Golf IV / Jetta IV :: 1.8t GLI Overheating / Coolant Light On
Jan 10, 2015
Mk4 Jetta Gli 1.8t , car was over heating only when sitting 5+ minutes at idle, mechanic said the big fan needed replaced so he replaced it. Car still over heated so i replaced the coolant with G13. It hasn't over heated yet but got in the car this morning and the coolant light started flashing and car was telling me to STOP the car. Checked out the coolant and it was on the low side. What it may be? Leak somewhere? Bad thermostat or water pump gone bad? Timing belt and water pump were done when i bought the car when it had less than 50k miles, car now has 99k miles on it.
View 7 Replies
Advertisement
Before I go buy a Bentley manual to dig around, when should my radiator fans kick on. I had the car idling for 10 minutes, no ac or heat on, and my coolant warning light came on, it overheated. It already has a new fan switch in the radiator, and the fuses are good.
View 7 Replies
My 04' GTI, 24v VR6, all stock, @ 107,000. I had a coolant leak from the t-stat housing. I installed all new housing, seals, and C-Pipe from GruvenParts. Already had a green CT sensor installed and the kit I got didn't come with one, so I didn't change it. Found out the leak was from the t-stat housing o-ring didn't fit the old housing. The new one fits perfect. I put coolant on the seals and burped it. Doesn't leak a drop. But still overheating, all the hoses have pressure and are hot, so no blockage....I noticed the fans were not coming on at all. The fans used to engage every other minute and run for 15 secs on high ONLY. Longer times, if not constantly w/ A/C on. I was wondering how to test the fans, sender, and/or fan control module to see which one of them isn't working. And which pinouts are what?
View 2 Replies
Last night while i was driving my car began to overheat. I could smell coolant burning. I pulled over and opened my hood. The coolant inside the coolant pod was boiling. Some coolant lines were steaming as well. I could also hear a gurgly like noise coming the engine. This is a 1.8t gti
View 3 Replies
After finally getting some issues sorted this weekend (needed a transmission flush) I was driving around a bit to make sure everything was good. On the way back to my house, the car started overheating. I replaced the thermostat this winter (~4-5 months ago) because it was stuck open making things run a little cool.
I was thinking the water pump is probably shot but not 100% sure. the radiator fans both work and when I turn on the heater, it blows hot. Any good way to check if the water pump is dead? I have a little point and shoot infrared thermometer and one side of the coolant line was way hot and the other was fine (cold ~90 deg F).
View 11 Replies
I am having a overheating issue with my 1.8t AWP gti, it goes as fallows, start the car, engine warms up go for a drive (short 5-8 mi), park the car and temp gauge starts to rise, (turns off car)... I began to check some things with the system, I checked both rad hoses bottom is hot top is a bit hotter and fans work when ac is on; here is where it gets interesting i took off the coolant return hose on the reservoir (cold start) and nothing was flowing ...water pump?... So i turned the heat on and air full blast and all of a sudden coolant starts to flow.
It also seems like air is being spat out as well. Soon after the flow beginning my coolant in the reservoir starts to fluctuate (rising and dropping) with air bubbles and beginnings to over flow so i shut the car off. Now I know what the possible issues are its either the water pump, air in the system or bad autozone thermostat. Here is some history of the car TB was replaced at 70,000 by Previous owner, i bought the car had the belt inspected and was told it was good, about 2 months ago i had a coolant leak and had it misdiagnosed as a thermostat housing leak; it turns out it was a coolant bypass hose that was leaking so i ended up fixing it. I lost a lot of coolant but topped it off with g12+. My mechanic doesn't think its the water pump and recommended changing the thermostat for an VW one another mechanic recommended to bleed air of the system.
View 7 Replies
Ok so I have an 04 Jetta 2.0 and lately it's been overheating on me. The first time it started overheating was because my radiator was cracked and leaked out all my coolant, I swapped the radiator everything was fine for a while. The second time I started overheating, I saw my primary fan was bad it wasn't spinning at all, I swapped it everything was fine for another while. I also changed the coolant temp sensor, it wasn't bad it's just because the coolant flange was leaking coolant, so I changed it a long with the O-Rings and sensor. I also changed the thermostat just incase that was the problem but it wasn't.
I don't think the fans are turning on by them selves when they have too, but either way the car still overheats when I turn on the fans manually with the A/C. I'm not sure if the coolant is circulating, as the car only begins to overheat when I come to a stop and it idles. I have a feeling it's the water pump but I wanna be sure it is before I change it. What it could be? Things that I should check for that usually go out?
