Engine will overheat unless I turn the AC on. The engine fan only operates with the ac on it seems.
Will not overheat unless in traffic for a while.
Would it be radiator thermo switch or the Fan Control Module?
My temperature has been randomly dropping, them back to middle, and recently my engine was overheating because I'm guessing the fans didn't turn on, because I'm also guessing, the engine didn't know it was overheating?
Anywho, during my replacement, I made sure to get rid of the pressure, and the car was cold. I tightened the cap again, but when I took the sensor out, all the coolant spewed out.
Now if I understand this correctly, do I have a leak? I figured the leak I had was coming from the temp sensor as it is.
Here's some pictures for those who'd like to see ....
Ok I have an automatic 02 gti..the other night as I was driving home it started to overheat And fast..I had to stop about four times to get home so it can cool down a bit..the next morning I went to check for leaks but I didn't have any and my coolant level was good..I turned the car on and let it heat up and I noticed the fan didn't kick on..is the fan not turning on a good sign that it is bad? I ordered a timing belt kit from ecs which came with a new water pump and thermostat but I didn't get to switch everything out in time and now im stuck with a overheated engine..the only thing I did change was the coolant temp. Sensor because it was the easiest thing to change.
View 2 RepliesSo to start off, its 10 degrees here with a -7 degree windchill. With that in mind, I was driving home just now from dropping off a friend, and noticed my engine temp was slightly about 190. Didn't think much of it, but within a mile down the road the temp was crossing the final line before the red 260 degree line. I pulled over and let it get down to 190 (luckily didn't take long) but in the next 3 miles home it rose again, then fell, and then rose again as I drove through my neighborhood. I'm thinking maybe the thermostat is going bad...? There's no way it went from normal operating temp to almost overheating as cold as it is....
View 18 RepliesMy brothers jetta is over heating constantly. The thermo switch on the radiator and controller box under the battery have been replaced. The fans dont come on till just before the red mark on the gauge. There are no water leaks, and we can hear gurgling when running the engine. How can we tell if the water pump is bad or not and where is the thermostat if it has one.
View 2 RepliesI have a 2001 1.8t beetle and doing some research to buy parts I came across two different engine codes. My trunk says I have a AWV engine but the cylinder head says AWM. This is really confusing as looking them up I get three entirely different options for this car.
View 6 RepliesI recently traded my mk1 for a 2001 jetta vr6 and though it was running fine the first few days, it now seems to die when the engine heats up. The check engine light and battery light turn on when it dies but turn back off when it cools down. I ruled out the battery variable by getting a brand new one (old one was 5 years old anyway) and the alternator is reading healthy voltages.
I've seen a lot about the crank position sensor (engine speed sensor) and I suspected that was my problem so I took it to an auto parts store and waited for it to die to pull the codes. The codes were P0201, P0205, P0203, P0206, P0444, P1473(?), P0418, and P0413.
The first ones said "fuel injector open circuit" and the others were all saying something about the evap system. I was wondering if these codes related to the crank position sensor or if there's something else I need to worry about. I may have stepped a little bit out of my league with this car and I'm at a dead end.
2001 Jetta GL, 2.0L, 170k miles.... It won't start and it's not likely the fuel pump. After the car has sat for a while, I hear the fuel pump spin up when I open the door. It turns over just fine. I pulled a spark plug, attached it back to the wire, held it close to the head, and when the engine turned over, no spark. Is that still a valid test for spark? I haven't had to diagnose a spark issue for so many years, I don't know whether that has changed.
View 18 RepliesSo, my brother has an 01' VW Jetta 2.8 VR6 with a 120k miles on it. He was recently driving around 50mph when the engine cut out, he lost all power and all the lights on the dash came on. He didn't get any loud bang when it happened, it just cut out. He tried to restart the car but heard the starter try and nothing else.
He got it towed to a garage who said they suspected it might be a timing chain but they couldn't say for sure until they started poking around. He doesn't recall getting the loud "marbles in an" noise when the chain is about to go. They were quoting around $4k to replace the engine. Being as my brother is a poor student this isn't something he can do, plus he'd already replaced the radiator, tires and all that and I want to verify what is wrong with it.
