when i start the car and drive it even when its warm if I don't let it sit for a minute or 2 and i just take off it will make chirping sounds like something is spooling but chirping until about a minute or 2 could this be my turbo ?
I feel like the turbo isn't getting enough oil or something into it so its making this kind of sounds until it gets the oil.
View 9 Replies
There is a knocking sound in the rear passenger side area. Cannot diagnose the cause, what it could be. I checked the bushings for the anti sway Bar but that was not it.
View 1 Replies
i started hearing this weird creaking noise about a month ago. When it started happening it would only occur at very low speeds and then it would stop, now it happens all the time unless i'm turning. I've heard it could be bushings but I'm not sure. What weirds me out is a lot of the time it'll stop either when I'm turning or if I shift into neutral.
[URL]
View 1 Replies
I have the most terrible clunking/rubbing sound on my right passenger side, especially when I'm turning left. When I drive straight it sounds like the wheel is hopping even when going over minuscule imperfections in the road. I also get a terrible rub when going over speed bumps or into grooves and dips in the road.
I've searched and searched but cannot come up with a answer towards rectifying the issue. My car hasn't been lowered; I'm running the stop 337 suspension. I've replaced the following within the past two years:
-control arm bushings
-ball joints
-tie rod ends
-upper strut bushings and bearings
-passenger side axle
-dog bone mount
-engine mount
-tranny mount
Most recently:
-front struts
-sway bar end-links
-driver's side axle
It seems to like everything should be solid considering I've done all of this crap. I don't understand why I'm having this issue and why it sounds like it is getting worse and worse.
View 18 Replies
I'm the proud owner of a 2005 MK4 1.8t gti, and recently it started making a weird sound when it starts kicking in to boost, where it would normally make a whistle sound while the turbo spools up it now makes a sound that reminds me of a supercharged car, it feels like it could be a leak but I don't have an ecl popping up, it does kind of platoes in the powerband, I hope I'm making some sense ..
View 24 Replies
My passenger side has been making thud noises on a number of occasions on my 01 Jetta 1.8t:
1. When I go over bumps, the front passenger side will make a loud thud noise.
2. When I take my foot off the brake, there will be a loud thud from the front passenger side as well.
3. When making left hand turns and I begin to turn the wheel back to return it to its original position, there is a thud coming from the front passenger side as well.
It does not continuously click like a bad CV joint would. All these symptoms came at the same time period.
View 3 Replies
So my jetta is 2001 i believe and idleing like its got major breathing problems, it goes from 700rpms to 1500 in cycles and sometimes dies out all together. I thought it was some kind of vaccum leak and had a few pipes in the engine bay replaced but it didnt fix it. Its also missing a muffler so its really load and annoying, especially when im at inn n out in the drive through lol. Other than that, the car doesn't seem to be running that bad but the check engine light is on as well as the traction light comes on sometimes for no reason.
View 1 Replies
So, I have a 2005 gti 1.8t, has 110k on it, just did a 3" straight pipe, and while a buddy and I were installing my new pipe, and straight pipe, he said my turbo seals were going bad. I could get the k04 cause it handles better, or get a rebuild kit. Well, today when I give it throttle, it almost makes a knocking sound from the turbo? Not from the front of the car, but at the end of straight pipe, you can hear it in that constant spool. What could this be? Time for the k04. Car has unitronic stage 2, so it gets ran hard sometimes.
View 21 Replies
There's this 1.8t gti I'm buying this week from a family member and we've been trying to solve an issue that we ran into. When accelerating the car there is a hissing noise, safe to say that it is air. Then when accelerating a little harder and you feel the turbo pulling you everything seems fine. But a second or so after , the turbo dies off and so does the hissing noise. Then I can let go of the gas and repeat the process and it happens again.
My issue is that I cant figure it out since I Need to be driving to hear the hissing and the turbo cut off. I looked around the threads but nothing really seems to match my issue. No codes either. On top of that I've never owned a 1.8t and don't know much about its turbo.
View 6 Replies
So I recently got this GTi and I was wondering what steps I should take before putting a bigger turbo on this car and the steps I should take when putting a bigger turbo. What should I do first be for considering a new turbo?
