GTI 337/20th Anniversary :: Clutch Stuck To The Floor On The Highway
Nov 7, 2010
50k Miles on my clutch. Was driving a couple weeks ago on the highway and clutch stuck to the floor. At first I thought it was my Slave cylinder. Got the trans out this weekend to find the mess (below) inside my bell housing. Obviously need a new clutch now and will still replace the slave while I am in there.
Cars setup is around 375ish whp. I know I could spend 1300 bucks and call it a day for a clutch master or south bend but was seeing if there is a cheaper alternative.
Also If I were to buy an OEM clutch or an upgraded one that was not rated for up to 400~whp would it drive and pull the same as a fully upgraded one just not last as long?
6 Speed ...
View 3 Replies
Advertisement
Just got in my car and the clutch went to the floor and stayed there when I stepped on it. What are the steps to diagnose this problem? I'm assuming my slave cylinder went kaput!
View 11 Replies
Coming to a stop, clutch pedal just lost all pressure. I can bring it back up, but even the slightest touch will send it to the floor again. I get the brake warning light on the dash. What could be causing this?
View 7 Replies
The transmission is a Six-speed MQ350 transmission in an MKIV 337 GTI.
I was driving last week and ran over a large snow chunk, heard it hit the underside of my car. A mile down the road my foot is resting on the clutch pedal at a stop light, and the clutch slowly went to the floor. It was still drivable, barely. The clutch came about an inch off the floorboard, but still caught. So i pull into the parking lot ahead of me, and was barely able to move the shifter left to right nor would the shifter go into gear. There were no fluids coming from under the car, nor could i see anything that looked wrong. I turned off, back on again. nothing. I then pulled the clutch pedal up from the floor and it went back to normal. Everything seems normal now, but the shifter seemed a little sticky yesterday from left to right.
View 6 Replies
So last night I was driving home from work, and at a red light while i was waiting to go i had my clutch down when light turned green i tried to go and noticed i could not put it in gear and that my clutch pedal was stuck in place. i didn't know what to do so I checked my shifter plate everything looked fine so went to look at the pedal and i pulled it forward and it came lose. I started it up everything was fine and back to order. This morning going to work same thing happened again, I don't know what is going on and what could be the cause?
View 5 Replies
So the other day i found a lake on the floor behind the drivers seat. Everywhere else is dry but there. A few days prior I got tapped by a ram enough to crack my rear bumper on the drivers side. I am wondering if the water came in through the crack? Everything is dry though under the spare tire . I know there's vents on the sides behind the bumper, but I don't think I got hit hard enough or at the right angle to bust a seal on the vents. I also blew air through the sunroof drains and they were all clear. Windows were closed and all doors were closed when it rained.
View 8 Replies
I noticed that my floors were wet. To the touch they weren't soaked or even a puddle. It was just a damp feeling. I took a moisture reader to the carpet and sure enough I was right. I used a space heater to dry out my carpet. I had it all dry and now some moisture is back and where it gets tricky. The floors that are wet, are in the middle of the foot well in the rear of the car. When I use the moisture reader, I try and follow a leak along the carpet but I can't not for the life of me figure where this water is coming in at. After a lot of teams each most issues seem to be leaky sun roof or leaky seal on windshield. I've cut the nipples off of my sun roof drains already. What can cause this water? have any way to test where it maybe leaking from? In the footwells there are frame bumps and the water is most wet in that location.
View 8 Replies
So over the weekend my clutch pedal stuck to the floor 2 times and would not come all the way up on several occasions. It has since then stopped doing it. I am wondering if I should bleed my clutch or not. Flush and change fluid?
Just concerned it may turn worse.
View 16 Replies
Facts: 1999 Vw passat 1.8t
1 year ago, clutch pedal would not come up off the floor, no life in the pedal.
Problem: Clutch master cylinder, replaced.
6 months ago, clutch finally went bad. Took car to clutch shop, replaced clutch kit(found out after i payed that they only turned the dual-mass flywheel... ). Get car from clutch shop, the clutch pedal came up only 2-3 inches off the floor by itself but you could lift the pedal with your hand or foot, and it would come back up all the way, but it was life-less. It was not pulling fluid in. It was catching extremely low. I called the shop, they said that it was just because it was a new clutch and it would get better. I didn't believe them.
Two days ago, I got into my car and couldn't get it into gear. Clutch pedal would go down with the same amount of force as before. Took it back to the clutch shop and explained the history with the clutch master and then them doing the clutch kit. They said it wasn't bleeding properly and they're not sure if its going to have problems again. Car is working now, but I am concerned that it will have similar problems again.
The tech who fixed it said he pumped fluid into it extremely hard, and that's what made the pedal come up all the way (no longer stops 2 inches off the floor) and its going into gear just fine now. What the problem might have been? Block in the hydraulic lines? If this is the case, does forcing fluid through it fix it?
View 2 Replies
1998 Passat 1.8T FWD. My clutch pedal is stuck to the floor and wont spring back up. I can't seem to find the little tank to check the clutch fluid. I have heard the it uses the same tank as the brake lines do, but the tank that holds the brake fluid is full. Can it be the slave cylinder is gone? or just got a air pocket in the line?
