Ford Transmission :: Overheating And Boiling Over - Trans Fluid In Coolant
Jun 24, 2015
I have a '99 E350 that sat for a winter. When I started it up, it appeared to be overheating and boiling over. I didn't have time to mess with it, and it sat for another year. Today I tried to figure out the issue and determined that I have trains fluid in the coolant. Pulling the trans dipstick revealed a white milkiness on the dipstick, so I'm guessing the trans cooler/radiator failed and the two fluids have mixed.
My question is, is the transmission salvageable? The van has not been driven in this condition, so I'm hoping there is hope. Obviously, flushing both systems (multiple times) is in order, along with a new radiator. But is there any hope for the transmission? I'd hate to spend the money flushing it all multiple times if it is a lost cause.
View 13 Replies
Advertisement
My son has a 94 Escort LX and this weekend he noticed that when he'd stop the car he could hear the coolant boiling. The car temp gauge never registered too hot, and it never lost coolant. We checked the oil and it is not milky.
About 2 years ago it got a new water pump. Last summer a new thermostat, and then earlier this year a new radiator.
Last weekend he was stuck in a huge traffic jam. (4.5 hours for a normally 45 min. drive). I'm wondering if that could have weakened the radiator cap. He's picking up a new one today, but wonder if there is something else we should check?
View 19 Replies
I have a 1992 Toyota Celica I think I may have overheating problems every time i stop after driving a little while i can hear a boiling noise from where you put your coolant in and when i open it there is steam coming from the black hose that goes in it.
The funny thing is when i am driving the temperature gauge stays at 1/2 way and never passes it, also sometimes when i stop green and a bit clear liquid leaks on the ground on the side where the battery is.
View 4 Replies
I have 2000 ford f350 7.3 diesel. (Approx 95,000 mi). Tried to tow heavy wood chipper out of soft backyard, truck on angle because of grade. Put in low and second for better traction. After somewhat high engine rpm tires started to move me ahead until spinning occurred upon which I would immediately stop and try again (slowly). Next thing I know trans fluid on ground and truck steaming. Let cool down, refilled trans oil to proper level, unhooked heavy load. Fluid NO longer leaking, drive home fine (towing nothing). What are my next steps? Very concerned I've done grave damage!?
View 9 Replies
I am adding an auxiliary trans fluid cooler to my C-6 in my F-250. Should the fluid route thru the aux cooler first then the stock rad cooler, or thru radiator cooler to aux cooler? Which stock hard line is fluid FROM the C-6 (HOT), and which is the return line (cold)?
Vehicle is 78 F-250 4x4 crewcab, 400/C-6
View 14 Replies
I am going over this new truck I brought home not long ago. and I haven't picked a service manual up yet but I figure since I've owned manual tranny's before it's pretty obvious on the basics.
The fill and drain plugs are on the same side correct? I found them on the passenger side, figured the top one was the fill plug.. So I remove the plug and I get bathed in gear oil to the armpit and topcoated the driveway; Geesh the smell hasn't changed one bit.. I'm guessing the PO topped the fluid to the top of this transmission. Because I expected to stick my finger in the hole and either feel fluid or not. Not get a bath Unless I removed the wrong square plug.. I don't think I did.
What seals can I expect to be blown because of this if any? I haven't put many miles on it since I bought; it maybe a 100 total. I have no idea though how long it was driven though before I picked it up.
View 3 Replies
I've got a 7.3 tranny that has had ELC Coolant and water mixed in with tranny fluid because of a bad radiator. I drained the fluid from the tranny a week ago and when I pulled off the pan today there is still junk in there. I'm planning on putting in a new filter, gasket and Mercon V but how do I clean the old stuff out of there? Picture.....
View 14 Replies
2000 Excursion 7.3 unk transmission
Quick run down on the situation. It has been terribly hot here bumping 105 degrees. I was told by a man he could see fluid leaking and it was trans fluid. I checked it and filled it up and got it to the shop.
Next day they said it was not leaking and that it probably overheated. They recommended an after market trans cooler. They put it in and off I went. 60 miles later I got fluid all over the rear of the truck. I filled it up again and got it home. Shop says I need a new trans.