View 1 Replies
Have had this grinding noise going on with my 2001 gti GLS 1.8t, the cam chain tensioner has been replaced recently. Would really like to get this solved and fixed, car has 81k miles.
Found this video on youtube, same model and exact same noise as mine : [URL] ,,,,
View 3 Replies
Every time I start my passat after it sits for more than 4 or 5 hours (overnight, workday) it sounds like the turbo is winding up at full rpm for about 10 secs. and then stops. It only happens on cold starts. I've had it in two shops with no luck what so ever.
View 8 Replies
My stereo fuse had blown off and while trying to find it, i removed all the fuses one by one to see which one was blown. I found the fuse, changed it, stereo was back to life. Only problem is that right before removing the fuses the car was driving normal. After checking the fuses the car seems to take longer to start; starter keeps turning for twice the time it did before. Also it seems as if the turbo is not even there. Btw the car is a golf mk4 tdi 150 bhp 2001 model
View 4 Replies
Ok so I just replaced the oil cooler, added 2 coolant filters, changed the oil/filter, and both fuel filters, and installed the updated turbo drain tube. I get it all back together, it takes a minute before it will fire but I figured that was normal for not having any oil in the sump under the cooler and changing both fuel filters. Everything seems fine, checking for leaks and I notice that I don't hear the whistle of the turbo so I go look at my edge CT and have zero boost and it stays at zero even if I rev it a bit. Obviously I didn't redline it or run it for very long maybe a total of 10 minutes over several times.
I will note that I did find a plug for the driver side injectors wasn't plugged in the first time I started it, but I shut it down pretty quick and plugged it in. So then after I noticed the turbo not spooling I used the chip to pull the codes and had a whole bunch related to the unplugged harness and one for turbo underboost. Figured it was because the harness was unplugged so I just cleared the codes and tried again, now I'm not getting any codes but I'm also not getting any turbo boost the only code that it is throwing is the P1000 "on-board diagnostic systems readiness test not complete" do I need to go drive it for the learning sequence because I had the batteries disconnected for a couple days?
View 14 Replies
Having an issue with my 05 f350. Seems when I chomp on the the throttle I get tons of boost 30 lbs plus with no power. Seems most prevalent when starting on a hill , or hard on the throttle off the line . Also getting turbo "bark " when backing off throttle. It's less prevalent when feathering the throttle and usually more noticeable 1/2 throttle or more. I'm thinking could be the Vgt actuator or clogged/ dirty ebp sensor?
View 10 Replies
My 07' sport has been spooling slowly and I hear the turbo whine slowly raise in pitch. After it gets up to speed the car then gets a surge of power. Previously I could not hear the turbo during the spooling phase and the power would have a light and smooth push like a bed of air under mid-heavy 4th gear acceleration. Seems most obvious around 2.5k rpm from a neutral throttle position. Dealer claims normal function, but it is definitely abnormal. I have also had oil pressure lights which generated no codes and were explained away as the engine being sensitive to the oil Ievel which was slightly high. I thought at first it was the cold weather, but after our 80 degree day yesterday and same results.
View 2 Replies
2005 f350 6.0 all stock except egr delete. My turbo is spooling up and down constantly. I can actually watch my VGT duty cycle fluctuate while sitting at an idle too. I've cleared the codes and p0299 always shows up first, but then I'll get p0069 BARO/MAP, and a p0470 exhaust pressure sensor eventually. Sometimes it takes an hour of driving before those show up. I can watch all these values on my torque pro, and nothing seems out of the ordinary other than the turbo opening and closing at will. What can cause this? I hate to just start throwing sensors at it.
View 11 Replies
Last night I noticed a weird sound coming from the left side (alternator side) of my engine. Took a video.... I have already done my timing belt replacement about 10k miles ago. Oil is full, no leaks. Have the pcv block so it has a slight putting sound (as stated from their install manual). You can hear an inconsistent hollow growling sound that happens at idle but also under revs. Didn't notice the sound this morning but a lot last night.
[URL].......
View 4 Replies