I'm posting as a last ditch effort to try and rescue my 2001 Vw golf here's some quick details about the car then I'll go into the situation.
2001 Golf 1.8t 5speed
Euro customs stage 2 Aftermarket intake and downpipe
Still have front and rear O2 sensor and probably cat. Maybe..
Otherwise stock
201k miles
Okay so pretty much here's the rundown.. I was driving my car to work one day, then all the sudden lost complete throttle response to my car but was about to cruise at about 5-8mph to get to work and avoid towing. What is going on besides the EPC light was on and CEL was on. After work I discovered that the rear O2 sensor was hanging down and frayed.
Apparently from what I was told, that fries your ecu and put the car into a similar mode as mine. I then replaced the ecu with the euro customs ecu, I replaced the throttle pedal, and the throttle body since all I was getting was throttle codes. I am still not able to get rid of either EPC or CEL lights. The codes showing are p0638 and p2101. Yes I have tried to get the throttle body realigned or whatever you call it. However the vag com will not let you realign with the codes still in the computer which have been deleted but come back immediately.
The rear O2 is still unplugged and I still have little to no throttle response.
I have a 2.0. Custom gt28 turbo project. Been up and running for awhile now. Took it on a 4 hr trip home and drove it back.
All of a sudden after the holidays it started to overheat and I had no heat. It will not overheat when idling. I replaced the thermostat recently. Lower hose gets warm when it opens. I replaced the green top sensor. I have done a wire tuck etc and I am running a closed coolant system. I believe I have gotten the air out of the system.
It will idle all day at 190. But as soon as I drive and accelerate hard or go over 50 mph it overheats and will not cool off unless I pull over and turn the car off. It will steam as if it's losing coolant somewhere but I think it's at the cap (too much pressure?).
I am thinking water pump but I am not sure. I got the car with 124k miles I'm at 127000. I was told timing was done at 90 could the pump be failing already? Also when it overheats I get a cel for misfire is that normal?
My 2002 Jetta VR6 is overheating. The car only overheats when the car is not mobile. If I get stuck in straffic or just let it idle it will over heat. What could it be?
View 3 RepliesAs the title says, car is overheating. Car gets to 190F within a couple miles drive. Temperature fluctuates between 190F and 225F.
Water pump was replaced ~2 months ago. Was not overheating prior. Temp reached 190F and stayed. Currently has the "black top" coolant temp sensor.
I noticed the coolant fans are not running after I turn the ignition off. This time of year they would usually be running after turning the engine off. If car is overheated and with AC off the fans do not run while engine is running.
I used the guide below to try diagnosing the cause: [URL] ....
Remember both fans should come on in slow speed any time the key is on and the AC is on - if the temperature is above about 32 F (0 C). Both fans run with key on and AC on
S180 (fuse 8, 30 amps, green plastic, above battery) must be good for slow speed operation.
Fuse and holder look good: no melting, no discoloration.
S164 (fuse 3, 40 amps, metal strip, above battery) must be good for fast speed operation.
fuse looks good: unbroken.
To ensure the AC circuits and the Fan Control Module has power check:
Fuse 5 on the cabin fuse panel.
Fuse 16 on the cabin fuse panel. When this fuse is blown the radiator fans will often run unexpectedly.
Fuse 25 on the cabin fuse panel.
All three fuses look good: unbroken
For the first test of the slow speed fans from the radiator thermoswitch have the key off.....Both fans should run in slow speed.
Passed test: both fans run slow
The second test is for the fast speed fans, key on, AC off.... Both fans should run in fast speed.
Passed test: both fans run fast
If the fans run in the tests above, then you should be good to go. No further tests are needed.
If you have been seeing high coolant temperatures and the fans have not been running, then you may need a new thermoswitch.
So my 2002 Jetta 1.8t is overheating. The water pump was bad. Replaced. The thermostat. Replaced. Radiator. Replaced. Radiator cap. Replaced. We're running out of things to replace! I'm ready to go to a junk yard and get a new block! We've tried about 100 magical "ways to burp it" with no luck. We even tried running it without a thermostat. Without the heater core. EVERYTHING.