View 9 Replies
I've been running type F since I bought the truck about 30k miles ago. The dipstick says to run M2C138cj which I recently found out is NOT type F! I hope I haven't destroyed the clutches. How I can get all of the old fluid out. Also I can't find any transmission fluid with the ford M2c138cj spec is Dex-Merc III backwards compatible?
View 2 Replies
My 1999 7.3l Disel 4x4 transmission quit on me the other day. No forward or reverse. Got towed to my regular repair shop, and they are treating the transmission as a black box and recommending total replacement. The diagnostics they performed were to make sure it was shifting, and that indeed it wasn't going forward or reverse. They drained the fluid and said "it's pitch black" and said it had to be completely replaced.
Fluid level was OK, and it wasn't hot. I was driving along, and merging onto the highway. It downshifted, shuddred, and nadda. Free rev. I coasted to the next exit and into a parking lot. Verified that it was shifting, checked Rev and all forwards. It wouldn't shift into 4W, and 1-2 also wouldn't move.
I'm trying to figure out what might have happened... and if it's worth trying to have the truck towed to a transmission shop and have them diagnose and rebuild, vs just getting a remanufactured transmission. None of the local wreckers have any used transmissions, and the cost between a reman and a used is pretty negligible...
Not sure what the symptoms points to for exact failure mode, be it the torque converter, pump, input shaft, etc... I've never had an automatic transmission apart before, but built plenty of motors and am a machinist by trade. My preference is to try and root cause the failure...
View 1 Replies
I pull a 23 ft travel trailer with my 99 f150 4.6l and so I decided I needed a trans cooler just to be safe towing in the dead of summer. I got a few quotes for right under 300. I couldn't justify the labor cost considering the cooler was under 100. So I made up my mind and decided to do it myself. I watched a bunch of videos for other makes and models but couldn't find nothing on my particular model year truck. I finished it today and I realized that my transmission fluid fluid is very dark. I have never serviced the transmission ever not even a drain and refill. I am going on my trip in about 7 days, and was wondering if I should even mess with anything to do with the transmission fluid. I put about a half quart of new fluid to top it off after the install of the transcooler but now I am worried that my transmission may not be in the best shape. Truck shifts fine as far as I concerned and acceleration is ok, so I am hesitant to do anything to it.
View 3 Replies
Today, the air conditioning stopped working in my 2003 Elantra. Just stopped blowing cold air. Then the engine thermometer kept on climbing. When I pulled over home, I lifted the hood and heard a lot of bubbling and gurgling sounds, and coolant fluid leaked out underneath the car.
What could be the cause of this? When I let the car stay for a while, the AC did kick back on, but only for a few moments and the thermometer kept on climbing again until I turned the car off. The fan is blowing, I can hear it, but it is obviously not cooling the engine off appropriately.
View 6 Replies
2001 Jeep Cherokee sport ... Just bought this Jeep with 145K miles. Had radiator and all hoses replaced. The overflow tank is boiling over but the engine is not overheating. Safe to drive? What should I be checking for?
View 13 Replies
My friend's '04 Sebring is still overheating even after these steps have been taken: heads were warped -- had a professional shave them down and rebuild engine; new radiator; new thermostat; then removed thermostat to try this way, and bled the system for air bubbles (more than once).
The car can run about five miles - then bubbling/boiling in the water recovery tank. The mechanic said there is a small crack on the water reservoir (a small plastic box) near where the bolt connects to the engine. Could this crack affect the pressure of the system and cause this overheating?
View 2 Replies
Today on a little road trip about 250 miles everything was going well then towards the end i was about to arrive when the temp gauge rose about a quarter inch from where it normally runs and i stopped at a gas station and all my coolant started rushing and boiling out of the top of my reservoir, I let the truck cool down and removed the cap and i lost all the coolant in the reservoir i bought two jugs and filled it back up and fired her up and the temp is back to normal and was not leaking from anywhere.