View 6 Replies
My temperature has been randomly dropping, them back to middle, and recently my engine was overheating because I'm guessing the fans didn't turn on, because I'm also guessing, the engine didn't know it was overheating?
Anywho, during my replacement, I made sure to get rid of the pressure, and the car was cold. I tightened the cap again, but when I took the sensor out, all the coolant spewed out.
Now if I understand this correctly, do I have a leak? I figured the leak I had was coming from the temp sensor as it is.
Here's some pictures for those who'd like to see ....
View 4 Replies
I have a 2002 VW MK4 1.8t. It has 172,000 miles on it. Since i bought the car i have had to add coolant from time to time due to leaks from various plastic coolant parts so I replaced the crappy plastic connectors and flanges as they failed but it has never overheated till a couple days ago. It rose up to about 210'F but I didn't let it get to 260'F (aka the red zone).
While the temperature was up, the coolant was spraying everywhere causing white smoke under the hood. I stopped and looked under the hood and came up with the conclusion it was the coolant flange that holds the temp sensor since it was leaking coolant from the flange like a faucet hince the reason it caused it to overheat due to lost of pressure and no coolant in the system. So I replaced the part and gaskets then checked for other obvious leaks.
No leaks are shown nowhere else in the vehicle. So I added coolant to the car and let the cooling system do its magic as i left the heater on high. Let car idle with cap off and heater on for about 45 minutes. No signs of overheating. So I take the car for a spin and that's when the car starts heating up. I look under the hood and feel hoses and notice all are pressurized but top hose that leads to coolant flange is hot and the bottom hose connected to thermostat is cold.
I checked the return hose that leads up to the coolant reservoir to see if it's cycling and it appears it was. At low rpms the return hose had a steady flow and at high rpms it was flowing much rapidly. Which made me think it wasn't the water pump also this car with that many miles wouldn't have lasted with the plastic impellar this long if it wasn't already swapped out by previous owners. My question is what would cause it to still overheat? I forgot to note the fans did not turn on when the temperature was rising unless i turned the a/c on. But i still did a drive test with a/c on and it still overheated. I also did multiple burp cycles. I have invested alot of money in custom work and suck to leave it parked on the drive way.
View 2 Replies
I have an 04 gti 1.8t and last night it started over heating. I pulled over and checked the coolant and the oil but everything looked good. I let it cool down and drove it home. When I popped the hood there was a little steam coming from the coolant overflow tank but I saw no leaking. I decided to vent the pressure off the system and then I got a little drip on the passenger side close to where the inter cooler is. I can't pinpoint the leak though.
View 4 Replies
Okay so recently I was driving my 2000 Jetta and the coolant temp light came flashing on, when I went to check the coolant I was surprised to discover that it was like a mud brown color, almost looks like peanut butter. From everything I have read this can be from a few things, either rust build up that is gunking everything up and oil getting into the coolant somehow. I'm pretty sure its rust build up but I was wondering what everyone thinks about this, I was also not using G12 coolant which I'm told now is the premier brand for VW's.
View 3 Replies
I know this is a common problem, it sounded like the coolant resevoir was the place to start so I replaced it today and I still have the low coolant light blinking, I don't know what else to do.
View 6 Replies
I got an 02 gti automatic. My low coolant light has been coming on often lately. I checked my coolant level and it was real low. I added coolant and the light didn't come back on. After a few weeks the light came back on. Again I had to add a lot of coolant..I have no leaks though. Where could all this coolant I add be going? I am not over heating or anything. Its like my car is literally drinking this and peeing it out, I have to add some almost every week now for the light to stay off.
View 24 Replies
Today was the first time my wagon has stranded me due to a mechanical issue. During city driving my coolant temp light came on so I pulled over to check it out. The fans appeared to be working, the coolant was a fair bit above the normal mark, but I'm not sure the water pump was running. I couldn't feel anything when I squeezed the top radiator hose. This is an '03 with about 50k miles on it.
I'll be taking it in Monday morning so I was curious what people's thoughts were. If it's the water pump is there anything else I should consider getting replaced while I'm at it? I'm still on the original timing belt, a change I've been delaying a long time since I drive so little so it might be time to bite the bullet and do it.
View 3 Replies
Car: 2003 Jetta VR6 GLX 24V
Sometimes when I start up my car ( I want to say when cold, but I haven't tried after its warm yet), the coolant light and warning come up. I obviously checked the coolant, and it is a little low. But it's been where it is since I bought the car, and I haven't noticed any leaks. After I turn the car off then on again the light goes away.
The car is running perfectly fine, it's not running hot or cold. Another thing I have noticed is that my fans don't seem to be working. ( I know it's a common problem). But I'm thinking this could be the fact that it's below 0 today.
