So I was going to get the truck washed, but 2 blocks down the road smoke out of the engine bay.
Pulled over popped the hood and the alternator is on fire. Extinguished it self out but the burnt electrical smell.....sheesh..
Anyways, could I potentially drive the truck to the dealer, or will it catch on fire again????
I have a 2000 Ford F-350 V10 Triton that is currently not running. It all started when I was going to work at 7:00am it just shut off in the middle of the road. I had someone to take out of the road and found out one of the fuses had blown. It was replaced and not even a mile down the road it died again, luckily next to Orielly's. They came out and did a test and found out it was coil 10. I purchased and installed a new one and went down the road only to have it die again. I replaced the fuse again, and went back to Oriellys and just as I was backing into the parking spot it died, this time smoke coming from under the hood. The brand new coil had caught on fire but I extinguished the flame and got the coil unplugged before any damage happened. Replaced the same coil and it ran fine until I got home, let it idle and it was fine. Then, two days later I started it and it died, again smoke coming from under the hood but no flames or fire. Now cylinder 10 does not fire any more. What the cause is?
View 5 RepliesI trying to see if this is something that is a easy fix or mayor work. Leak coming from that metal housing behind alternator. Does this housing came off? or do I need to take out the intake out? .
View 8 RepliesI have a 2006 f-250 powerstroke with 97000 on it egr delete exhaust and a h and s xrt pro on it. The pickup will always start when the engine and oil is cool, but once i run it for a while it and the oil gets warm it wont start back up again. I then have to leave it sit for a while and it will start. The engine just cranks but does not fire. I have replaced the dummy plugs on both sides and all the injector o rings on the passenger side. Some mechanic friends of min have had same problemed 6.0 liters and replaced these and it has fixed the problems I do not think it my high pressure pump.
View 2 RepliesNeed to diagnose my truck issues. On my 2002 F250 V10, when I try to start it, the engine just cranks and cranks and cranks with no fire or even hint if starting. I am not sure if it has no spark or isn't getting any fuel. I just replaced all ten spark plugs and coils less than 500 miles ago. I want to perform the fix myself, but I need to get the problem diagnose the issue first.
View 8 Replies2001 F250 5.4 with 160K miles. My wife "borrowed" my truck as she drove away, I saw white smoke coming out of the tailpipe. The kind you see in cold weather. Its was 75 degree in Texas this morning, so what could that be? There is antifreeze in the reservoir and I recently changed the oil and there was no water in it.
View 5 RepliesWent to run errands today, and noticed a slight hitch in the engine cranking... I'm on a brand new battery that isn't even a year old, so it seemed a bit odd. After running the first errand, the hitch in the cranking got a lot bigger and I noticed the voltmeter was reading lower than normal. In addition, lights, HVAC motor, radio, and even brake lights would move the needle. To me this says my alternator isn't working...at all.
View 5 RepliesI recently bought a 2001 f-350 xl 4 door with the 8 foot box it has the 5.4L triton v8. I was heading to a job up in northern Alberta about 10 hours away from where I live. On the drive I lost control of the truck on some black ice I was doing about 50 miles I went into the ditch but nothing crazy drove right out after. Now my truck won't do over 30 mph the engine starts to sputter and back fire I loose all my power, what's going on. At idle she revs fine but as soon as I put her into drive it's like she wants to die what can it be?
View 6 RepliesI have a 2004 F250 with 180K miles on it. About a year ago my truck would smoke pretty bad so I got on here and found I needed to take my FICM off and do some touch up soldering on it in a few places. Did that and everything has been fine until this past weekend when I noticed a little bit of whiteish smoke. Could it be the FICM again or something else. still have power and all gauges are normal. What to check next. Also, I do not have a scangauge, just the stock gauges.
View 11 RepliesI putting a bit newer engine in my truck. from what I know there have been few changes in the middle of 1999. Do I need to replace the computers too or are they the same. what about the wiring harness.
My truck : 1999 (11/1998 production date) 7.3, zf6 trans, 1 alternator, 315k
Donor truck : 2001 7.3, zf6, dual alternator, 110k
My Uncle has a 1999 F250 with 260K miles. Engine, fuel and exhaust systems have never been touched. Saturday he pulled his 26 foot horse trailer throughout WA with no problems. Sunday he went to take the truck to town and noticed that he suddenly had a lack of power, and some smoke (possibly blue-ish) coming from the exhaust. He has been told "injectors" by a couple people, "turbo" by some, and "injector harness/valve cover gasket" by others.
View 3 RepliesOur 2009 F-250 in our signature with 53,000 miles on it recently had a transmission episode that has me concerned. We were towing our fifth-wheel camper which weighs around 9000 lbs. We were nearly home on a 275 mile trip. All interstate at speeds of no more than 67 MPH. As I was in the process of exiting the interstate on the last 12 miles of our journey I noticed some smoke coming from underneath the truck. I immediately stopped and got under the truck and noticed transmission fluid running down from the top of the transmission and dripping onto the crossover exhaust pipe.
