Golf/GTI VI :: Metal Tapping Brake Pedal
May 17, 2012
So out of nowhere after about 20k miles, I am driving and start to feel what seems like something metal, tapping my brake pedal (felt like someone was tapping it lightly with a hammer). It clearly was not coming from inside of the car and was annoying, if you place your foot on the brake and "jiggle" the steering wheel you could feel it, as if something was loose. After looking I could not find anything on the inside or outside of the vehicle that seemed loose. I did not have to equip to jack the car up and get into the nitty gritty, but did what i could from the top.
Since I still have a warranty I took it in. Stealership calls about 2 hours later and says there is an obvious issue with my ABS. Then proceeds to tell me that my car is "heavily modified" (i have a twintake and hi-flo pipe) and they are basically trying to blame the issue on my intake. Because clearly that makes sense.
View 3 Replies
Advertisement
2012 Passat SEL ... I got new tires put on a few weeks ago and have a new rattle, sounds like glass tapping against glass or metal on metal. It only happens when I'm cruising around 65 mph. From where I am in the drivers seat, it sounds like it's coming from the drivers rear tire area or under/behind the center console/dash board. I know it's not a lot of info, but need to figure out what's going on.
View 1 Replies
I ease off the brake and i hear this rattle coming from my car, like metal on metal. But really high pitched like something got loose or something. Tick tick tick tick. So i give it gas and it goes away. Its only there if i brake and release the brake...So i get home and everything is normal. I go outside and move my car and there's the weird rattle again ...
View 21 Replies
Ever since i put tires and rims on the tread of my tires gives i little bit of vibration in the cab. Now i noticed at highway speeds mostly an annoying metal tapping noise from the second row captain chairs. What could be doing that out of the seats....
View 5 Replies
I've been hearing a metal on metal sound coming from the brakes. I checked the pads with the wheel on and they all looked good. The back were replaced before I bought the car back in October. Last night the brake warning light came on, so I brought to my local shop. Longer story short, the inner pad was completely worn out, but the outer's were good.
View 2 Replies
I swapped my fluid and ever since I did that my clutch and brake pedal are pulsing/vibrating only when I start the car. It almost feels like ABS pulsing but on both pedals and the car is obviously stationary.
I followed the procedure from the manual and did all 4 corners and slave.
Brakes work fine/clutch is fine...
I must have done something to upset the BRAKE system?
View 8 Replies
I own a stock 2010 golf with 22k miles on it. There seems to be a problem with brake feel. Brake pedal feels way too soft and there is way too much pedal travel for brakes to engage. Car won't start decelerating until pedal is pushed nearly 1/2 of its total travel length. However there seems no problem with stopping the car. On hard braking car stops well (with ABS). Another problem is brake feel isn't linear.
View 10 Replies
I picked my R up three weeks ago tomorrow. I took it in this morning because there has been brake noise from day one. The noise was a scraping, metal on metal sound that diminished a fair amount when the brakes were warm. I only got a very brief conversation with the service agent at the dealership this afternoon, and all he told me is that they had to order in new brakes. I don't know if it's just pads, or calipers or rotors or the whole deal! I'll get the whole scoop tomorrow.
View 5 Replies
For the past few months, pretty consistently, whenever I engage the clutch from full stop into first gear (it does it when starting in second gear too; and reverse) there is a pretty obnoxious and loud screeching noise that I would liken to a subway/train braking or just metal on metal grinding situation. When I took the car in to Douglas for an oil change and APR Stg 1 flash, they told me it's just the brakes being cold, etc. After driving the car some more, I really doubt that it's the brakes and I can reproduce this regularly by slowly releasing the clutch and get the noise usually just before the gear engages.
That car has just over 16K on the clock and has never been abused. The clutch pedal feels fine and there is no issue shifting into any of the gears other than the noise. No mods other than the APR Stage 1.
View 16 Replies
This morning on my way to work, pulling into the parking lot around 20mph. I hear a metal on metal grinding noise. (almost to the sound of a muffler dragging on the ground type noise). Then that disappears for a bit, hear a loud metal clunk then some high pitched sound. All within say 30 seconds. Definitely coming from the back, but can not tell from which side.
Things I've checked in the parking lot:
Nothing hanging low, exhaust seems in-tact
It doesn't look like the brake shields behind the rotors are bent or touching
Sounds still happening if on or off brakes , on or off throttle.
It seemed to happen only at lower speeds. Disappeared once I got up to 50mph
Just took it out for a drive, that loud metal clunk happened when I put it into reverse, drove around, no other sounds. I just don't have a warm fuzzy feeling that this will just disappear.
View 11 Replies
So, it snowed pretty good this morning and there was about 3-4 inches of snow on the ground. I pulled out of the driveway as usual (in reverse), I get to the end and I'm turning and I noticed a vibration like something was rubbing against the wheels, I thought maybe something to do with the snow and wheels lost traction or something. Then I continue driving and when I step on the brake moderately hard (normal braking), I get this vibration like something is stuck in the wheel well and the brake pedal vibrates. If I very gently press it, it doesn't happen. So i pulled over and check the wheel wells and rotors and nothing seems out of whack. Is this the ABS? The pedal shakes quite a bit.