I haven't gotten it scanned yet, but what's going on; i.e., Thermostat, sensors, fans etc..
View 7 Replies
I've got some problems going on with my 2001 VR6 Jetta. I was driving home from my way to work this evening and all of a sudden the indicator light came on and told me to stop and check the coolant level. Within about three minutes the car was already up to about 200. I pulled over to a gas station and the coolant reservoir was completely empty. So I began to pour coolant in the reservoir and fill it up I notice I was pouring a lot of coolant so I went to the hood looked on the driver side below the bumper and water/cool was pouring out everywhere. I inspected as many radiator hoses as I could and did not find any cracks. The water seem to be pouring out from around the thermostat housing. My question would be since I don't know whole lot about cars would they crack thermostat housing because you need to have this problem?
View 24 Replies
This morning I went to my car started it for 10 seconds the light on my dash said stop and to check coolant, I got a ride to get some coolant filled it up, drove to work than drove home after work and the coolant level is at the same place I filled it up as this morning. What happend that it was gone last night than fine today? 03 vw gti vr6 24v ....
View 6 Replies
My coolant indicator light keeps returning on my 01 Jetta GLS 2.0
I have searched in the forums and read that its likely a coolant sensor and requires replacing the coolant tank. I am wondering if there are other possible causes as I want to drive it for another 3k before replacing tank (as I will be having timing belt replacement and coolant flush at that time). Previous owner had universal (green) coolant in and it will be replaced with proper coolant when the flush is done.
The indicator comes on within a minute of starting the car. The thermostat seems to operate just fine and car is not overheating. I have topped off with diluted water, it definitely has proper level.
Safe to ignore as long as I watch coolant level and temp?
On a separate issue: I tried to use code reader but it would not connect to my car (had successfully connected at some point prior), I believe it may be because I have an aftermarket radio (the K-wire issue?). If that is true, should it resolve if I swap the stock radio back in? I need to be able to connect to the car eventually when it is time to renew registration (for state emissions control testing).
View 5 Replies
I have a 2002 passat. it is a v6 with a manual trans (i do not know about gls or anything like that) but the coolant stop light is coming on and if i drive, it runs hotter than normal. i assume it is a thermostat stuck closed but is there anything else i should look at before i make that assumption?
View 2 Replies
Before someone says "normal" I know the low temp light is supposed to come on until the car reaches normal operating temp My problem is really strange and my mechanic and I are both perplexed. I have a 2008 Yaris automatic sedan with 98K miles on it.
The symptoms:
After driving for quite a while (30 minutes or more at times) the low temp light will come on... and sometimes goes right out... and sometimes goes on for a while.
If the check engine light isn't already on - it will eventually go on.
Sometimes with the low temp light is on - it will race the engine (just straight high rev) OR it will pulse the engine (like I am pumping the gas peddle) OR it will not let the car shift into high gear (rare). Remember... all of this happens after the car has been running for while so it warmed up.
What we've tried (over a 4 week period now):
The error code indicates to replace the thermostat - so we've replaced it... twice. We've replaced the actual low temp sensor. We've checked the wiring between the sensors and the computer - wiring does not appear to have a short. Last week we replaced the computer with a used one, but the same problem still exists with a replaced computer...
What the mechanic says now:Might be an air conditioning thing running the fan too long?
Can you really run a fan so long it will drop the car temp back to below the low range operating temperature while driving on a highway? That seems pretty unlikely to me.... If it were just a flickering light, I wouldn't be so concerned... but because it revs the engine (even when I am at a stop light and I have to push the brake harder so it won't start moving) and it sometimes wont shift into high gear... it's concerning from a safety perspective.
View 6 Replies
I have a '97 Buick Century. I noticed the smell of coolant, and the "Low Coolant" light flashed on the dashboard. However, according to the temp gauge on the dashboard, the car was at normal temperature. I pulled over and opened the hood. The coolant in the overflow tank (not the radiator) was boiling, and sputtering out.
I took the vehicle to a nearby shop, where they said it needed a new "Coolant Level Switch." They told me they put a new one in and did a coolant flush, and sent me on my way.
About a mile down the road, the "Low Coolant Light" came on again. I pulled over and found that there was ZERO coolant in the engine. I filled it myself, and continued driving. Over the next few days, I checked the coolant every day and it stayed normal. I drove a bit, but never more than a few minutes, so the car didn't have a chance to overheat.
Then, today, I drove it a good distance for the first time since the original incident. After a few minutes of driving, I smelled coolant and pulled over. The coolant in the overflow tank was once again boiling and bubbling out. What it might be?
View 1 Replies