I let the truck idle for several minutes and it seemed to stop dripping fluid, or at least it had slowed considerably. I took off again being very careful not to gas it up at all, if fact I was very light footed with it from there on home. The ScanGauge II showed the transmission temp. had never got above 186 all the way home and it was at about 185 at the time I saw the smoke. The ambient temperature was around 90 and the truck had not labored at all on the way home. It would do the usual down shifting at overpasses but since I installed the 4.30 gears it doesn't do all that much shifting with the cruise control set on around 65-66 MPH.
I couldn't see where the oil was coming from but it was toward the top of the transmission. The transmission acted perfectly normal in every way even at the time of the dripping.
As I said, I took it plenty easy all the remaining 12 miles home and the tranny temp. dropped down to around 181. I parked the truck and camper on our asphalt driveway and saw no sign of drippage after it was parked. I fired the truck up the morning after this incident and drove it pulling the camper until the transmission temp. got to 185 and came home and parked it on the asphalt again and saw no signs of any leakage.
I checked the transmission fluid level per the instructions in the owners manual and it appeared to be right up to full. I don't believe it was over full. It smelled like it was new without a hint of any burnt odor. I bought the truck with 31,000 miles on it and had the dealer at which I purchased it change the transmission fluid at that time so it should be in very good condition.
I am going into a very busy time with this truck and can't chance any down time if it can be avoided. According to the research I did at the time I purchased this truck the automatic transmissions Ford used in the 2009 F-250 are pretty much bullet proof if maintained properly and not overly abused. This one has been well maintained and I've NEVER abused it. I wanted a manual trans. at the time I bought this unit but could not find one anywhere. I'm not a big slush-a-matic fan and I sincerely hope this one doesn't make me realize my long standing fear of slush-a-matic transmissions.
My truck is a 2000 7.3 doesn't smoke on start up but once it gets to temperature it does. I'm not going through any antifreeze, just oil and it's coming out the exhaust. The truck still runs great starts right up every morning without being plugged in. Any opinions?
View 3 RepliesI have an 04 F250, stock. Two times within the last week I have noticed whiteish smoke coming out of the tailpipe and a diesel smell. Could this be the glow plugs going out and not burning the fuel, I have not changed them since owning the truck or something else.
View 14 RepliesI have a 2002 ford f350 triton 5.4 V8. I just put front brake pads on my truck today. Started driving around and i could smell burning brakes. Stopped and alot of smoke was coming from my brakes on my front passenger side but nothing from the front drivers side. Replaced all the brake pads on the front. What is making them so hot?
View 8 RepliesTruck blows smoke like a blown NASCAR engine occasionally when pulling heavy load....pull over, cool off and resume driving. Its as if it never happened. All fluid levels are in range and truck drives fine minus load. My last f350 5.4 did same thing at about 200k miles. My local ford dealer tells me I'm the only guy on earth this Has happened to.
View 8 Replies1999 7.3 diesel 150K miles.
Over the winter, it sits in my driveway. I keep it plugged in and start it once a week. Lately when I start it, it cranks over and over several times but will not fire up. I stop cranking, wait a couple of seconds and try again and it will then fire right up. After warming up it everything was fine.
Now that it has warmed up outside, it still requires the cranking, stop and trying again but now even when the engine is hot, I have to do this. What is going on?
Got my 240 amp alternator in and had all new 1/0 GA battery cables with a 250amp fuse in line made to do all new lines. I started tonight and found a small line going from the alt connector down the power line to a fuseible link (fuse) all in the power line
I wanna do away with the main 4 ga alt wire but obviously I can't do anything with that line going to the plug. Can I put a connector on it and wire that into the one side of the 250amp fuse.
The only other option is to add a wire to beef up the stock line ....
The V10 in my service truck took the long slow ride. I located and am in the middle of replacing said engine. My question is, how difficult would it be to install a second alternator in this truck, considering I have it torn down for replacement?
It a 2000 F350 with a V10. I'm looking for more power as I have mounted on the Knaphiede service body a IMT 1015 crane, 3200 lb capacity. I would like to install a power inverter to be able to run an air compressor in the field.
Am I looking for a new harness? Etc?
I have had this whining noise that I'm not sure what it is. It sounds like its comin from the alternator area. There are three symptoms that are confusing me though, 1st is I only hear this whine as the weather starts getting colder and the colder it is the louder it is. 2nd is it only happens around 1800rpms like when it's getting ready to shift to the next gear. I can get it to whine when I'm parked and bringing the rpms up. 3rd is after 10-15 minutes when the truck is warmed up - no more whine. The truck is used very little duing the summer and I had this whine all winter last year. Alternator appears to be working fine and I do plow a few driveways every storm. Money is tight so I don't want to replace the Alternator an find it wasn't the problem.
View 3 RepliesMy trouble is that the alternator light on my 2004 F-250 Diesel began to come on occasionally, but never constant. Taking in the fact that it was still the original alternator, and over 70,000 miles, I figured it was time for a new one. I installed the new one and after two days the light came on again. I tested the alternator and it read 13.84 volts while running. With the engine shut off, I had 12.59, and 12.6 volts at the batteries. What may be my problem? Diesel down.
View 8 Replies