I got pics, will upload as soon as I'm off work. But anyways, there's a small rust spot on the drivers side hinge, as well as a small spot on the passenger side rear door hinge. It seems rather hard for me to believe considering I'm the guy who periodically washes their car, and waxes all the door jambs and under the hood.
View 1 RepliesRandomly my driver side door hinge squeaks....
View 6 RepliesAny time I open or close the driver side door, hearing some noise from the door hinge.
View 1 RepliesAfter the years and 300k miles, the door hinge on the driver side door are getting some play. I wonder if i can replace just the pin on this hinge or the whole thing needs to be replaced. By the way, I am talking about a 00' F450 ...
View 2 RepliesWe have been tolerating a bad squeak in the driver's side front door upon opening, closing (any type of swinging of the door). Dealer tried lubricating it with no success. They told us that they would order a new hinge and "hope" that resolves it. I am a little worried about this. Would you trust your dealer to remove and re-install the door or just live with the squeak?
View 5 RepliesDue to the rain this weekend I decided to clean out my interior and do some maintenance. Lately my driver-side door has been making a squeaking sound. As such, I decided to lube up all the doors just in case. Upon inspecting all the doors/hinges I found that both the driver-side rear door and passenger-side rear door hinge bolts are rusted real bad. These are the bolts that connect the hinge to the door rather than the hinge to the door frame.
I inspected the door for any sign of water intrusion, but could not see anything out of ordinary. Also, nothing else was rusted or appeared to be water damaged. I inspected all the other hinge bolts around the car for comparison and they were fine. It is strange that both rear passenger doors have this issue. I bought the vehicle used and the Carfax comes back clean with no accidents or damage reported.
The only other time I have seen this is when the door has been worked on, and a socket was used which stripped the protective paint off the bolt. Even then only the rough edges of the bolt rusted, and not the entire thing. While I could foresee one door being worked on, I do find it strange that both would have needed work. However, this assumption does not rule out the possibility.
My only other issue of concern which may play into this is the surprising amount of sand I find on the exterior. As good as one can clean a car there are always some places that will never get fully clean. With that said, while the exterior is clean I have found sand residue in little crevices (weep holes) and corners throughout. I am sure that sand and moisture would play a part in causing rust to accumulate, except that no other parts show any sign of rust. This is certainly bizarre to me. I plan on replacing the bolts, but would like to remedy the problem before hand if possible.
I have a 2003 Highlander and noticed on when you open the door, there small spot of rust.
View 15 RepliesMy son bought a 1996 Toyota Corolla as his first car. There is rust developing on the driver's side door panels, mostly around where the decorative strip is. I am wondering what we can do to stem the tide, so to speak. Hopefully, something simple can be done. We can worry about patching the small areas that have already corroded, but he would like to not have it get worse.
View 12 RepliesSo i parked my car in the garage cause it was supposed to snow over night, well pull out this morning and there was a small wet spot, when to inspect it and it was oil, colorless, it came from front driver side, something is leaking, I popped the hood and looked down and i can see oil on plastic, on the bottom of the engine bay, where is this coming from? no light are on, and oil levels are all good? its a 2012 gti with 31k miles on it....
View 1 RepliesFor over a month I was having a slight rattle coming from the driver's side.
Today I found that my door panel on one end is coming off. I can literally bend it and look inside
Not sure how to take the top half (where the wood trim is) off without breaking any remaining clips.
Replacing the top door hinge on a mk4 r32 if so what size spline is it?? also has to remove the hinge pin?? was this a easy enough job if so whats the procedure.
View 3 RepliesMy fuel door is starting to crack at the connection to the hinge? It looks like from the assembly drawing that I'll have to remove the wheel and the wheel well liner to get to it but the drawing is not super clear.
View 1 RepliesI started to notice a slight vibration coming from my front end on the drivers side last week and now is pretty loud. It increases with acceleration, fades slightly when turning left, and goes away almost entirely when turning right. Tie rods seem fine. The inner and outer cv boots are torn but have been that way for some time.
View 4 RepliesGot a 03 GTI VR6 and my drivers door kept on making this creaking/popping noise(it is very similar to the creaking noise of a old wooden door or the sound you hear in horror movies but for a lot shorter duration). The sound seems to come up when I accelerate, break take off from a complete stop. I took the car into the dealership and they torqed some bolt on the hinge and the creaking went away. Not a month later the passenger door develops the same creaking. The dealer tries to torqe the bolt on the hinge again and they say it cant be done and that their body shop needs to replace the hinge. They paint a hinge for me and put it on but don't get the door adjustments right so I get a lot of wind noise. Finally they adjust the door right and all is well.
A while later the drivers door starts creaking again! I went to another dealership and did an oil change while I was away on a trip to Toronto and the service technician said he could lubricate the door gasket and that this will take the creaking away. So he did. Now granted that has taken the creaking away but after some rain and 2 car washes the creaking came back in full swing.
I call the dealership to set up an appointment and they refuse to look at the door saying that as far as they are concerned the vehicle is up to manufacturers specs and that they will need to get a VW rep to look at it. In the mean time I call the vw customer care which tells me that they contacted the dealer and that the dealer beleves that the car is up to manufacturers specifications and that the noise I am hearing is normal and that all the cars have this noise.
Now I owned an 02 Golf GL 2dr and never heard that sound. It's been a month and a half and neither the dealer or vw customer care have called to inform me when the VW area rep. will be coming to have a look at the issue. It looks like I hit a dead end with having my issue acknowledged and looked at. Is this really a standard noise on the mk4 2dr platforms ? How I should pursue this issue ?!? Anything ?!
I got a small rust spot on a corner of the hood of my car (5 months old). The 3 year/36,000 mile paint warranty included with the purchase of the Elantra should take care of this, correct? It's small so I was gonna sand it down myself and use a touch-up pen, but now having second thoughts. Should I take it to the dealership instead?
View 16 RepliesI noticed a rust spot near my passenger rear wheel well. Not really sure how I got the damage or where it came from. I don't walk to that side of the car as often so I'm not sure how long it's been there. I can't feel on the other side as there is another panel on the other side so I don't know if it is rusted all the way inside.
View 12 RepliesMy drivers side windshield wiper is missing a band about 3" wide in the middle. I bought aftermarket blades but is still missing the same band.
View 4 RepliesWash the car today, unfortunately found the driver side doorsill start to have some rust, and luckily the rust only found at he driver side doorsill rest doorsill looks fine.
Don't know what to do now, get it painted? or just grease it will keep rust from spreading?
I just picked up an 01 V10 Limited 4x4 and one thing I noticed is the drivers side running board has a very soft spot right where I step to get in. It seems solid both forward and behind that area. Any suggestions for reinforcing the stock runingboards?
View 6 RepliesSo I've noticed a problem. When I go to lock my doors with the keyfob my drivers side door doesn't lock. Manually I can turn the key and lock it. Now what's weird is my drivers door will lock when I press the lock button on the inside of the door(the button on the handle). So I'm pretty sure the actuator isn't bad since the door will lock via the inside button, maybe I'm wrong though? Not really a super bad problem but annoying nonetheless.
View 4 RepliesSo, simple question. I have a squeaky driver side door.
I'm interested in some color matching door grease. I've always hated the black gunky door grease. Why? Cause I'm OCD. I saw on the MKVI R [on CW anyways] their door hinge grease was color matched.
If this is too absurd, any recommendations for removing/cleaning the grease currently on the door hinge and replacing it? It comes off as straight forward.