I guess this would be covered by either power train warranty or certified warranty? I also have axle inner boot leakage. I am going in tomorrow for DSG and fuel filter, going to have them look at these issues...should be fun ... oh yeah and head gasket might show signs of leakage......
Detailed pics in link..... [URL] .....
Just noticed something strange. Haven't opened the boot for a few days and We have had some really heavy rain but today, when I did open the boot water, poured out between the carpet on the inside of the boot and the metal. Has water in the actual boot or is there some drain holes I need to check.
View 7 RepliesWhat is the procedure for changing the passenger side boot on the power steering? I've read the Chilton repair manual, looks too easy.
View 6 RepliesI'm repainting my peeling shifter trim plate and replacing the shift boot with a new one. Lots of support available on removing the shifter and disassembling the trim plate, but no clear instructions on how to remove the boot from the knob. It looks like this inside:
How do I separate the boot from the knob to install a new boot? The only instructions I found showed a metal collar which is not the case in our cars.
I had an accident with my 2007 Hyundai Azera 3.8 Limited at the driver's side a couple of weeks ago. The frame bent a little bit from the left side. Took it to body shop/mechanic and was straightened back. The mechanic advice me to change the CV axle on the left side due to the CV boot coming off the axle. We bought a used CV axle from the junkyard and everything was fine until 2 days later when I made a wide left trun and I heard a cracking noise.
Immediately, I pulled over and AGAIN the CV Boot from the CV axle has popped out of the axle again and up until now when i drive I hear a cracking noise when turning to the left. Even without checking the car again, the mechanic is still suggesting its the axle I bought that I should buy another one... We also changed the hub in the process....before this problem occurred...
Here is the picture of how it looks now...
I was replacing the oil in the transfer case and came across this under the passenger side. Power steering rack seems to be leaking through the rubber boot, but I have not noticed anything on the garage floor in recent months...
Can the boot itself be replaced? I hate to think the whole system needs to be replaced.
2002 2wd, 4dr has a power steering fluid leak. I am losing fluid in the resevior and there is a mess at the bottom around the steering box, lines and sway bar and it's hard to find the origin. it is not leaking at rest with or without the engine running. What are the more common leak points in this system?
View 6 RepliesI am driving an accent crdi 2006. Facing some problem with power steering oil leakage.
View 1 RepliesOur 2009 Corolla S 5-spd is making a ticking sound like a CV joint is out, but the boots are fine, and the sound is only consistent when there's three fat people in it. With just me driving, I can hear it, but it's just an occasional pop when turning, nothing like the very consistent and recognizable click-click-click noise of a dying CV axle, which is exactly what it does when there's weight.
View 6 RepliesI have a 2003 Ford F150, 4x4, and I recently installed torsion bar leveling keys, i did not notice before i put the keys on, but while parked level, wheels straight, my wheels stand awkward, the bottom sticks out while the top is kinda sucked in, when i took a closer look, my inner axle shaft boot on my passenger side is busted and slinging all the grease out, what is the solution?
View 8 RepliesSo I've been noticing my power steering in the reservoir has been going down for quite some time. Now its more noticeable than ever. Just about a month ago I topped off the tank to the "max" line and now its at the "min" line. I also notice the fluid on the garage floor. I've always had a lot of grease (I assume the fluid) all around the body and under the reservoir under the hood. It seems to be leaking from the hose where it connects to the actual reservoir. Maybe the clamp is bad or something.
View 14 RepliesOK, I have developed a leak in the power steering hose that connects to the fluid reservoir (the smaller diameter hose). The dealer only sells this as an assembly (all the way to the pump, and very expensive). The hose is molded. Need to replace just this first hose section? AutoZone and several others I checked don't seem to have this (at least on line).
View 11 RepliesSo the other day I was changing the oil on the SF, and I noticed a glob of grease (fist sized) on the passenger side of the frame. After cleaning up the mess it appeared that the grease was coming from the inner CV boot on the passenger side. From my position under the SF I could not see any obvious crack in the boot, and I also squeezed the boot and ran my finger around it in each of the bellows. I still didn't find any rupture. I then began to wonder if the boot had slipped off of the base of the axle. I pushed and pulled on the boot and could not really budge it.
In full disclosure I did change the front struts 2 weeks prior. My only thought is maybe I pulled the boot off somehow during that job. If that was the case though wouldn't I be able to move/dislodge the boot now?
FWIW there is no noise coming from the passenger side that would indicate the CV joint is bad or on its way out.
1998 F-250LD 4X4 ... The outer boot is cracked, so I got a new one. Took the axle off, but cannot understand how to remove the boot. Where do I take the joint apart?
View 2 RepliesThe other day I started hearing a noise in first gear, and then this toy car sound got worse. I realized the power steering was low so I added more, now it leaks about half a bottle a day. I just wanted to know if its an expensive repair, how I can pinpoint the problem, and what the long-terms effects are if I leave the problem alone.
View 2 RepliesI have an 06 gs300 awd. My left front axle boot is torn wide open. I've called multiple parts stores, looked online. And I can't seem to find one anywhere but the dealer. I have found one for gs350. So my question is will that one work in my gs300? What is the part number from the dealer is different between 06 and 07?
View 5 Repliesjust found out about this a few days ago. It seems that the leak is between the fluid container and the tube. I just used some zipper to tighten up the connector. Where to buy this tube and the steering wheel fluid, and how much are they? My car is a LE V6 2007.
View 13 RepliesSo the big rubber hose attached to my power steering reservoir is leaking and my mechanic told me to replace it. I went to a couple of different Autozone stores and they both couldn't identify the correct dimensions of it. They told me to take it out and then bring it to them. This is very hard for me since this is my only car and how to pull the bottom bit of the hose out from whatever it's attached to.
I've measured the length to be about 2.4 feet but I'm not sure on how thick it is. I've taken a pic of the hose here:
I am getting what seems to be a leak from around the cv axle near the transmission on the passenger side. It only does it after driving and stops shortly after the car stops. How do I check the fluid on the automatic transmission.
View 3 RepliesJust checked out at 2003 V6 LE with 120k miles for $5500. Car seems to be in excellent mechanical condition but I did notice quite a significant power steering fluid leak, seems to be coming from the reservoir. I see that there are two hoses for about $80 each listed on Partsgeek.
Is this a common problem, can the clamps just be tightened, Could it be the reservoir it's self or even the pump too high a pressure?
Seems to be quite a lot of fluid running down the side of the car but after taking it for a test drive I didn't see any signs of it squirting out so perhaps it's a slow leak and been leaking for a while.
On my way to pick up my mother in law yesterday I noticed a strange whirring sound whilst at the traffic lights, thought that was a strange new sound anyway I guessed something was wrong so on arrival I noticed an oil like mark on the left hand side of the car on the wet drive. So it looks like I may have a corroded power steering line. Got the car booked in with the chap who does my vehicle repairs for me is this a difficult job on the V10?
View 6 Replies