Hit the road again for the rest of the roughly 35 miles of the trip to my camp no smoking or lack of power then through a little sand and mud and she stayed cool. I was towing a small single axle utility trailer with a atv and was going 65-70 whole way. Truck has never had a problem with anything in the year and a half i have had it. Just hit 250k. What could this have been? Its holding all the coolant its been in there for a couple hours now without leaking. Thermostat maybe stuck for a second? Or a air bubble?
View 14 Replies
Tranny fluid spews out pretty good underneath. Is it likely a broken hose? Where do I start?
View 3 Replies
I cannot find the transmission dipstick to check the trans fluid? I looked in the owners manual also and I can't find it.
View 14 Replies
Have some issues with my power steering pump. When I purchased the car i discovered it had brown fluid in it. Replaced it with green type and tough the pump had taken no damages from it. Did a track day with slicks (Toyo R888) and got problems with fluid boiling and loss off power in hard cornering.
My first thought was that the pump was damages by the wrong fluid. Before I got around replacing it the pump started making more and more whining sounds while driving on normal road with road tires.
Therefor I replaced the pump but the sound still continues. I changes the belt tensioner as well since the bearing could cause some issues like this as well. But the pump still struggle on normal road usage.
Could the steering rack be damaged with some internal leakage from the wrong fluid on it when purchased? I run DLI engine mounts, I can't see how but would that affect the sound from the pump?
Could there be any bearing on the belt (water pump/ac/alternator?) causing this issue? When running idle the belt runs fine with out any typical shot bearing sound.
View 2 Replies
Long story short, I got a 2001.5 1.8t M5 Passat with 63k miles 2 weeks ago.
This weekend I was driving around and pulled into the driveway and noticed the coolant was boiling in the coolant reservoir. It also looked like there was some oil in the reservoir. Take it to the shop, turns out that the plastic impeller on the water pump broke at 64k miles. This is wierd because the car never actually overheated. The mechanic doesn't think that the head gasket is blown or i have a cracked/warped head because the car still runs fine. He suggests I replace the water pump, timing belt, coolant reservoir, thermostat and obviously flush the coolant. I go ahead with the repair since its almost time for the TB anyway.
After bending over and taking it from the shop on a timing belt and water pump repair, I think I am all good. Today I open everything up after a few days of driving around just to check up on stuff. I open the coolant reservoir and there is telltale signs of oil in the coolant. Now i think this was an issue before the water pump went. Searching the archives I see that the oil cooler is a common failure. This could have also contributed to the failure of the water pump and maybe the thermostat, I don't know.
So instead of bending over for the mechanic for a second time in a week , I think I'm going to replace the oil cooler and flush the coolant system again and change the oil myself. Poked around looking at the oil cooler and it seems as if there is the slightest sign of an oil leak on the outside, which could mean there is a leak inside. I don't have compressed air so I'm not sure how I can test the oil cooler for leaks.
I am thinking i need:
-Oil cooler (some suggest S4, some suggest TDI one?)
-Oil cooler gasket
-Feed and return lines
-Hose clamps
-g12 coolant
-Oil filter
-Synthetic oil
Should I replace the upper and lower radiator hoses while I've got the coolant out? What else should I replace while the coolant is out. I see people suggest flushing the system several times. Should i use G12 everytime or can I just use water to flush until its clean and fill with G12?
View 3 Replies
been working on my passat for the last year oil cooler went bad and also my CCM fried. Anyways got the car running good or so i thought drove the car up the road today and my coolant sounds like it's boiling inside the reservoir.
View 11 Replies
2.7 Power Steering Fluid boiling/foaming leaking out a reservoir cap!
1) Recently had Timing Belt/Water Pump and spark plugs/wires replaced.
2) Issue started immediately after.
3) Removed most of old PS fluid, cleaned out reservoir w/brake cleaner. NOTE: nothing appeared to be clogging reservoir. Refilled with new PS fluid. Repeated these steps a second time. This appeared to immediately resolve the issues for several weeks.
4) Now the power steering is getting rough and noisy again. Also, the PS reservoir is leaking out of the cap worse than before. It looks like the fluid may be "boiling", but it is definitely foaming up pretty badly.
What my issue(s) may be?
View 4 Replies