The car runs at operating temperature at 4 RPM. But when we take it for a drive, it overheats. There's no heat with the thermostat in unless you rev it at the high RPMs. As for the hoses, top is hot, bottom gets hot. As for the car, it runs beautifully. It gives no codes. No smoke either. Nothing in the oil, nothing in the coolant so I don't think it's the head. It just overheats. This has been FAR too long.
My 2002 VW Jetta GLS 1.8T 5-Speed is over heating
Car is still over heating after replacing the following:
- Head gasket
- Coolant fan module
- Geba Metal Prop Water pump
- Full timing belt kit
- coolant fan switch in Radiator
- Bleed the system of all air blow hot air
So Driving the car around town is ok, doesn't over heat, but as soon as I take it on a highway it over heats. I drove it 50 kms out of the city and it over heated, let it cool down and added water. got it back home. Oil light flashed on as I pulled into driveway, turned it off right away. no external oil leaks. Checked coolant, Oil in coolant. also the coolant was boiling, the level was raising up and lowering. I have been reading the forums for a few hours and the oil in the coolant sounds like the oil cooler gasket. Ok so the fans are running and it still over heats. The old metal propeller water pump was very hard to turn so I replaced it with a Geba Metal water pump. no leaks at water pump. Could it be possible that the Oil cooler was causing air to leak into the cooling system causing the coolant to boil? And then when the oil cooler "o-ring" finally failed it dumped oil into the coolant?
1.8 jetta... Seems to do this when at idle only on occasions it goes above 190F. Waterpump was changed about 5k ago so I'm sure its not that. Thermostat still needs to be changed. It seems like if I turn the heat on it stays at 190F.
View 2 RepliesMk4 Jetta Gli 1.8t , car was over heating only when sitting 5+ minutes at idle, mechanic said the big fan needed replaced so he replaced it. Car still over heated so i replaced the coolant with G13. It hasn't over heated yet but got in the car this morning and the coolant light started flashing and car was telling me to STOP the car. Checked out the coolant and it was on the low side. What it may be? Leak somewhere? Bad thermostat or water pump gone bad? Timing belt and water pump were done when i bought the car when it had less than 50k miles, car now has 99k miles on it.
View 7 RepliesThe issue: Check engine light on. Codes pulled, and he's getting O2 sensor codes (aftermarket exhaust has caused that since he bought the car) and 17705 Pressure Drop Between Turbo and Throttle Valve. The car barely accelerates, and you can hear the turbo spooling, and the engine has small surges. I had VCDS going and went for a drive and noticed his N75 Valve duty cycle was stuck at 5.1% no matter what throttle position he was in. So we're going to the wreckers this afternoon and will pull an N75 valve? The DV is stock and appears to be in good condition, but if changing the N75 doesn't work then that's the next spot I'll look.
View 7 RepliesMy girlfriend has a jetta and I work at a DODGE dealership in service. I recently replaced the water pump and flushed the coolant twice and replaced the coolant with G13 coolant from the local VW dealership. After I finished burping the coolant system of air bubble. After I finished I took it for a spin and being the speed demon I am, I don't hold back on the throttle. I noticed immediately the engine lagging and being extremely sluggish. I ran my shops snap on code scanner on it and I came up with cylinder 1 fuel injector open circuit. Cylinder 6 fuel injector limited power. And last but not least o2 sensor 1 open circuit. If your facing the motor I undid the left motor mount from the frame, lifted the car on a hoist and took the bottom side motor mount off of the motor. I took the cv shaft off of the transmission and lowered the car and jacked the motor up by the oil pan to expose the water pump for removal and replacement. I'm wondering if possibly the o2 sensor could cause the ECU to seize power to two of the cylinders to ensure no engine damage or if its 3 separate problems.
View 3 RepliesSo my gf's check engine light on her 01 Golf flashes once in a while, and it misfires. But the thing is, it doesn't stay on, and it's once in a while (like once or twice a week). She has new spark plugs, and new wires. I have a feeling it's the coil pack, but I really don't know if it needs to be replaced until the check engine light actually stays on.
View 14 RepliesJust a few days ago I was driving and I noticed as I went over 35 mph my car would stutter and the check engine light would start flashing. And when I slowed back down the car drove fine. I'm wondering what the problem could be? Feels like the car is losing power. Car is currently at 119k miles.
View 1 Replies