View 18 Replies
I have a 2013 golf r with 12k miles and I remember the next day after racing it my brake petal started vibrating every time I step on it.
View 10 Replies
I was driving around today and had to hit the brakes really hard for the first time. ABS kicked in and during the ABS 'action' the brake pedal rapidly went to the floor. With each 'pump' the ABS made it felt like the pedal sunk slightly.
This was on dry pavement, a little gravelly / dirty and the car stopped rapidly, but just as I stopped the pedal was VERY close to the floor, and with just a touch more pressure it did in fact hit bottom.
Sounds to me like the ABS pump needs to be bled, is that right? Can I do that myself with a VAGCOM? I hate having the dealer do anything, even if it is their job. How to SAFELY confirm if cars does / does not do this as well?
View 8 Replies
A friend of mine recently had a VWR intake installed in his R along with HPA dogbone mount. After the installation he noticed a lot of vibration in his brake pedal. He then had the dogbone mount removed and the stock put back in thinking that the mount was causing the problem. After doing that he still had the vibrations in his brake pedal. He then brought the vehicle back to the dealership who did the install for him. They couldn't find what was causing the problem. He later found out that his VWR intake was resting directly on top of the brake reservoir. Noticed vibrations in the brake pedal or notice that it is resting on top of brake reservoir? Can his intake be missing a bracket or installed improperly?
View 5 Replies
Ok, so I have a 1992 GMC Suburban with a 350 TBI with a full dual exhaust and long pipe headers. The problem I'm having is that there is a tapping noise that comes from the driver's side of the engine when you push the gas pedal down. It only makes the noise when you push the pedal down more than about a quarter of an inch. I have tested it down hill with the transmission out of overdrive and the rpms up and there is no tapping. I'm thinking it might be pre-ignition in one of the cylinders but how to test for it other than just disconnecting plug wires one at a time until it stops. Much more I don't know what would be causing it to happen if that is the problem.
View 10 Replies
This morning I could feel vibration in both the clutch pedal and the brake pedal under normal acceleration. This just happened and is significant enough to make me feel something is wrong. Car has about 5700 miles on it. To be honest, I have never liked this transmission and have zero confidence in it. It feels completely weak, loose, soft, and lacks any feedback except unbelievably notchy shifting. Maybe it's my DieselGeek. I've already had to tighten/adjust it twice in ~2000 miles.
I am not resting my foot on the pedals during acceleration. I can feel the vibration as I go to engage the clutch/apply brakes.
View 6 Replies
2010 TDI DSG 25k miles. Something I just noticed when I was coming off cruise control I went to cancel cruise by stepping on the brake pedal and noticed it vibrating quite a bit (kind of tickled). I tried experimenting with it on the way to work the next day. Seems to happen when the car is under power not coasting. Tires are at 38psi no vibration through the steering wheel or seat, car tracks straight.
My previous two cars were Subaru's WRX and Legacy GT and boxer motors shake a lot but I never noticed a vibration. This could have been happening with the Golf for a while and I just noticed now. I don't think it's the rotors as I was feeling around under the brake pedal with my left foot while accelerating with my right and definitely vibrating. I brought it to the dealer and they replaced the brake pedal carrier bearing/pin and it's a little better but still vibrating. Is this normal?
View 9 Replies
So after my first track day i bleed my brakes and they felt great for about 3 days, but then the pedal feel started to deteriorate back to its old crappy feel where nothing happens until its depressed to the same depth as the gas pedal...
In other words, I have about a solid 1.5 inches of travel with nothing happening.
Fixes? Bleeding procedure? I heard we have to prime our abs pumps? yes no?
View 5 Replies
Ok so the brakes are new and for some reason at higher speeds, i feel the pedal vibrate as if its a bad rotor....gonna grease the pins and pads this weekend to see if theres a diff. But what gets me is that it Squeals as if the pads are shot as well in the front.
The title problem is that when i brake its smooth ish until 10 MPH where then it feels like the pedal goes to MUSH and i hear an ERRRRR sound as the car comes to a stop. it almost sounds like ABS/ESP while im sliding to a stop in the snow.... Expect there's no snow.
I don't have a high tech phone to record the noise. It never used to make this sound and i feel there is an actual problem.
I am gonna try flushing the brake system with new fluid, take the front brakes off and re grease everything. yesterday seemed to be the day my dash decides to light up like a Christmas tree...
View 5 Replies
I just finished the install of a stop tech BBK on my Jsw and it seems I have two problems:
1) brake pad signal comes on when I start my car and
2) car wont lock (though it is running fine).
View 1 Replies
I've had my R32 for a week now and I'm starting to develop some questions. This is one that I haven't been able to find an answer to by searching, so here it goes. When the ABS is active (coming to a hard stop on snow and ice, for example), I get a really strange almost "crunchy" feel through the brake pedal. ABS I've experienced on other cars hasn't been this harsh so I'm not sure if it's normal on these.
View 4 Replies