View 1 Replies
So I got in to my car today to goto school and noticed it smelled kinda musky. I happened to look behind the passenger side seat and there was 3in. of water on the floor so i looked up at the sunroof and there wasn't any stains or anything from water as well as the doors windows everything... It's the strangest thing I've seen the only thing wet is on the floor...
View 4 Replies
Leaks in passenger side floor during a big day of rain? my floor mat was SOAKED, and i think i its coming from some area going up on the right side of the glove compartment, doesn't look like its the door, but perhaps the corner outside where the windshield meets the hood? I also believe I may have leaky seals on my left rear window.
View 4 Replies
I have a 2003 Jetta GLI. Thus morning driving into work my clutch pedal stuck to the floor. I was able to pull it back it and make it to work, but when i got to work i noticed fluid dripping from underneath my car.
View 4 Replies
I've been driving manual 12 years, all my driving life, and been in 10+ manual vehicles during that time, including a 10+ year stint in a 1.8T Passat with a 5-speed.
In all that time, and all those experiences, I've never replaced a clutch, damaged a clutch, or had one problem. In fact, I consider myself a very good operator of the manual transmission.
This is preface to my current situation. 2009 Tiguan (early build) 2.0T 6M, driving at 57mph in 6th gear - downshift to 4th to pass a truck and WHAM. Grinding, confusion, and then the clutch pedal stuck straight to the floor. Glide to a stop on the side of the bayou road.
Totally immobile vehicle. Impossible to shift into gear, or get the pedal off the floor except by pulling. Smell of acrid smoke.
VW dealership says "we're doing a courtesy warranty repair" on the clutch, flywheel and bearings, as if it's my fault. Impossible. This is a mechanical defect if I ever saw one.
View 9 Replies
I was driving the other day and accelerated in 5th and the car stuttered before finally going- I got the flashing CEL. I figured that the car was misfiring and that a coilpack change was the culprit. All my coilpacks are fine and the sparkplugs look good as well. CEL hasn't come back, but the car just feels like it doesn't want to go right away when if i give it some gas when I'm going about 55-65 MPH.
Other guesses would be there is a fuel cut somewhere and that may be causing it?
View 6 Replies
2004.5 GLI 1.8t. Its got 70k on the clock, its a Cali car, runs like a charm BUT... For some reason when it gets warmed up, it makes a knocking noise by the pass side floor board?
Its just at idle, i mean i can give it a little rev, and it doesn't seem to get worse so that eliminates bottom end or head... so???? Ive read some post on here that say... its nothing... just ignore it... but idk.
Like I said its just at idle and it sounds like its coming from the pass floorboard.... I left it running and popped the hood and couldn't hear it.
View 10 Replies
So over the past couple months when driving on the highway I would notice that sometimes my car would lose all power and slowly coast to a stop, but then the power comes back on and I'm off after a few seconds. It happened again today and I notice when I do hit the gas when it decides not to accelerate my boost gauge shows that there is vacuum building up in the engine. It just doesn't make sense to me. Would my car be getting thrown into a limp mode? Or is it something to do with fueling?
View 4 Replies
I have a 2003 20th anniversary edition GTI. Yesterday I noticed my car started shaking when I was driving on the highway. The only thing I can think of that I did was run into a snow bank during the snowstorm. What is causing my car to shake?
View 2 Replies
Having issues with turning over but no start, sometimes takes up to five turns to start up, and hesitation on hwy in 6th gear. Fuel problem im pretty sure.
View 1 Replies
98 Jetta TDI hydraulic system ... We just received this vehicle from my mother in law, who is not driving any more. It's a cream puff--79,000 miles, beautiful condition. Problem is the clutch engages lower and lower to the floor, and eventually the shifter gets stuck in gear. The brake pedal slowly sinks to the floor when at stops on hills. Our mechanic tells us these two are connected because both the clutch and brake run off the same hydraulic system.
1st time he said the fluid was filthy, and he emptied the system and put in clean fluid. Worked for a little while and then we were back where we started. Second time he replaced a couple parts on the clutch, replaced this fluid, and this time it ran like a dream for a little over a month. Then the problem just returned. Again he says the fluid is filthy, and now we are looking at replacing the master cylinder and again changing the fluid. The theory behind why this is happening is that my mother in law let the car sit for half a year before passing it on to us. She didn't do much driving the 6 months before that either. I've done research, and this doesn't appear to be a common problem by any means on these cars.
View 2 Replies
I recently got the GTI 1.8L 337 with 64,000 on it. It had been sitting, with daily start-ups, for about 8 months until the ALT was replaced. I've been driving it for a month with no problems until last week. At first I noticed the clutch pedal would pause on the way up for a split second then tap the bottom of my shoe. I thought maybe it needed adjustment but nothing serious. A few days ago the pedal would stick at 3/4 of the way up, and stay there most of the time unless I raised it with my foot, till the car warmed up a bit. Yesterday and today the pedal started to stick 1/4 of the way up, unless raised with my foot, at the morning start-up and will only come up 3/4 when warm. It also wont go into reverse at initial start-up until it gets really warmed up, shifting into other gears is fine. I've had no problems or real sounds shifting into any other gears, though out of 1st has been a little jumpy.
View 3 Replies
